Husqvarna HUV 4421-D / DXP - Manual

Table of Contents:

• Page 3 – NOTICE
• Page 4 – 007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual; FOREWORD
• Page 5 – TABLE OF CONTENTS
• Page 9 – SAFETY DETAILS; result in minor personal injury.; CAUT ION; could result in property damage.; Figure 1 Battery Cable Removal
• Page 10 – GENERAL WARNINGS; DAN G E R; CAUTION statements in this manual as well as those on the vehicle.
• Page 11 – • To avoid unintentionally starting the vehicle:; Figure 2 All-wheel Drive Warning
• Page 12 – GENERAL INFORMATION; . There is also a second serial number decal mounted on the rear; CONTROLS AND INDICATORS; See General Warnings on page 8.; and operating procedures.; Figure 3 Serial Number
• Page 14 – KEY SWITCH – GASOLINE VEHICLES; ACCELERATOR PEDAL; The accelerator pedal (1) is the pedal farthest to the right; See WARNING and CAUTION on page 12.
• Page 15 – BRAKE PEDAL; The park brake pedal (3) is located to the left of the brake pedal; See following; vehicle from rolling.; STEERING ADJUSTMENT LOCK; Figure 4; lever to firmly lock the steering column in position.; See following WARNING.; Figure 6 Park Brake Release
• Page 16 – LOW OIL WARNING LIGHT; See following CAUTION.; permanent engine damage.; FUEL GAUGE/HOUR METER; See Periodic Service Schedule on page 29.; HEADLIGHT CONTROL; Press the headlight rocker switch to turn the headlights on or off.; ELECTRIC BED LIFT; NOTE: Remove cargo before raising the bed.
• Page 17 – ROLL-OVER PROTECTIVE STRUCTURE AND SAFETY BELTS; Figure 7 Release Safety Belt
• Page 18 – more people – this includes children.; • Be careful not to damage the safety belt webbing or hardware.; SEAT LATCH AND ADJUSTMENT; Vehicles with bucket seat option:; • Do not adjust the driver-side seat while the vehicle is in motion.
• Page 19 – PRE-OPERATION AND DAILY SAFETY CHECKLIST; when the brake pads or rotor have been replaced.
• Page 20 – PERFORMANCE INSPECTION; Check for proper operation.; See Controls and Indicators on page 10.; in the REVERSE position.; DRIVING INSTRUCTIONS; • Only licensed drivers should be allowed to drive the vehicle.
• Page 21 – Driver should have both hands on the steering wheel.
• Page 22 – • Operator must control vehicle speed when going downhill.
• Page 23 – this condition, avoid extremely hard braking in reverse.; STOPPING THE VEHICLE; See following WARNING and CAUTION; pedal to hold position.; PARKING AND LEAVING THE VEHICLE; BED LATCH AND PROP ROD; The bed latch; resulting in severe personal injury or death.
• Page 24 – vehicles are equipped with an automatically engaging prop rod; LOADING AND UNLOADING CARGO; Figure 8 Bed Latch
• Page 25 – VEHICLE LOAD CAPACITIES; Refer to
• Page 26 – TOWING WITH THE VEHICLE; See Vehicle Load Capacities on page 23 for vehicle capacity; TRANSPORTING ON A TRAILER; • Do not allow riders in the trailer being towed.; Figure 10 Vehicle Load Capacity – Two-Passenger
• Page 27 – per vehicle being transported.; STORAGE; • Clean up any spilled fuel before operating the vehicle.; Frozen batteries can explode.
• Page 28 – • Batteries in a low state of charge will freeze at low temperatures.; PREPARING THE VEHICLE FOR EXTENDED STORAGE; Figure 11 Fuel Shut-off Valve – Closed Position; OFF
• Page 29 – See Engine Oil and Filter Change on page 36.; RETURNING THE STORED VEHICLE TO SERVICE; Gasoline vehicles only:
• Page 30 – MAINTENANCE; NEUTRAL position and chock the wheels prior to servicing.
• Page 31 – maintenance and service manual.; PERIODIC SERVICE SCHEDULE; REGULAR INTERVAL
• Page 34 – PERIODIC LUBRICATION SCHEDULE
• Page 36 – BRAKE FLUID RESERVOIR; The brake fluid reservoir (1) is located under the hood; BRAKE FLUID; ENGINE OIL; OIL PRESSURE – GASOLINE ENGINE; Figure 16 Brake Fluid and Coolant Access; FULL
• Page 37 – ENGINE OIL LEVEL CHECK; • Do not remove dipstick while engine is running.; or damage to the engine.; Figure 18 Engine Oil Level Check –
• Page 38 – ENGINE OIL AND FILTER CHANGE; See WARNING “To avoid unintentionally start-; gloves when handling oil drain plug, oil filter, and oil drain pan.; Figure 20 Engine Oil Level Check – Diesel Vehicles
• Page 39 – or; . Turn the plug clockwise; Engine Oil Filter Change; See Engine Oil Draining on page 36.; into the oil drain pan.
• Page 41 – Engine Oil Filling; Refer to oil viscosity guidelines for selection of oil grade; result in damage to the engine.; OIL VISCOSITY; Figure 28 Add Engine Oil – Gasoline Vehicles
• Page 42 – GEARCASE LUBRICATION; Each gearcase component is equipped with two oil port plugs (1 and 2)
• Page 43 – Tighten the level indi-; See Periodic Lubrication Schedule on page 32.; Apply Loctite 567 to the; See Periodic Lubrication Schedule on page 32.; Apply Loctite 567 to the threads of
• Page 44 – ENGINE COOLANT – DIESEL VEHICLES; ENGINE COOLANT LEVEL CHECK; check the coolant level before every operation.; AIR INTAKE SYSTEM; allowing excessive contamination to enter the air intake system.; AIR FILTER REPLACEMENT; More frequent service may be
• Page 45 – Air Filter Removal; Release both canister tab locks; Air Filter Installation; Secure the canister cap with both tab locks.; FUELING INSTRUCTIONS; • Turn key switch to the OFF position before fueling.; have a green fuel cap.; See preceding DANGER and following NOTE.; Figure 35 Air Filter Cartridge
• Page 46 – Figure 36 Fuel Tank – Gasoline Vehicles; VENT
• Page 47 – See Draining Water from Fuel Filter.; Check the engine oil level daily before the engine is started.; See Engine Oil Level Check on page 35.; DRAINING WATER FROM FUEL FILTER
• Page 48 – BATTERY; • Follow all instructions carefully when working with batteries.; Figure 38 Fuel Filter
• Page 49 – shield and rubber gloves when working on or near batteries.; the designated fill line. Replace battery cell caps.; Figure 39 Battery; FRONT
• Page 50 – engage the park brake, and chock the wheels.; Figure 41 Jump Starting
• Page 51 – CLEANING THE VEHICLE; protect occupants from flying objects.; ELECTRIC WINCH ACCESSORY; See following WARNING and CAUTION.
• Page 52 – • Before beginning a winch operation:; SUBSEQUENT OWNER REGISTRATION
• Page 53 – VEHICLE SPECIFICATIONS; SPECIFICATIONS
• Page 56 – HUSQVARNA
• Page 58 – Carburetor Modification for High Altitude Operation; The following are the EPA approved percentages of oxygenates:
• Page 60 – CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT