Page 3 - NOTICE
Husqvarna Forest and Garden 7349 Statesville Rd. Charlotte, NC 28269 USA www.usa.husqvarna.com/huv 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 1 NOTICE The Husqvarna Limited Warranty appears on the last pages of this manual. No other warranties, express orimplied, are c...
Page 4 - FOREWORD; You have chosen the finest utility
Page 2 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual FOREWORD Thank you for choosing Husqvarna, a world leader in outdoor products. You have chosen the finest utility vehicle on the market. Please protect your investment and ensure that your Husqvarna vehicle provides years of...
Page 5 - TABLE OF CONTENTS
2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 3 TABLE OF CONTENTS Vehicle Feature Identification – HUV4210-E Electric Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Vehicle Feature Identification – HUV4210-G Gasoline Vehicle . . . . . . . . ...
Page 6 - Vehicle Feature Identification
Vehicle Feature Identification Page 4 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual HUV4210-E ELECTRIC VEHICLE SERVICE NOTICE DECAL (ON BODY UNDER BED) FORWARD/REVERSE SWITCH BATTERY DANGER DECAL (ON BATTERY CAPS OR ON BODY UNDER SEAT) CHARGER RECEPTACLE TOW SWITCH WARNING DEC...
Page 8 - HUV4210-G GASOLINE VEHICLE
Vehicle Feature Identification Page 6 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual HUV4210-G GASOLINE VEHICLE 102825601 • R e a d o w n e r ’ s m a n u a l a n d d a s h - m o u n t e d s a f e t y w a r n i n g s p r i o r t o d r i v i n g . • S t u d y a n d u n d e r s t ...
Page 10 - Rotating Parts; Practice Safety; PROPOSITION 65 – STATE OF CALIFORNIA
! WARNING Rotating Parts Practice Safety Page 8 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Safety signs like you see above may at first seem shocking, but their impact is mildcompared with the reality of severe personal injury. Your safety and satisfaction are of the utmost...
Page 11 - Safety Details; SAFETY DETAILS; result in minor personal injury.; GENERAL WARNINGS; vehicle and service area. Service only in a well-ventilated area.
Safety Details 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 9 SAFETY DETAILS ý WARNING • This owner’s manual should be read completely before attempting to drive or service the vehicle. Failure to follow the instructions in this manual could result in property damage,sev...
Page 12 - General Warnings; DAN G E R; produces carbon monoxide, which is an odorless, deadly poison.; • Do not leave children unattended on vehicle.
General Warnings Page 10 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual ý DAN G E R • Do not operate gasoline vehicle in an enclosed area without proper ventilation. The engine produces carbon monoxide, which is an odorless, deadly poison. • A Husqvarna vehicle will not provide...
Page 13 - General Information; caution to avoid shorting of components or wiring.; GENERAL INFORMATION; cause serious injury or death.; Figure 1 Gasoline Vehicle
General Information 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 11 ý WARNING • Use insulated tools when working near batteries or electrical connections. Use extreme caution to avoid shorting of components or wiring. All vehicles: • Wear safety glasses or approved eye p...
Page 14 - Model Identification; MODEL IDENTIFICATION; Figure 3 Bumper
Model Identification Page 12 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual MODEL IDENTIFICATION The serial number of the vehicles are printed on two bar code decals. (Example: HH0501-583947) (Figure 5) . One is mounted on the frame, under the bed, on the passenger side. There ...
Page 15 - Controls and Indicators; CONTROLS AND INDICATORS; See General Warnings on page 9.; operating procedures before allowing the vehicle to be driven.; KEY SWITCH; the engine is cold it may be necessary to use the choke.; See Choke on page 18.; Release the key and it will
Controls and Indicators 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 13 CONTROLS AND INDICATORS See General Warnings on page 9. ý WARNING • If renting or loaning the vehicle, make sure the driver is familiar with all controls and operating procedures before allowing the ...
Page 16 - The Forward/Reverse handle is located on the seat support panel; See WARNING and CAUTION on page 13.; Electric Vehicles; Figure 6 Key Switch
Controls and Indicators Page 14 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual NOTE: The key can be removed only when the key switch is in the OFF position. Electric Vehicles The key switch is mounted on the dash to the right of the steering column. It has two positions, OFF an...
Page 17 - ACCELERATOR PEDAL; Figure 7 Forward/Reverse Handle – Gas Vehicle
Controls and Indicators 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 15 ACCELERATOR PEDAL The accelerator pedal is the pedal on the right, with the word GO molded into it (Figure 9) . Electric Vehicles The operation of the accelerator pedal differs from that of an automo...
Page 18 - BRAKE PEDAL; the vehicle, press the brake pedal with your foot; PARK BRAKE PEDAL; See; Batteries have discharged to less than 25% of rated capacity.
Controls and Indicators Page 16 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual BRAKE PEDAL The brake pedal is the large pedal on the left with the word STOP molded into it (Figure 9) . To slow or stop the vehicle, press the brake pedal with your foot (Figure 10) . PARK BRAKE PE...
Page 19 - See the battery charger owner’s man-; Electric Vehicles Only; • Before Towing the Vehicle:; Place the Tow/Run switch in the TOW posi-; • For Long Term Storage:
Controls and Indicators 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 17 • The warning light will not illuminate if the charge is 90% or more complete. The onboard computer willretain in memory the amount of charge needed to fully replenish the batteries and will complete...
Page 20 - CHOKE; Figure 12 Tow/Run Switch
Controls and Indicators Page 18 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual CHOKE Gasoline Vehicles Only The choke is located on the seat support panel below and to the left of the driver’s left knee (Figure 13) . If the vehicle is hard to start in cool or cold temperatures,...
Page 21 - Pre-Operation and Daily Safety Checklist; CAUT ION; . Pull out to turn the; 2-VOLT OUTLET ACCESSORY; PRE-OPERATION AND DAILY SAFETY CHECKLIST; Check electrolyte to ensure that it is at its proper level
Pre-Operation and Daily Safety Checklist 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 19 CAUT ION • Failure to add oil immediately when the low oil warning light stays on may result in permanent engine damage. HEADLIGHT CONTROL The headlight control (2) is located on the...
Page 23 - Driving Instructions; Accelerate the vehicle to full speed; Gasoline Vehicles; DRIVING INSTRUCTIONS
Driving Instructions 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 21 ý WARNING • Zero-speed detect will not limit vehicle speed to 1 mph (1.6 km/h) on very steep grades. Do not operate vehicle on slopes exceeding 20% grades. • Pedal Up Motor Braking (adjustable on IQ Sys...
Page 24 - Make sure wheels are turned in desired direction.
Driving Instructions Page 22 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual ý WARNING • To help avoid possible injury to an inattentive passenger and (or) damage to the vehicle, avoid sudden starts, sudden stops, and abrupt turns. • To help avoid the possibility of losing contr...
Page 25 - See following; • Operator must control speed when going downhill.; STOPPING THE VEHICLE; position. Remove the key when the vehicle is not in use.; • Electric vehicles only:
Driving Instructions 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 23 5. Turn the key all the way to the START position and hold, activating the choke as necessary, until the engine is running smoothly. The engine will idle in neutral. 6. Select direction by placing the F...
Page 26 - Bed Latch; BED LATCH; The bed latch (1) is located under the front corners of the bed; TRANSPORTING ON A TRAILER; WA R N I N G; Figure 15 Bed Latch
Bed Latch Page 24 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual BED LATCH See General Warnings on page 9. The bed latch (1) is located under the front corners of the bed (Figure 15, Page 24) and engages automati- cally when the bed is closed. To lift the bed, pull the bed latc...
Page 27 - Storage – Electric Vehicles; STORAGE – ELECTRIC VEHICLES; Adjust tires to recommended tire pressure.
Storage – Electric Vehicles 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 25 If the vehicle must be transported over long distances or on public highways, it should be transported on an approved trailer that has the approved load rating of 1200 lb. (544 kg) per vehicle be...
Page 28 - Storage – Gasoline Vehicles; RETURNING THE STORED ELECTRIC VEHICLE TO SERVICE; Adjust tires to recommended tire pressure.; See Vehicle Specifications on page 46.; Perform the Pre-Operation and Daily Safety Checklist on page 19.; STORAGE – GASOLINE VEHICLES; • Keep gasoline out of reach of children.; • Batteries in a low state of charge will freeze at low temperatures.; PREPARING THE GASOLINE VEHICLE FOR EXTENDED STORAGE; Drain carburetor and seal the fuel tank.
Storage – Gasoline Vehicles Page 26 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual RETURNING THE STORED ELECTRIC VEHICLE TO SERVICE 1. If necessary, connect batteries and tighten terminals to 110 in-lb (12.4 N·m). 2. Fully charge batteries. 3. Adjust tires to recommended tire p...
Page 29 - Perform semiannual periodic lubrication.; See Periodic Lubrication Schedules on page 32.; Figure 16 Fuel Shut-off Valve – Closed Position
Storage – Gasoline Vehicles 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 27 2.4. Plug the fuel tank vent nipple so that it is air tight. We recommend using a slip-on vinyl cap. 3. Disconnect the battery cables, negative (–) cable first. 4. Batteries should be clean and f...
Page 30 - Maintenance; RETURNING THE STORED GASOLINE VEHICLE TO SERVICE; Restore fuel system to operation; Perform the Pre-Operation and Daily Safety Checklist on page 19.; MAINTENANCE
Maintenance Page 28 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual RETURNING THE STORED GASOLINE VEHICLE TO SERVICE 1. Restore fuel system to operation (Figure 32, Page 45) . 1.1. Remove plug from fuel tank vent. 1.2. Connect vent tube to fuel tank vent. 2. Connect battery cabl...
Page 31 - Periodic Service Schedules; Gasoline vehicles only:; PERIODIC SERVICE SCHEDULES; vehicle in optimum operating condition.
Periodic Service Schedules 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 29 ý WARNING Gasoline vehicles only: • Moving parts: Do not attempt to service gasoline vehicle while the engine is running. • Hot! Do not attempt to service hot engine or exhaust system. Failure to ...
Page 32 - PERIODIC SERVICE SCHEDULE – ELECTRIC VEHICLES; REGULAR INTERVAL
Periodic Service Schedules Page 30 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual PERIODIC SERVICE SCHEDULE – ELECTRIC VEHICLES REGULAR INTERVAL SERVICE Daily service by owner Batteries Charge batteries (after each use only). Weekly service by owner Batteries Check electrolyte ...
Page 34 - Periodic Lubrication Schedules; PERIODIC LUBRICATION SCHEDULES; PERIODIC LUBRICATION SCHEDULE – ELECTRIC VEHICLES
Periodic Lubrication Schedules Page 32 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual PERIODIC LUBRICATION SCHEDULES PERIODIC LUBRICATION SCHEDULE – ELECTRIC VEHICLES REGULAR INTERVAL SERVICE LUBRICATION POINTS RECOMMENDED LUBRICANT Semiannually by owner or trained technician (...
Page 35 - PERIODIC LUBRICATION SCHEDULE – GASOLINE VEHICLES
Periodic Lubrication Schedules 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 33 PERIODIC LUBRICATION SCHEDULE – GASOLINE VEHICLES REGULAR INTERVAL SERVICE LUBRICATION POINTS RECOMMENDED LUBRICANT Semiannually by owneror trained technician (or every 50 hours of operation, ...
Page 36 - Vehicle Controller – Electric Vehicles; VEHICLE CONTROLLER – ELECTRIC VEHICLES
Vehicle Controller – Electric Vehicles Page 34 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual VEHICLE CONTROLLER – ELECTRIC VEHICLES The electric vehicle is equipped with a solid state speed controller. In order to properly service and maintainthe solid state controller vehicle...
Page 37 - Batteries – Electric Vehicles; BATTERY CARE; Dispose of waste water properly.; See following CAUTION.; Figure 21 Electric Battery Electrolyte Level
Batteries – Electric Vehicles 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 35 BATTERY CARE To keep batteries in good working condition, follow this maintenance program on a regular basis: 1. The batteries should be kept clean and free of corrosion. Wash tops and terminal...
Page 38 - Battery Charger – Electric Vehicles; BATTERY CHARGER – ELECTRIC VEHICLES; voltage and frequency as shown on the charger.
Battery Charger – Electric Vehicles Page 36 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual BATTERY CHARGER – ELECTRIC VEHICLES ý DAN G E R • The charging area must be ventilated. Hydrogen level in the air must never exceed 2%. The total volume of air in the charging area must b...
Page 39 - CHARGING BATTERIES; • Do not use a charger if:
Battery Charger – Electric Vehicles 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 37 NOTE: Because the vehicle’s onboard computer (OBC) has a storage charge feature that automaticallychecks and recharges the batteries as necessary every 15 days, the charger can remain plu...
Page 40 - PLUG AND RECEPTACLE; Figure 22 Correct Insertion of Charger DC Plug
Battery Charger – Electric Vehicles Page 38 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual NOTE: When temperatures fall below 65 °F (18.3 °C), batteries charged in unheated areas should beplaced on charge as soon as possible after use. Batteries are warmest immediately after us...
Page 41 - Battery – Gasoline Vehicles; RECEPTACLE FUSE LINK; . If the charger does not come on when the vehicle is placed; See following WARNING.; BATTERY – GASOLINE VEHICLES; • Follow all instructions carefully when working with batteries.; Figure 24 Receptacle Fuse Link
Battery – Gasoline Vehicles 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 39 RECEPTACLE FUSE LINK As an additional feature to protect the batteries and charging circuit from an overload, the electric vehicle isequipped with a receptacle fuse link (Figure 24) . If the char...
Page 42 - watering; See preceding WARNING and following CAUTION.; battery to become damaged from vibration or jarring.
Battery – Gasoline Vehicles Page 40 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual ý DAN G E R - External: Flush with water. Call a physician immediately. - Internal: Drink large quantities of milk or water followed with milk of magnesia or vegetable oil. Call a physician immed...
Page 43 - Engine Oil – Gasoline Vehicles; ENGINE OIL – GASOLINE VEHICLES; Do not overfill with oil.; ENGINE OIL LEVEL CHECK; • Do not remove dipstick while engine is running.; Reinsert dipstick into the oil filler tube.; ENGINE OIL AND FILTER CHANGE; neutral POSITION. Chock the front wheels.; Figure 27 Engine Oil Level Check
Engine Oil – Gasoline Vehicles 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 41 ENGINE OIL – GASOLINE VEHICLES See General Warnings on page 9. Even though the low oil warning light on the dash should illuminate if oil level becomes low, engine oil levelshould be checked m...
Page 44 - See WARNING “To avoid unintentionally start-; counterclockwise, and allow the engine oil to drain into the pan.; gloves when handling oil drain plug, oil filter, and oil drain pan.; sion washer remains on the drain plug.
Engine Oil – Gasoline Vehicles Page 42 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual 3. Disconnect the battery cables, negative (–) cable first . See WARNING “To avoid unintentionally start- ing...” on page10. 4. Position a pan designed for oil changes under the front drain pl...
Page 45 - OIL VISCOSITY; Figure 29 Remove Engine Oil Filter
Engine Oil – Gasoline Vehicles 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 43 10. Use a clean rag and wipe the oil filter mounting bracket surface clean where the oil filter gasket seats. 11. Install a new oil filter (Husqvarna 603 00 00-06) onto the engine oil filter p...
Page 46 - Fueling Instructions – Gasoline Vehicles; FUELING INSTRUCTIONS – GASOLINE VEHICLES; • Turn the key switch to the OFF position before fueling.; See Preparing the; See preceding CAUTION.; Replace fuel cap on tank. Ensure cap is tightened securely.
Fueling Instructions – Gasoline Vehicles Page 44 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual FUELING INSTRUCTIONS – GASOLINE VEHICLES See General Warnings on page 9. ý DAN G E R • Turn the key switch to the OFF position before fueling. • Do not pour gasoline into the fuel ta...
Page 47 - Cleaning the Vehicle; CLEANING THE VEHICLE; ACCESSORIES; Figure 32 Fuel Tank
Cleaning the Vehicle 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 45 CLEANING THE VEHICLE Husqvarna vehicles are equipped with ABS front bodies and TPO for rear bodies. Use only commerciallyavailable automotive cleaners with a sponge or soft cloth for normal cleaning. A ...
Page 48 - Vehicle Specifications; VEHICLE SPECIFICATIONS; SPECIFICATIONS
Vehicle Specifications Page 46 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual VEHICLE SPECIFICATIONS SPECIFICATIONS Electric HUV4210-E Electric HUV4210- EXP Gasoline HUV4210-G Gasoline HUV4210- GXP POWER SOURCE Drive motor: Direct drive, 48 volts DC, shunt-wound, 3.2 hp • Engin...
Page 50 - LIMITED TWO YEAR / 2000 HOUR WARRANTY
Page 48 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual HUSQVARNA ® LIMITED TWO YEAR WARRANTY FOR 2005 TRANSPORTATION AND UTILITY VEHICLES 1. WARRANTY: HUSQVARNA, INC., ("HUSQVARNA") hereby warrants to the Original Retail Purchaser that its new 2005 ModelTransportation a...
Page 52 - WARRANTY LIMITATIONS; HUSQVARNA
Page 50 2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual battery, a prudent owner will read and study the charger owner's manual, the electric vehicle owner's manual, the operatorinstructions, and the battery warning labels; and will exercise due care in working on or around batt...
Page 55 - CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT
2005 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 53 CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT Your new Husqvarna, Inc. ("HUSQVARNA") vehicle engine complies with both the U.S. EPA and State of California emission regulations. Husqvarna provides the same emission...
Page 56 - an; Publication Part Number
HUV4213 Gasoline Vehicles 20 05 O w ne r' s M an ua l Husqvarna Forest and Garden 7349 Statesville Rd.Charlotte, NC 28269USAwww.usa.husqvarna.com/huv Publication Part Number 603 00 20-02 Edition Code 0505B0705A