Husqvarna HUV4421G - Manual

Table of Contents:

• Page 3 – NOTICE
• Page 4 – 007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual; FOREWORD
• Page 5 – TABLE OF CONTENTS
• Page 9 – SAFETY DETAILS; result in minor personal injury.; CAUT ION; could result in property damage.; Figure 1 Battery Cable Removal
• Page 10 – GENERAL WARNINGS; DAN G E R; CAUTION statements in this manual as well as those on the vehicle.
• Page 11 – • To avoid unintentionally starting the vehicle:; Figure 2 All-wheel Drive Warning
• Page 12 – GENERAL INFORMATION; . There is also a second serial number decal mounted on the rear; CONTROLS AND INDICATORS; See General Warnings on page 8.; and operating procedures.; Figure 3 Serial Number
• Page 14 – KEY SWITCH – GASOLINE VEHICLES; ACCELERATOR PEDAL; The accelerator pedal (1) is the pedal farthest to the right; See WARNING and CAUTION on page 12.
• Page 15 – BRAKE PEDAL; The park brake pedal (3) is located to the left of the brake pedal; See following; vehicle from rolling.; STEERING ADJUSTMENT LOCK; Figure 4; lever to firmly lock the steering column in position.; See following WARNING.; Figure 6 Park Brake Release
• Page 16 – LOW OIL WARNING LAMP; See following CAUTION.; permanent engine damage.; FUEL GAUGE/HOUR METER; See Periodic Service Schedule on page 29.; HEADLAMP CONTROL; . Press the headlamp rocker switch to turn the headlamps on or off.; ELECTRIC BED LIFT – OPTIONAL ON SOME VEHICLES; Remove cargo before raising the bed.; HIGH-TEMPERATURE WARNING LAMP – DIESEL VEHICLES ONLY
• Page 17 – ROLL-OVER PROTECTIVE STRUCTURE AND SAFETY BELTS; Figure 7 Release Safety Belt
• Page 18 – more people – this includes children.; • Be careful not to damage the safety belt webbing or hardware.; CARGO CAGE HEADRESTS; To adjust the headrests
• Page 19 – SEAT LATCH AND ADJUSTMENT; Vehicles with bucket seat option:; • Do not adjust the driver-side seat while the vehicle is in motion.; To adjust the passenger-side seat; PRE-OPERATION AND DAILY SAFETY CHECKLIST; Figure 8 Adjust Headrests
• Page 20 – PERFORMANCE INSPECTION
• Page 21 – DRIVING INSTRUCTIONS; • Only licensed drivers should be allowed to drive the vehicle.
• Page 22 – laws pertaining to child safety.; STARTING THE VEHICLE; Driver should have both hands on the steering wheel.
• Page 23 – • Operator must control vehicle speed when going downhill.; this condition, avoid extremely hard braking in reverse.
• Page 24 – STOPPING THE VEHICLE; See following WARNING and CAUTION; pedal to hold position.; PARKING AND LEAVING THE VEHICLE; The bed latch; resulting in severe personal injury or death.; , unless equipped with the electric bed lift accessory.
• Page 25 – LOADING AND UNLOADING CARGO; VEHICLE LOAD CAPACITIES; Figure 9 Bed Latch
• Page 26 – Gross Trailer Weight; Refer to
• Page 27 – TOWING WITH THE VEHICLE; overturn, possibly resulting in severe personal injury.; TRANSPORTING ON A TRAILER; is on an approved trailer.; per vehicle being transported.
• Page 28 – STORAGE; • Clean up any spilled fuel before operating the vehicle.; Frozen batteries can explode.; • Batteries in a low state of charge will freeze at low temperatures.; Figure 12 Fuel Shut-off Valve – Closed Position; OFF; VIEWED FROM SELECTOR
• Page 29 – PREPARING THE VEHICLE FOR EXTENDED STORAGE; Bil; See Engine Oil and Filter Change on page 35.; Figure 13 Fuel Shut-off Valve – Open Position
• Page 30 – See Vehicle Specifications on page 50.; Perform semiannual periodic lubrication.; See Periodic Lubrication Schedule on page 32.; RETURNING THE STORED VEHICLE TO SERVICE; Restore the fuel system to operation; Gasoline vehicles only:; Completely open the fuel shut-off valve; MAINTENANCE
• Page 31 – NEUTRAL position and chock the wheels prior to servicing.; PERIODIC SERVICE SCHEDULE; maintenance and service manual.
• Page 32 – REGULAR INTERVAL
• Page 34 – PERIODIC LUBRICATION SCHEDULE
• Page 35 – BRAKE FLUID RESERVOIR; The brake fluid reservoir (1) is located under the hood; FULL
• Page 36 – BRAKE FLUID; ENGINE OIL; OIL PRESSURE – GASOLINE ENGINE; • Do not remove dipstick while engine is running.; or damage to the engine.
• Page 37 – ENGINE OIL AND FILTER CHANGE; Figure 19 Engine Oil Level Check – Gasoline Vehicles
• Page 38 – Engine Oil Draining; NEUTRAL position. Chock the front wheels.; See WARNING “To avoid unintentionally start-; Remove the oil filler cap to allow the oil to drain properly.; or; gloves when handling oil drain plug, oil filter, and oil drain pan.; Figure 22 Engine Oil Drain Plug and Pan – Gasoline
• Page 39 – Engine Oil Filter Change; See Engine Oil Draining on page 36.; into the oil drain pan.
• Page 40 – Engine Oil Filling; result in damage to the engine.; Figure 27 Add Engine Oil – Gasoline Vehicles
• Page 41 – OIL VISCOSITY; GEARCASE LUBRICATION; Each gearcase component is equipped with two oil port plugs (1 and 2); Tighten the level indi-
• Page 42 – Apply Loctite 567 to the; Apply Loctite 567 to the threads of
• Page 43 – ENGINE COOLANT – DIESEL VEHICLES; ENGINE COOLANT LEVEL CHECK; check the coolant level before every operation.; AIR INTAKE SYSTEM; allowing excessive contamination to enter the air intake system.; AIR FILTER REPLACEMENT; More frequent service may be; Air Filter Removal; Release both canister tab locks
• Page 44 – Air Filter Installation; Secure the canister cap with both tab locks.; FUELING INSTRUCTIONS; • Turn key switch to the OFF position before fueling.; have a green fuel cap.; See preceding DANGER and following NOTE.; fuels and fuels that are blended with alcohol.
• Page 45 – Check the engine oil level daily before the engine is started.; See Engine Oil Level Check on page 34.; Figure 35 Fuel Tank – Gasoline Vehicles; VENT
• Page 46 – Figure 37 Fuel Filter
• Page 47 – BATTERY; face shield and rubber gloves when working on or near batteries.; . Electrolyte level should be checked semiannually.; FRONT
• Page 48 – the designated fill line. Replace battery cell caps.; engage the park brake, and chock the wheels.
• Page 49 – See DANGER “Battery – Explo-; Sit in the driver’s seat and start the engine.; • Damage to the alternator can occur if:; CLEANING THE VEHICLE; Dispose of waste water properly.
• Page 50 – ACCESSORIES
• Page 51 – SUBSEQUENT OWNER REGISTRATION
• Page 52 – VEHICLE SPECIFICATIONS; SPECIFICATIONS
• Page 54 – HUSQVARNA
• Page 56 – Carburetor Modification for High Altitude Operation; The following are the EPA approved percentages of oxygenates:
• Page 58 – CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT