Quadra-Fire CB1200 - Manuals

Page 2 - and Welcome to the Quadra-Fire Family; SAMPLE SERIAL NUMBER / SAFETY LABEL LOCATION:; SA; Report Number

Page 2 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR and Welcome to the Quadra-Fire Family ! Hearth & Home Technologies welcomes you to our tradi - tion of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality, durabil - ity, and performance.Th...

Page 3 - Page; TABLE OF CONTENTS

RR R September 21, 2006 7014-082B Page CB 1200 Pellet Stove Section 1: Listing and Code Approvals A. Appliance Certifications ...................... 4 B. Mobile Home Approved ...................... 4 C. Glass Specifications ............................ 4 D. Electrical Rating ...........................

Page 4 - Listing and Code Approvals; A. Appliance Certification

Page 4 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR 1 Listing and Code Approvals A. Appliance Certification C. Glass Specifications E. BTU & Efficiency Specifications This appliance is equipped with 5mm ceramic glass. Replace glass only with 5mm ceramic glass. Please contact your deale...

Page 5 - Getting Started; Considerations; Appliance Location; CAUTION; • Do NOT connect this unit to a chimney flue servicing; WARNING; • Do not operate appliance before reading

RR R September 21, 2006 7014-082B Page 5 CB 1200 Pellet Stove 2 Getting Started A. Design, Installation & Location Considerations 1. Appliance Location Consideration must be given to safety, convenience, traffic flow, and the fact that the appliance will need a chimney and chimney connector. It ...

Page 6 - Tools and building supplies normally required; C. Tools And Supplies Needed; Or any such action that may cause a fire hazard.; D. Measuring Standards

Page 6 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR E. Inspect Appliance & Components and Pre-Use Check List Reciprocating Saw Channel Locks Hammer Phillips Screwdriver Tape Measure Plumb Line Level Framing Material Hi-temp Caulking Material Gloves Safety Glasses Framing Square Electri...

Page 7 - Page 7; Dimensions and Clearances; A. Appliance Dimensions; CL; Figure 7.2 - Top View with Top Vent Adapter

RR R September 21, 2006 7014-082B Page 7 CB 1200 Pellet Stove 3 Dimensions and Clearances A. Appliance Dimensions 5.0 in (127mm) 4-5/8 in ( 1 18mm) 12-/8 in (14mm) 14-1/4 in (62mm) 2-1/2 in (64mm) C L 8-1/6 in. (205mm) 20- 7/16 in. (519mm) 28-1/2 in. (724mm) 27-5/8 in. (692mm) 25-/4 in. (654mm) C L ...

Page 9 - for Horizontal Installations:; Hearth Pad Requirements

RR R September 21, 2006 7014-082B Page 9 CB 1200 Pellet Stove *L Exception for Horizontal Installations: USA INSTALLATIONS : A non-combustible floor protec - tion is recommended extending beneath the flue pipe when installed with horizontal venting or under the top vent adapter with vertical install...

Page 10 - Vent surfaces get HOT, can cause burns if; A. Chimney and Exhaust Connection; approved venting specifically designed for corn. Follow; Substitute or damaged vent components may; B. Venting Termination Requirements; Vent Information

Page 10 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR Do not terminate vent in any enclosed or semi-enclosed area such as a carport, garage, attic, crawl space, under a sun deck or porch, narrow walkway or closely fenced area, or any location that can build up a concentration of fumes such ...

Page 11 - ALTITUDE IN THOUSANDS OF FEET; D. Pipe Selection Chart

RR R September 21, 2006 7014-082B Page 11 CB 1200 Pellet Stove Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to the owner’s information manual provided with this appli - ance. For assistance or additional information consult a qualif...

Page 12 - Venting Systems; Illustrations reflect typical installations and are FOR; All minimums listed are to a combustible surface.; Alcove Installation

Page 12 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR 5 Venting Systems NOTE: • Illustrations reflect typical installations and are FOR DESIGN PURPOSES ONLY . • Illustrations/diagrams are not drawn to scale. • Actual installation may vary due to individual design preference. A. Alcove Figur...

Page 13 - Page 1; ini; Straight Out; Horizontal termination cap must be a minimum of 12 inches.; Illustration shows venting going in both directions.

RR R September 21, 2006 7014-082B Page 1 CB 1200 Pellet Stove 12 in. (05mm) M ini m u m Non-combustible Hearth Pad Wall Thimble Horizontal Termination Cap 2 in. (51mm) Minimum 6 in. (152mm) Minimum From Glass Straight Out B. Through The Wall Horizontal termination cap must be a minimum of 12 inches....

Page 15 - F. Alternate Masonry

RR R September 21, 2006 7014-082B Page 15 CB 1200 Pellet Stove Fire HazardInspection of Chimney:• Masonry chimney must be in good condition.• Meets minimum standard of NFPA 211• Factory-built chimney must be 6 in. (152mm) UL10 HT. WARNING E. Masonry F. Alternate Masonry Non-Combustible Hearth Pad Ai...

Page 16 - Mobile Home; pages 8; You must use a Quadra-Fire Outside Air Kit

Page 16 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR 6 Mobile Home 1. An outside air inlet must be provided for the combustion air and must remain clear of leaves, debris, ice and/or snow. It must be unrestricted while the appliance is in use to prevent room air starvation which causes smo...

Page 17 - A. Outside Air Kit Instructions; Never draw outside combustion air from:; Rear Installation; Floor Installation; Secure Collar

RR R September 21, 2006 7014-082B Page 17 CB 1200 Pellet Stove 7 Appliance Set-Up A. Outside Air Kit Instructions Flex Hose Hose Clamp Collar Assembly Trim Rin g Terminatio n Cap Assembly Hose Clamp Included in Kit: 1 piece of 2 inch x foot flex hose, 2 hose clamps, 1 collar assembly, termination ca...

Page 18 - to 3 inch Top Vent Adapter; B. Top Vent Adapter Installation; Installing the Top Vent Adapter; C. Rear Vent and Rear Vent to Top Vent

Page 18 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR 3 to 3 inch Top Vent Adapter 3 to 6 inch Top Vent Offset Adapter 1. Put a layer of high temperature silicone on the inch (76mm) exhaust outlet. 2. Slide the top vent adapter onto the rear exhaust outlet and adjust the assembly to a verti...

Page 19 - D. Brick Set Installation; Note: Figure 19.5 shows the finished shape of the brick; Installed Clip; E. Brick Clip Installation

RR R September 21, 2006 7014-082B Page 19 CB 1200 Pellet Stove D. Brick Set Installation 1. Remove the baffle first, follow instructions on page 32 . 2. Slide bottom of left rear brick in first; rotate top edge toward rear of appliance and then rotate outer edge toward rear of appliance, until brick...

Page 20 - G. Optional Gold or Nickel Grille Assembly; Logs are FRAGILE. Use extreme care when handling or; LOCATING PINS; Right Twig; Install Logo; Do not open top all the way back so the weight of the; It will damage the; It will be necessary to prop the top up with

Page 20 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR G. Optional Gold or Nickel Grille Assembly 1. Place the front log in first as shown in Figure 20.1 . Place log between firepot and face of appliance with charred area surrounding firepot. 2. Set the left and right twigs onto the log, pla...

Page 21 - J. Thermostat Installation; • Do NOT remove grounding prong from plug.; I. Door Installation; Rod and nut

RR R September 21, 2006 7014-082B Page 21 CB 1200 Pellet Stove 1 . A 12 volt AC thermostat is required to operate this pellet appliance. You may use the included wall mount thermo - stat or purchase an optional programmable thermostat or remote control. It is equipped with an adjustable heat anticip...

Page 22 - Operating Instructions; A. Fuel Size And Material; If you; Shelled Field Corn; B. General Operating Information; Thermostat Calls For Heat

Page 22 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR 8 Operating Instructions A. Fuel Size And Material 1. Wood Pellets Fuel pellets are made from sawdust or wood by-products. If the source material is hardwood, they can have a higher mineral content, creating more ash. Fuels containing ba...

Page 23 - D. Fuel Adjustment Rod; set; F. Fire Characteristics; IMPORTANT DETAIL: The tip of the thermocouple must; G. Feed Rate Adjustment Instructions

RR R September 21, 2006 7014-082B Page 2 CB 1200 Pellet Stove D. Fuel Adjustment Rod The set screw is located at the bottom of the hopper and set loose at the factory so the fuel adjustment control rod will slide up and down by only loosening the thumb screw at the top. See Figure 23.1. Do not re-ti...

Page 24 - page; I. Frequently Asked Questions; ISSUES; Figure 24.1 - DO NOT LEAVE FIREPOT FLOOR OPEN

Page 24 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR H. Ignition Cycles 1. During each ignition cycle, it is normal to see some smoke in the firebox. The smoke will stop once the fire starts. 2. The convection blower will automatically turn on after your appliance has reached the set tempe...

Page 25 - Troubleshooting; Symptom; Possible Cause

RR R September 21, 2006 7014-082B Page 25 CB 1200 Pellet Stove 9 Troubleshooting With proper installation, operation, and maintenance your appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a qualified service person in the di...

Page 27 - Symptoms

RR R September 21, 2006 7014-082B Page 27 CB 1200 Pellet Stove Symptoms Possible Cause Corrective Action Convection blower fails to start. #1 snap disc defective. Blower not plugged in. Blower is defective. Control box is defective. Replace snap disc. Check that blower is plugged into wire har - nes...

Page 28 - Maintaining & Servicing Your Appliance; NOTE: Remove optional log set if installed.; B. General Maintenance; Cleaning Firepot with Cleaning Rod & Firepot; Shock and Smoke Hazard; A. Proper Shutdown Procedure

Page 28 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR 10 Maintaining & Servicing Your Appliance Figure 26.1 - Large Clinker 4. Cleaning Ash Drawer• Frequency: As needed • By: Homeowner • Task: The ash drawer is located in the pedestal. To remove and empty the ash drawer, open both the l...

Page 29 - Heat exchanger cleaning rods may be warm; There are heavy duty vacuum cleaners specifiically; Cleaning Rods

RR R September 21, 2006 7014-082B Page 29 CB 1200 Pellet Stove 6. Ash Removal from Firebox (Cont’d) c. See Cleaning Ash Drawer for instructions to remove the ash drawer. d. This ash is deposited in the same ash drawer as the firepot debris. The ash drawer should be emptied every time you clean the f...

Page 30 - Cleaning the Top Vent Adapter; Cleaning Convection Blower - Requires No

Page 0 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR Clean Out Cover Figure 28.1 16. Cleaning the Top Vent Adapter a. The appliance must be in complete shutdown and the exhaust blower should be off. Allow the appliance to completely cool down. b. Open the clean-out cover. See Figure 28.1. c...

Page 31 - Figure; C. High Ash Fuel Content Maintenance; Convection Blower Replacement; D. Blower Replacement

RR R September 21, 2006 7014-082B Page 1 CB 1200 Pellet Stove Correct Flame Size, Yellow/White in Colo r Correct Figure 31.3 Ash Build Up in Firebox Pellets Back Up In Feed Tube Firepot Overfills Tall, Lazy Flame, Orange in Colo r Incorrect Figure 31.1 Figure 31.2 Poor quality pellet fuel, or lack o...

Page 32 - Exhaust Blower Replacement; E. Igniter Replacement; Igniter; Remove existing blower:

Page 2 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR 2. Exhaust Blower Replacement E. Igniter Replacement F. Baffle Removal 1. Use proper shut down procedures to shut down the appliance and let it completely cool down and then unplug it and remove the ash drawer. 2. Follow instructions to r...

Page 33 - G. Glass Replacement; • Glass is 5mm thick high temperature heat-; Replacing Center Glass; DO NOT LET Air Wash Spacers fall down from

RR R September 21, 2006 7014-082B Page CB 1200 Pellet Stove G. Glass Replacement • Glass is 5mm thick high temperature heat- resistant ceramic glass. • DO NOT REPLACE with any other material.• Alternate material may shatter and cause injury. WARNING Figure 33.1 • Remove door from appliance and place...

Page 34 - Reference Materials; Heat Output Switch; When describing the location of a component,; Convection Blower

Page 4 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR 11 Reference Materials 7. Heat Exchangers The heat exchangers transfer hot air from the exhaust system into convection air. Lift the stove top to access the heat exchangers. There are 2 clean out rods located under the heat exchangers. 8 ...

Page 35 - Wiring Harness

RR R September 21, 2006 7014-082B Page 5 CB 1200 Pellet Stove 16. Snap Disc #1 (Convection Blower) 145°F Snap disc #1 is located on the right side of the appliance on the top of the heat exchanger box. There are 2 purple wires connected to it. This snap disc turns the convection blower on and off as...

Page 36 - Page 6; B. Component Locations; Power Outlet

Page 6 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR B. Component Locations Heat Output Fan Speed Reset Button Call Light HIGH HIGH MED LOW LOW Power Outlet Terminal Block. Center 2 screws for Thermostat Wires Outside Air Flex Hose Convection Blower Cleaning Rods Heat Exchanger Tubes Figure...

Page 38 - Nbr

Page 8 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR Figure 38.1 2 24 25 26 27 28 29 0 1 2 4 5 6 7 8 9 40 41 42 4 44 45 46 47 48 Nbr Description 2 Door Assembly 24 Ash Pan 25 Panel Access, Front (Firepot) 26 Latch, Draw 27 Director, Air, Large 28 Director, Air, Small 29 Grille, Louvers 0 Kn...

Page 40 - Fire web site at; D. Service Parts and Accessories

Page 40 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR IMPORTANT: THIS IS DATED INFORMATION. The most current information is located on the Quadra- Fire web site at www.quadrafire.com . When ordering, supply serial and model numbers to ensure correct service parts. D. Service Parts and Acces...

Page 41 - Appliance; Classic Bay 1200 Pellet Stove; Accessories

RR R September 21, 2006 7014-082B Page 41 CB 1200 Pellet Stove Appliance Part No. Classic Bay 1200 Pellet Stove CB1200 Glass Assembly, Left or Right, 1 pc 510-5410 Grille, Bar, Bottom 410-80 4 Glass Frame Post 410-6240 5 Glass Frame Side 410-4740 7 Glass Frame Spacer 410-6250 8 Glass Frame, Top &...

Page 42 - Date of Service; E. Service And Maintenance Log

Page 42 7014-082B September 21, 2006 R CB 1200 Pellet Stove RR Date of Service Performed By Description of Service E. Service And Maintenance Log

Page 43 - Page 4; Lifetime Warranty; LIMITED LIFETIME WARRANTY; the first five years.; THREE YEAR WARRANTY; cident, or misuse of the product shall nullify this warranty.

RR R September 21, 2006 7014-082B Page 4 CB 1200 Pellet Stove Lifetime Warranty F. Warranty Policy LIMITED LIFETIME WARRANTY The Hearth & Home Technologies limited Lifetime Warranty guarantees that the following components will work as designed for the lifetime of the stove or Hearth & Home ...

Page 44 - CONTACT INFORMATION; For the number of your nearest Quadra-Fire dealer; Your Records for Model:

R Hearth & Home Technologies 1445 North Highway Colville, WA 99114 Division of HNI INDUSTRIES www.quadrafire.com 7014-082B September 21, 2006 Page 44 CONTACT INFORMATION : Please contact your Quadra-Fire dealer with any questions or concerns. For the number of your nearest Quadra-Fire dealer ple...