Quadra-Fire Isle Royale - Manual
Quadra-Fire Isle Royale – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Isle Royale Wood Stove; and Welcome to the Quadra-Fire Family; ATTENTION; SA; LABEL LOCATION: ON THE BACK OF THE STOVE; Serial Number
- Page 3 – TABLE OF CONTENTS
- Page 4 – NEVER DRAW; INSTALLATION MATERIALS NEEDED FOR YOUR SAFETY
- Page 5 – FRONT VIEW; DL double wall connector or any listed double-wall connector pipe.; LABEL IS LOCATED ON THE BACK OF THE STOVE; CL; SIDE VIEW; Shown with Hearth; NOTE: If Hearth Legs
- Page 6 – FOR TOP VENT INSTALLATIONS:; heat shield and the following clearances.; FOR REAR VENT INSTALLATIONS:
- Page 7 – In USA installations,; Minimum; WHEN LOCATING YOUR STOVE; LOCATING YOUR STOVE
- Page 8 – REVERSIBLE FLUE COLLAR; CONVERTING COLLAR FOR REAR VENT INSTALLATION; Mounting Screws; Bend Flange Down; Please note this cover plate will not; REAR FLUE DEFLECTOR COVER PLATE; Calculating Alternate Floor Protection; Material; Thermal Conductivity: k value
- Page 9 – NOTE; CHIMNEY HEIGHT REQUIREMENTS / DRAFT; will
- Page 10 – Figure 10A - Chimney Connector; MASONRY CHIMNEY; See Figure 10B
- Page 11 – SOLID PACK CHIMNEY WITH METAL SUPPORTS AS A THIMBLE; TO COMBUSTIBLES AS REFERENCED ON PAGES 6,7.
- Page 14 – make sure it is safety listed, Type UL 103 HT; CONNECTION TO A METAL PREFABRICATED CHIMNEY; ERS’ INSTALLATION INSTRUCTIONS AND; Figure 14A - Exterior Chimney
- Page 15 – Refer to page 6t; MOBILE HOME INSTALLATION; WARNING: DO NOT INSTALL
- Page 16 – Items Needed for Installation; OUTSIDE AIR KIT INSTALLATION; and; INSTALLATION OF OPTIONAL BLOWER; If Necessary; The blower speed control for this unit is adjusted at the factory,
- Page 17 – BURNING PROCESS; before reloading; OPERATING INSTRUCTIONS; IMPORTANT - PLEASE READ BEFORE USING STOVE; PRIMARY AIR SYSTEM; Primary Slide Control; SLIDE LEFT; OPEN; Primary Air
- Page 18 – See; OPERATING THE TOP LOADING OPTION; ALSO BECOME HOT DURING OPERATION.; HEAT OUTPUT SETTINGS; NOTE: These are approximate settings, and will vary; Due to altitude and; wide open for 5 to 15 minutes.; *Primary Air Slide Control
- Page 19 – OPACITY; . Place several wads of crushed paper on the firebox floor.; WARNING! DO NOT LEAVE THE FIRE UNATTENDED WHEN THE; BUILDING A FIRE
- Page 20 – WOOD SELECTION AND STORAGE; Burn only dry seasoned wood!; WITHIN THE SPACE REQUIRED FOR FUELING AND ASH REMOVAL; on at your desired rate.; OPTIONAL BLOWER OPERATING INSTRUCTIONS; the following burn rates:; lose; the; MEDIUM LOW
- Page 21 – CHIMNEY CLEANING; MAINTENANCE; ASH REMOVAL & DISPOSAL; OVERFIRING
- Page 22 – OTE: Remove all labels from glass prior to lighting; GLASS CARE; Clean plated surfaces with vinegar or a glass cleaner before
- Page 23 – FIREBRICK REPLACEMENT; mark the desired brick and take it to your authorized dealer.; Nbr
- Page 25 – Service Parts; NOTE: Order glass & gasketing separately with door frames; Accessories; you can install an Outside Air Kit or Blower, but not both.; Appliances
- Page 26 – Date of Service; Service and Maintenance Log
- Page 27 – Lifetime Warranty; LIMITED LIFETIME WARRANTY; THREE YEAR WARRANTY; CONDITIONS
- Page 28 – CAUTION; Hearth & Home Technologies; CONTACT INFORMATION; For the number of your nearest Quadra-Fire dealer,; Your Records for Model:
SAVE THESE INSTRUCTIONS
www.quadrafire.com
This manual contains instructions for Installation, Operation & Maintenance.
Please read this entire manual before you install and use your new room heater. Failure to follow
instructions may result in property damage, bodily injury, or even death.
Isle Royale
Non-Catalytic, Top-load, Wood Heater
O - T L
Tested and
Listed by
Beaverton
Oregon USA
OMNI-Test Laboratories, Inc.
C
250-5763B February 4, 2005
PRIOR TO FIRST FIRE: Remove all labels from glass. Clean plated surfaces with a glass cleanser and soft
cloth to prevent staining from fingerprint oils.
IMPORTANT SAFETY NOTES:
1) When installing your stove, particular attention should be paid to fire protection. If this room heater is not
properly installed, a house fire may result. To reduce the risk of fire, follow the installation instructions. Contact
local building or fire officials or authority having jurisdiction about restrictions, installation inspection and
permit requirements in your area.
2) CAUTION: Never use gasoline or gasoline-type lantern fuel, kerosene, charcoal lighter fluid, or similar liquids to
start or “freshen up” a fire in this heater. Keep all such liquids well away from heater while it is in use.
3) During operation, if any part of the stove starts to glow, the stove is in an overfired condition. Close the air controls
completely until the glowing has stopped.
OVERFIRING VOIDS YOUR WARRANTY!
4) Cool ashes should be disposed of carefully, using a metal container.
5) Do not burn wet or green wood. Store wood in a dry location.
6)
DO NOT BURN GARBAGE OR FLAMMABLE FLUIDS SUCH AS GASOLINE, NAPHTHA OR ENGINE
OIL.
Do not burn treated wood, or wood with salt (driftwood, etc.). Burning materials other than wood
(including charcoal) under adverse conditions may generate carbon monoxide in the home, resulting in
illness or possible death.
7) Do not permit creosote or soot to accumulate excessively in the chimney or inside the firebox.
8) Check your chimney system thoroughly when installing into an existing metal or masonry chimney. Seek
professional advice if in doubt about its condition.
9) Do not connect this unit to a chimney flue already serving another appliance.
10) Comply with all minimum clearances to combustibles as shown in this manual for this appliance.
11) Build fire on brick firebox floor. Do not use grates, andirons or other methods to support fuel.
12)
HOT WHILE IN OPERATION!
Keep children, pets, clothing and furniture away. Contact can cause skin burns.
13) Do not connect to any air distribution duct or system
14)
RISK OF FIRE!
Do not operate with stove door open, without the firescreen, or ash removal system door open.
15) For further information refer to NFPA 211 (USA) or CAN/CSA-B365 (Canada).
16) Do not operate without fully assembling all components. Burning your stove without the legs attached (if supplied
with unit) will void your warranty, and could present a serious safety hazard
17) Do not oeprate with broken glass..
1445 North Highway
Colville, WA 99114-2008
R
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
R Page 2 February 4, 2005 Isle Royale Wood Stove 250-5763B and Welcome to the Quadra-Fire Family ! Hearth & Home Technologies welcomes you to our tradi- tion of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality, durabil- ity, and performance.This co...
Page 3 Isle Royale Wood Stove R February 4, 2005 250-5763B Listings & Safety Notices ........................................3 Serial Number Label Location .................................2 Pre-Use Checklist .....................................................3 Dimensions ........................
R Page 4 February 4, 2005 Isle Royale Wood Stove 250-5763B LISTINGS and SAFETY NOTICES WARNING ! DO NOT ATTEMPT TO OPERATE THIS WOODSTOVE WITHOUT READING AND UNDERSTANDING THESE OPERATING INSTRUCTIONS THOROUGHLY. FAILURE TO OPERATE THIS APPLIANCE PROPERLY MAY CAUSE A HOUSE FIRE. WARNING ! THE OUTSID...
