Husqvarna HUV 4213-G - Manuals

Page 3 - NOTICE

Husqvarna Forest and Garden 7349 Statesville Rd. Charlotte, NC 28269 USA www.usa.husqvarna.com/huv 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 1 NOTICE The Husqvarna® Limited Two Year Warranty for 2007 Transportation and Utility Vehicles and California Emis-sion Control Warranty Statement appe...

Page 4 - FOREWORD

Page 2 2007 HUV4213 Gasoline Vehicle Owner’s Manual FOREWORD Thank you for choosing Husqvarna, a world leader in outdoor products. You have chosen the finest utilityvehicle on the market. Please protect your investment and ensure that your Husqvarna vehicle provides yearsof reliable, superior perfor...

Page 5 - TABLE OF CONTENTS

2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 3 TABLE OF CONTENTS Vehicle Feature Identification .................................................................................................................... 4 Safety Details ....................................................................

Page 6 - Vehicle Feature Identification

Vehicle Feature Identification Page 4 2007 HUV4213 Gasoline Vehicle Owner’s Manual HUV4213-G VEHICLE LOADING DECAL OPERATING INSTRUCTIONS DECAL DIFFERENTIAL LOCK CONTROL DECAL BED LOAD WARNING DECAL DRIVER/PASSENGER WARNING DECAL UNDERAGE WARNING DECAL (UNDER SEAT SUPPORT) (ON TOP OF FUEL TANK) KEY ...

Page 10 - PROPOSITION 65 - STATE OF CALIFORNIA; WARNING; Rotating Parts; Practice Safety; compared with the reality of severe personal injury.

Page 8 2007 HUV4213 Gasoline Vehicle Owner’s Manual PROPOSITION 65 - STATE OF CALIFORNIA This product contains or emits chemicals or substances that have been determined by the state of California to cause cancer and birth defects or other reproductive harm. ! WARNING Rotating Parts Practice Safety ...

Page 11 - Safety Details; SAFETY DETAILS; result in minor personal injury or product or property damage.; CAUT ION; could result in property damage.; Figure 1 Battery Cable Removal

Safety Details 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 9 SAFETY DETAILS ý WARNING • This owner’s manual should be read completely before attempting to drive or service the vehicle. Failure to follow the instructions in this manual could result in property damage,severe personal injury, or ...

Page 12 - General Warnings; GENERAL WARNINGS; DAN G E R

General Warnings Page 10 2007 HUV4213 Gasoline Vehicle Owner’s Manual GENERAL WARNINGS The following safety statements must be heeded whenever the vehicle is being operated, repaired, or ser-viced. Vehicle feature identification information is also included beginning on page 4. Other specific safety...

Page 13 - Model Identification; shield and rubber gloves when working on or near batteries.; MODEL IDENTIFICATION; . There is also a second serial number

Model Identification 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 11 ý WARNING • Frame ground – Do not allow tools or other metal objects to contact frame when disconnecting battery cables or other electrical wiring. Do not allow a positive wire to touchthe vehicle frame, engine, or any other m...

Page 14 - Controls and Indicators; CONTROLS AND INDICATORS; See General Warnings on page 10.; and operating procedures.; KEY SWITCH; Figure 3 Key Switch

Controls and Indicators Page 12 2007 HUV4213 Gasoline Vehicle Owner’s Manual CONTROLS AND INDICATORS See General Warnings on page 10. ý WARNING • Before allowing anyone to drive the vehicle, make sure the driver is familiar with all controls and operating procedures. • Do not tamper with the governo...

Page 15 - damage to the unitized transaxle.; FORWARD/REVERSE CONTROL; The Forward/Reverse handle is located on the seat support panel; See WARNING and CAUTION on; Husqvarna; ACCELERATOR PEDAL; to the original position and the engine will idle.; See WARNING and CAUTION on page 12.; Figure 4 Forward/Reverse Handle

Controls and Indicators 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 13 CAUT ION • Do not “rev” the engine for long periods of time while the Forward/Reverse handle is in the NEUTRAL position. Failure to heed this caution could result in damage to the unitized transaxle. • Do not shift the Forw...

Page 16 - BRAKE PEDAL; the vehicle, press the brake pedal; PARK BRAKE; See; vehicle from rolling.; CHOKE; Figure 5 Accelerator and Brake Pedal

Controls and Indicators Page 14 2007 HUV4213 Gasoline Vehicle Owner’s Manual BRAKE PEDAL The brake pedal is the large pedal on the left with the word STOP molded into it (Figure 5) . To slow or stop the vehicle, press the brake pedal (Figure 6) . PARK BRAKE The park brake handle is located between t...

Page 17 - DIFFERENTIAL LOCK; • Disengage differential lock on paved surfaces.; LOW OIL WARNING LAMP; . If the warning lamp comes on, oil should be checked and added; See following CAUTION.; permanent engine damage.; FUEL GAUGE/HOUR METER; odic Service Schedule on page 26.; Figure 9 Low Oil Warning Lamp

Controls and Indicators 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 15 DIFFERENTIAL LOCK ý WARNING • With the differential lock engaged, vehicle turning functions are greatly reduced. To prevent loss of vehicle control when differential lock is engaged, do not operate vehicle at speedsgreater ...

Page 18 - Seat Latch and Adjustment; HEADLAMP CONTROL; SEAT LATCH AND ADJUSTMENT; See following WARNING.; PRE-OPERATION AND DAILY SAFETY CHECKLIST; Each Husqvarna; • Safety and information decals:; should be fully charged.; See Engine Oil on page 29.

Seat Latch and Adjustment Page 16 2007 HUV4213 Gasoline Vehicle Owner’s Manual HEADLAMP CONTROL The headlamp control is located on the instrument panel between the fuel gauge/hour meter and steering col-umn. Pull the headlamp control knob out to turn the headlamps on and push the knob in to turn the...

Page 19 - Performance Inspection; See Fueling Instructions on page 33.; fuel filters, and carburetor for fuel leakage on a daily basis.; See Master Cylinder on page 29.; PERFORMANCE INSPECTION; Check for proper operation.; See Controls and Indicators on page 12.; in the REVERSE position.; • Differential lock cable:; mance. Have a Husqvarna

Performance Inspection 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 17 • Fuel: Check fuel level. See Fueling Instructions on page 33. Check fuel tank, lines, fuel cap, pump, fuel filters, and carburetor for fuel leakage on a daily basis. • Exhaust system: Check for leaks. • Hydraulic brakes: Ch...

Page 20 - Driving Instructions; DRIVING INSTRUCTIONS

Driving Instructions Page 18 2007 HUV4213 Gasoline Vehicle Owner’s Manual DRIVING INSTRUCTIONS ý WARNING • Only licensed drivers should be allowed to drive this vehicle. • Before allowing anyone to drive the vehicle, make sure the driver is familiar with all controls and operating procedures. • No o...

Page 21 - STARTING THE VEHICLE; Make sure the Forward/Reverse handle is in the NEUTRAL position.; • Operator must control vehicle speed when going downhill.; STOPPING THE VEHICLE; See following WARNING and CAUTION; pedal to hold position.

Driving Instructions 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 19 STARTING THE VEHICLE 1. Read safety warnings on dash and vehicle loading information located above pedals. 2. Be sure load, if any, is secure. 3. Study and understand controls. 4. Be sure all passengers are seated and holding ...

Page 22 - Bed Latch and Prop Rod; PARKING AND LEAVING THE VEHICLE; the vehicle from rolling.; See also Figure 24 on page 34.; BED LATCH AND PROP ROD; The bed latch; resulting in severe personal injury or death.; equipped with the electric bed lift accessory.

Bed Latch and Prop Rod Page 20 2007 HUV4213 Gasoline Vehicle Owner’s Manual PARKING AND LEAVING THE VEHICLE 1. After stopping the vehicle, set hand brake until it locks. Make sure it is fully engaged. This will prevent the vehicle from rolling. 2. Turn the key switch to the OFF position and place th...

Page 23 - Front Shock Absorbers; FRONT SHOCK ABSORBERS

Front Shock Absorbers 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 21 FRONT SHOCK ABSORBERS The vehicle arrives from the factory with the front coil-over shocks pre-adjusted for optimum vehicle perfor-mance. We do not recommend adjusting the shock absorbers unless the vehicle will be equipped w...

Page 24 - Towing with the Vehicle; TOWING WITH THE VEHICLE; TRANSPORTING ON A TRAILER; per vehicle being transported.

Towing with the Vehicle Page 22 2007 HUV4213 Gasoline Vehicle Owner’s Manual TOWING WITH THE VEHICLE ý WARNING • Do not tow a vehicle or trailer on public streets or highways. • Normal vehicle operating speed should be reduced when towing. • Extreme caution should be used when towing. • Do not allow...

Page 25 - Storage; STORAGE; • Keep gasoline out of the reach of children.; Frozen batteries can explode.; • Batteries in a low state of charge will freeze at low temperatures.; PREPARING THE VEHICLE FOR EXTENDED STORAGE; Tilt the bed and ensure that the prop rod is properly engaged.

Storage 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 23 STORAGE See General Warnings on page 10. ý DAN G E R • Do not attempt to drain gasoline when the engine is hot or while it is running. • Be sure to clean up any spilled gasoline before operating the vehicle. • Store gasoline in an approved...

Page 26 - See WARNING “To avoid unintentionally start-; Adjust tires to recommended tire pressure.; See Vehicle Specifications on page 38.; Perform semiannual periodic lubrication.; See Periodic Lubrication Schedule on page 28.; RETURNING THE STORED VEHICLE TO SERVICE; Tilt the bed and ensure that the prop rod is properly engaged.; See WARNING “For vehicles with cargo; Figure 12 Fuel Shut-off Valve – Closed Position; OFF; VIEWED FROM SELECTOR

Storage Page 24 2007 HUV4213 Gasoline Vehicle Owner’s Manual 7. Disconnect the battery cables, negative (–) cable first. See WARNING “To avoid unintentionally start- ing...” on page 10. 8. Batteries should be clean and free of corrosion. Wash tops and terminals of batteries with a solution of baking...

Page 27 - MAINTENANCE; Contact your local Husqvarna; See following; Figure 13 Fuel Shut-off Valve – Open Position

Maintenance 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 25 6. Connect battery cables, positive (+) cable first, and tighten terminals to 12 ft-lb (16 N·m). Coat terminals with Battery Terminal Protector Spray (P/N 603 00 00-03). 7. Completely open the fuel shut-off valve (Figure 13) . Make sur...

Page 28 - Periodic Service Schedule; the NEUTRAL position and chock the wheels prior to servicing.; PERIODIC SERVICE SCHEDULE; maintenance and service manual.

Periodic Service Schedule Page 26 2007 HUV4213 Gasoline Vehicle Owner’s Manual ý WARNING • Only trained technicians should service or repair the vehicle. Anyone doing even simple repairs or service should have knowledge and experience in electrical and mechanical repair.The appropriate instructions ...

Page 29 - REGULAR INTERVAL

Periodic Service Schedule 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 27 ý WARNING • If any problems are found during scheduled inspection or service, do not operate vehicle until repairs are made. Failure to make necessary repairs could result in fire, property damage,severe personal injury, ...

Page 30 - Periodic Lubrication Schedule; PERIODIC LUBRICATION SCHEDULE

Periodic Lubrication Schedule Page 28 2007 HUV4213 Gasoline Vehicle Owner’s Manual PERIODIC LUBRICATION SCHEDULE PERIODIC LUBRICATION SCHEDULE REGULAR INTERVAL SERVICE LUBRICATION POINTS RECOMMENDED LUBRICANT Semiannually by owneror trained technician (or every 50 hours of operation, whichever comes...

Page 31 - Master Cylinder; MASTER CYLINDER; Raise or remove the seat to check the brake fluid level.; BRAKE FLUID; ENGINE OIL; ENGINE OIL LEVEL CHECK; • Do not remove dipstick while engine is running.; Figure 16 Brake Fluid Reservoir

Master Cylinder 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 29 MASTER CYLINDER The master cylinder is located under the passenger bucket seat toward the center of the vehicle (Figure 16) . Raise or remove the seat to check the brake fluid level. When checking the brake fluid, also inspect the ...

Page 32 - Engine Oil; ENGINE OIL AND FILTER CHANGE; NEUTRAL position. Chock the front wheels.; engine oil to drain into the pan.; gloves when handling oil drain plug, oil filter, and oil drain pan.; sion washer remains on the drain plug.

Engine Oil Page 30 2007 HUV4213 Gasoline Vehicle Owner’s Manual ENGINE OIL AND FILTER CHANGE Engine oil and oil filter should be changed after the first 100 hours of operation. After that, they should bechanged every 200 hours of operation or annually, whichever comes first. 1. Turn the key switch t...

Page 35 - Fueling Instructions; OIL VISCOSITY; more frequently when using them.; FUELING INSTRUCTIONS; • Turn the key switch to the OFF position before fueling.; Remove fuel cap and fill tank with fresh unleaded gasoline only.; See preceding DANGER and CAU-; Figure 23 Oil Viscosity Chart

Fueling Instructions 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 33 OIL VISCOSITY Choose the viscosity according to the temperature as shown in the oil viscosity chart (Figure 23) . NOTE: Using multi-grade oils (5W-20, 10W-30, and 10W-40) will increase oil consumption. Check oil level more fre...

Page 36 - BATTERY; • Follow all instructions carefully when working with batteries.

Battery Page 34 2007 HUV4213 Gasoline Vehicle Owner’s Manual NOTE: Whenever possible, avoid using oxygenated fuels and fuels that are blended with alcohol. Vehicles to be stored for extended periods should be prepared for storage as instructed. See Preparing theVehicle for Extended Storage on page 2...

Page 37 - Battery; The battery in a Husqvarna; Figure 25 Battery

Battery 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 35 ý WARNING • Do not jump-start a dead battery using another battery and jumper cables. The battery in a Husqvarna vehicle is a 12-volt, low-maintenance battery that requires infrequent checks (Figure 25) . Electrolyte level should be checke...

Page 38 - Cleaning the Vehicle; CLEANING THE VEHICLE; protect occupants from flying objects.

Cleaning the Vehicle Page 36 2007 HUV4213 Gasoline Vehicle Owner’s Manual Be sure battery hold-down clamp is properly tightened. Tighten to 12 ft-lb (16 N·m). A loose clamp may allowthe battery to become damaged from vibration or jarring. If battery appears weak, have it charged by a trained technic...

Page 39 - Subsequent Owner Registration; ELECTRIC WINCH ACCESSORY; See Vehicle Feature Identification on beginning page 4.; • Before beginning a winch operation:; SUBSEQUENT OWNER REGISTRATION

Subsequent Owner Registration 2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 37 ELECTRIC WINCH ACCESSORY If your vehicle is equipped with an electric winch, read and follow all manufacturer safety warnings andinstructions in the winch operator manual, as well as the following WARNING and CAUTION ...

Page 40 - Vehicle Specifications; VEHICLE SPECIFICATIONS; SPECIFICATIONS

Vehicle Specifications Page 38 2007 HUV4213 Gasoline Vehicle Owner’s Manual VEHICLE SPECIFICATIONS SPECIFICATIONS HUV4213-GXP HUV4213-G POWER SOURCE Engine: 4-cycle OHV, 400 cc, 13.0 maximum HP @3600 rpm (per SAE J 1940/1349), single- cylinder, air-cooled, with pressure lubrication system • Fuel sys...

Page 44 - CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT

Page 42 2007 HUV4213 Gasoline Vehicle Owner’s Manual CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT Your new Husqvarna, Inc. ("HUSQVARNA") vehicle engine complies with both the U.S. EPA and State of California emission regulations. YOUR WARRANTY RIGHTS AND OBLIGATIONS: The California Air Res...

Page 45 - FUEL AND OIL RECOMMENDATIONS; EMISSION CONTROL INFORMATION; CAUTION

2007 HUV4213 Gasoline Vehicle Owner’s Manual Page 43 FUEL AND OIL RECOMMENDATIONS Fuel Use only clean, fresh, unleaded regular grade gasoline. Octane Rating The octane rating of a gasoline is a measure of its resistance to “knocking”.Use of a mini-mum of 87 octane of the anti-knock index isrecommend...