Husqvarna 4210-G - Manual

Table of Contents:

• Page 3 – NOTICE
• Page 4 – FOREWORD; You have chosen the finest utility
• Page 5 – TABLE OF CONTENTS
• Page 6 – Vehicle Feature Identification
• Page 8 – HUV4210-G GASOLINE VEHICLE
• Page 10 – Rotating Parts; Practice Safety; PROPOSITION 65 – STATE OF CALIFORNIA
• Page 11 – Safety Details; SAFETY DETAILS; result in minor personal injury.; GENERAL WARNINGS; vehicle and service area. Service only in a well-ventilated area.
• Page 12 – General Warnings; DAN G E R; produces carbon monoxide, which is an odorless, deadly poison.; • Do not leave children unattended on vehicle.
• Page 13 – General Information; caution to avoid shorting of components or wiring.; GENERAL INFORMATION; cause serious injury or death.; Figure 1 Gasoline Vehicle
• Page 14 – Model Identification; MODEL IDENTIFICATION; Figure 3 Bumper
• Page 15 – Controls and Indicators; CONTROLS AND INDICATORS; See General Warnings on page 9.; operating procedures before allowing the vehicle to be driven.; KEY SWITCH; the engine is cold it may be necessary to use the choke.; See Choke on page 18.; Release the key and it will
• Page 16 – The Forward/Reverse handle is located on the seat support panel; See WARNING and CAUTION on page 13.; Electric Vehicles; Figure 6 Key Switch
• Page 17 – ACCELERATOR PEDAL; Figure 7 Forward/Reverse Handle – Gas Vehicle
• Page 18 – BRAKE PEDAL; the vehicle, press the brake pedal with your foot; PARK BRAKE PEDAL; See; Batteries have discharged to less than 25% of rated capacity.
• Page 19 – See the battery charger owner’s man-; Electric Vehicles Only; • Before Towing the Vehicle:; Place the Tow/Run switch in the TOW posi-; • For Long Term Storage:
• Page 20 – CHOKE; Figure 12 Tow/Run Switch
• Page 21 – Pre-Operation and Daily Safety Checklist; CAUT ION; . Pull out to turn the; 2-VOLT OUTLET ACCESSORY; PRE-OPERATION AND DAILY SAFETY CHECKLIST; Check electrolyte to ensure that it is at its proper level
• Page 23 – Driving Instructions; Accelerate the vehicle to full speed; Gasoline Vehicles; DRIVING INSTRUCTIONS
• Page 24 – Make sure wheels are turned in desired direction.
• Page 25 – See following; • Operator must control speed when going downhill.; STOPPING THE VEHICLE; position. Remove the key when the vehicle is not in use.; • Electric vehicles only:
• Page 26 – Bed Latch; BED LATCH; The bed latch (1) is located under the front corners of the bed; TRANSPORTING ON A TRAILER; WA R N I N G; Figure 15 Bed Latch
• Page 27 – Storage – Electric Vehicles; STORAGE – ELECTRIC VEHICLES; Adjust tires to recommended tire pressure.
• Page 28 – Storage – Gasoline Vehicles; RETURNING THE STORED ELECTRIC VEHICLE TO SERVICE; Adjust tires to recommended tire pressure.; See Vehicle Specifications on page 46.; Perform the Pre-Operation and Daily Safety Checklist on page 19.; STORAGE – GASOLINE VEHICLES; • Keep gasoline out of reach of children.; • Batteries in a low state of charge will freeze at low temperatures.; PREPARING THE GASOLINE VEHICLE FOR EXTENDED STORAGE; Drain carburetor and seal the fuel tank.
• Page 29 – Perform semiannual periodic lubrication.; See Periodic Lubrication Schedules on page 32.; Figure 16 Fuel Shut-off Valve – Closed Position
• Page 30 – Maintenance; RETURNING THE STORED GASOLINE VEHICLE TO SERVICE; Restore fuel system to operation; Perform the Pre-Operation and Daily Safety Checklist on page 19.; MAINTENANCE
• Page 31 – Periodic Service Schedules; Gasoline vehicles only:; PERIODIC SERVICE SCHEDULES; vehicle in optimum operating condition.
• Page 32 – PERIODIC SERVICE SCHEDULE – ELECTRIC VEHICLES; REGULAR INTERVAL
• Page 34 – Periodic Lubrication Schedules; PERIODIC LUBRICATION SCHEDULES; PERIODIC LUBRICATION SCHEDULE – ELECTRIC VEHICLES
• Page 35 – PERIODIC LUBRICATION SCHEDULE – GASOLINE VEHICLES
• Page 36 – Vehicle Controller – Electric Vehicles; VEHICLE CONTROLLER – ELECTRIC VEHICLES
• Page 37 – Batteries – Electric Vehicles; BATTERY CARE; Dispose of waste water properly.; See following CAUTION.; Figure 21 Electric Battery Electrolyte Level
• Page 38 – Battery Charger – Electric Vehicles; BATTERY CHARGER – ELECTRIC VEHICLES; voltage and frequency as shown on the charger.
• Page 39 – CHARGING BATTERIES; • Do not use a charger if:
• Page 40 – PLUG AND RECEPTACLE; Figure 22 Correct Insertion of Charger DC Plug
• Page 41 – Battery – Gasoline Vehicles; RECEPTACLE FUSE LINK; . If the charger does not come on when the vehicle is placed; See following WARNING.; BATTERY – GASOLINE VEHICLES; • Follow all instructions carefully when working with batteries.; Figure 24 Receptacle Fuse Link
• Page 42 – watering; See preceding WARNING and following CAUTION.; battery to become damaged from vibration or jarring.
• Page 43 – Engine Oil – Gasoline Vehicles; ENGINE OIL – GASOLINE VEHICLES; Do not overfill with oil.; ENGINE OIL LEVEL CHECK; • Do not remove dipstick while engine is running.; Reinsert dipstick into the oil filler tube.; ENGINE OIL AND FILTER CHANGE; neutral POSITION. Chock the front wheels.; Figure 27 Engine Oil Level Check
• Page 44 – See WARNING “To avoid unintentionally start-; counterclockwise, and allow the engine oil to drain into the pan.; gloves when handling oil drain plug, oil filter, and oil drain pan.; sion washer remains on the drain plug.
• Page 45 – OIL VISCOSITY; Figure 29 Remove Engine Oil Filter
• Page 46 – Fueling Instructions – Gasoline Vehicles; FUELING INSTRUCTIONS – GASOLINE VEHICLES; • Turn the key switch to the OFF position before fueling.; See Preparing the; See preceding CAUTION.; Replace fuel cap on tank. Ensure cap is tightened securely.
• Page 47 – Cleaning the Vehicle; CLEANING THE VEHICLE; ACCESSORIES; Figure 32 Fuel Tank
• Page 48 – Vehicle Specifications; VEHICLE SPECIFICATIONS; SPECIFICATIONS
• Page 50 – LIMITED TWO YEAR / 2000 HOUR WARRANTY
• Page 52 – WARRANTY LIMITATIONS; HUSQVARNA
• Page 55 – CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT
• Page 56 – an; Publication Part Number