Quadra-Fire Isle Royale - Manuals

Quadra-Fire Isle Royale – Manual in PDF format online.

Manuals:

Manual

Manual Quadra-Fire Isle Royale

Summary

Page 2 - Isle Royale Wood Stove; and Welcome to the Quadra-Fire Family; ATTENTION; SA; LABEL LOCATION: ON THE BACK OF THE STOVE; Serial Number

R Page 2 February 4, 2005 Isle Royale Wood Stove 250-5763B and Welcome to the Quadra-Fire Family ! Hearth & Home Technologies welcomes you to our tradi- tion of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality, durabil- ity, and performance.This co...

Page 3 - TABLE OF CONTENTS

Page 3 Isle Royale Wood Stove R February 4, 2005 250-5763B Listings & Safety Notices ........................................3 Serial Number Label Location .................................2 Pre-Use Checklist .....................................................3 Dimensions ........................

Page 4 - NEVER DRAW; INSTALLATION MATERIALS NEEDED FOR YOUR SAFETY

R Page 4 February 4, 2005 Isle Royale Wood Stove 250-5763B LISTINGS and SAFETY NOTICES WARNING ! DO NOT ATTEMPT TO OPERATE THIS WOODSTOVE WITHOUT READING AND UNDERSTANDING THESE OPERATING INSTRUCTIONS THOROUGHLY. FAILURE TO OPERATE THIS APPLIANCE PROPERLY MAY CAUSE A HOUSE FIRE. WARNING ! THE OUTSID...

Page 5 - FRONT VIEW; DL double wall connector or any listed double-wall connector pipe.; LABEL IS LOCATED ON THE BACK OF THE STOVE; CL; SIDE VIEW; Shown with Hearth; NOTE: If Hearth Legs

Page 5 Isle Royale Wood Stove R February 4, 2005 250-5763B DIMENSIONS FRONT VIEW SIDE VIEW 29" (737mm) 28-3/4" (730mm) 30" (762mm) CL 8-1/4" (210mm) 16-1/2" (419mm) 24-5/8" (625mm) 26-7/16" (570mm) 30" (762mm) 22-3/4" (578mm) 16-3/4" (425mm) VENT SPECIFICATION...

Page 6 - FOR TOP VENT INSTALLATIONS:; heat shield and the following clearances.; FOR REAR VENT INSTALLATIONS:

R Page 6 February 4, 2005 Isle Royale Wood Stove 250-5763B B A C D CLEARANCES TO COMBUSTIBLES (UL and ULC) G H Ceiling E E F F MINIMUM CLEARANCES TO COMBUSTIBLE MATERIALS In Inches & (Millimeters) NOTE: "A" ,"C" and "F" Dimensions are to the inside diameter of the flue co...

Page 7 - In USA installations,; Minimum; WHEN LOCATING YOUR STOVE; LOCATING YOUR STOVE

Page 7 Isle Royale Wood Stove R February 4, 2005 250-5763B FLOOR PROTECTION The floor must be non-combustible material, extending beneath heater and to the front, sides and rear as indicated. The ﬂoor must be non-combustible or otherwise adequately protected from radiant heat given off by the unit a...

Page 8 - REVERSIBLE FLUE COLLAR; CONVERTING COLLAR FOR REAR VENT INSTALLATION; Mounting Screws; Bend Flange Down; Please note this cover plate will not; REAR FLUE DEFLECTOR COVER PLATE; Calculating Alternate Floor Protection; Material; Thermal Conductivity: k value

R Page 8 February 4, 2005 Isle Royale Wood Stove 250-5763B REVERSIBLE FLUE COLLAR The ﬂue collar is reversible for either a top or rear venting installation. The unit is shipped with the ﬂue collar in the top vent position. CONVERTING COLLAR FOR REAR VENT INSTALLATION 1. Remove 5 Phillips head screw...

Page 9 - NOTE; CHIMNEY HEIGHT REQUIREMENTS / DRAFT; will

Page 9 Isle Royale Wood Stove R February 4, 2005 250-5763B To be sure that your stove burns properly, the chimney draft (static pressure) should be approximately -.04” water column (W.C.) during a low burn and -.10” W.C. during a high burn, measured 6 inches (152mm) above the top of the stove after ...

Page 10 - Figure 10A - Chimney Connector; MASONRY CHIMNEY; See Figure 10B

R Page 10 February 4, 2005 Isle Royale Wood Stove 250-5763B Thimble Assembly: 12" (305mm) of brick separation between clay liner and combustibles. Fireclay liner 5/8" (16mm) Minimum or Equivalent. Sill support Header Wood Stud 2" (51mm) Clearance from chimney wall Fireclay liner 5/8"...

Page 11 - SOLID PACK CHIMNEY WITH METAL SUPPORTS AS A THIMBLE; TO COMBUSTIBLES AS REFERENCED ON PAGES 6,7.

Page 11 Isle Royale Wood Stove R February 4, 2005 250-5763B SOLID PACK CHIMNEY WITH METAL SUPPORTS AS A THIMBLE Figure 11A Center of Hole Wall Center Line Opening Center Line CL 26-7/16" (570mm) Add the 26-7/16 inches (671mm), center-line measurement to the depth measurement of your ﬂoor protect...

Page 14 - make sure it is safety listed, Type UL 103 HT; CONNECTION TO A METAL PREFABRICATED CHIMNEY; ERS’ INSTALLATION INSTRUCTIONS AND; Figure 14A - Exterior Chimney

R Page 14 February 4, 2005 Isle Royale Wood Stove 250-5763B When a metal prefabricated chimney is used, the manufac- turer’s installation instructions must be followed precisely. It will be necessary to install the ceiling support package or wall pass through, “T” section package, ﬁrestops (when nee...

Page 15 - Refer to page 6t; MOBILE HOME INSTALLATION; WARNING: DO NOT INSTALL

Page 15 Isle Royale Wood Stove R February 4, 2005 250-5763B Spark Arestor Cap Roof Flashing Storm Collar Joist Shield/Firestop Listed Chimney Connector Floor Protector Outside Air Kit Connector Outside Air Floor Vent 1 . An outside air inlet must be provided for combustion and must remain clear of l...

Page 16 - Items Needed for Installation; OUTSIDE AIR KIT INSTALLATION; and; INSTALLATION OF OPTIONAL BLOWER; If Necessary; The blower speed control for this unit is adjusted at the factory,

R Page 16 February 4, 2005 Isle Royale Wood Stove 250-5763B OUTSIDE AIR TERMINATION CAP (contains rodent screen) FLEX FLANGE 1 . Remove all materials from packing box. 2. Mount the ﬂex ﬂange (with pipe ﬁtting extending out), over the intake air opening at the rear of stove using the four mounting sc...

Page 17 - BURNING PROCESS; before reloading; OPERATING INSTRUCTIONS; IMPORTANT - PLEASE READ BEFORE USING STOVE; PRIMARY AIR SYSTEM; Primary Slide Control; SLIDE LEFT; OPEN; Primary Air

Page 17 Isle Royale Wood Stove R February 4, 2005 250-5763B BURNING PROCESS In recent years there has been an increasing concern about air quality. Much of the blame for poor air quality has been placed on the burning of wood for home heating. In order to improve the situation, we at Quadra-Fire hav...

Page 18 - See; OPERATING THE TOP LOADING OPTION; ALSO BECOME HOT DURING OPERATION.; HEAT OUTPUT SETTINGS; NOTE: These are approximate settings, and will vary; Due to altitude and; wide open for 5 to 15 minutes.; *Primary Air Slide Control

R Page 18 February 4, 2005 Isle Royale Wood Stove 250-5763B WARNING! DO NOT LEAVE THE FIRE UNATTENDED WHEN THE DOOR IS UNLATCHED OR WHEN USING THE FIRESCREEN. UNSTABLE FIREWOOD COULD FALL OUT OF THE FIREBOX CREATING A FIRE HAZARD TO YOUR HOME. WARNING! ALWAYS OPERATE THIS APPLIANCE WITH THE DOOR CLO...

Page 19 - OPACITY; . Place several wads of crushed paper on the firebox floor.; WARNING! DO NOT LEAVE THE FIRE UNATTENDED WHEN THE; BUILDING A FIRE

Page 19 Isle Royale Wood Stove R February 4, 2005 250-5763B OPERATING INSTRUCTIONS (Cont’d) OPACITY This helps to determine how cleanly your stove is burning. Opacity is measured in percent; 100% opacity is when an object is totally obscured by the smoke column from a chimney, and 0% opacity means t...

Page 20 - WOOD SELECTION AND STORAGE; Burn only dry seasoned wood!; WITHIN THE SPACE REQUIRED FOR FUELING AND ASH REMOVAL; on at your desired rate.; OPTIONAL BLOWER OPERATING INSTRUCTIONS; the following burn rates:; lose; the; MEDIUM LOW

R Page 20 February 4, 2005 Isle Royale Wood Stove 250-5763B OPERATING INSTRUCTIONS (Cont’d) WOOD SELECTION AND STORAGE Burn only dry seasoned wood! This will not only minimize creosote formation, but also provide the most efﬁcient heat output. Even dry wood contains at least 15% moisture by weight a...

Page 21 - CHIMNEY CLEANING; MAINTENANCE; ASH REMOVAL & DISPOSAL; OVERFIRING

Page 21 Isle Royale Wood Stove R February 4, 2005 250-5763B CHIMNEY CLEANING 1. Remove all ash from the ﬁrebox and extinguish all hot embers before disposal. Allow the stove to cool com- pletely. 2. Close the door tightly and proceed with sweeping the chimney. 3. Sweep the collected ashes into the a...

Page 22 - OTE: Remove all labels from glass prior to lighting; GLASS CARE; Clean plated surfaces with vinegar or a glass cleaner before

R Page 22 February 4, 2005 Isle Royale Wood Stove 250-5763B N OTE: Remove all labels from glass prior to lighting the ﬁrst ﬁre. GLASS CARE 1. Ensure that the ﬁre is out and the appliance is cool to the touch. 2. Protect a table or counter top with padding or towels.3. Remove door with broken glass f...

Page 23 - FIREBRICK REPLACEMENT; mark the desired brick and take it to your authorized dealer.; Nbr

Page 23 Isle Royale Wood Stove R February 4, 2005 250-5763B DOOR & GASKET Periodically check the door gasket for proper seal. As the gasket compresses or “seats” during use, it may become necessary to adjust or tighten the door latch either by removing spacer washers, shown below (at least one w...

Page 25 - Service Parts; NOTE: Order glass & gasketing separately with door frames; Accessories; you can install an Outside Air Kit or Blower, but not both.; Appliances

Page 25 Isle Royale Wood Stove R February 4, 2005 250-5763B Service Parts Serial No. Part No. Brick Set 834-3860 Brick, single (See page 23 for dimensions) 832-0550 Door Handle Only, Fiber SRV433-1380 Door Handle Assembly,(includes cam latch & key, gasketing, ﬁber handle and screw adapter. Also ...

Page 26 - Date of Service; Service and Maintenance Log

R Page 26 February 4, 2005 Isle Royale Wood Stove 250-5763B Date of Service Performed By Description of Service Service and Maintenance Log

Page 27 - Lifetime Warranty; LIMITED LIFETIME WARRANTY; THREE YEAR WARRANTY; CONDITIONS

Page 27 Isle Royale Wood Stove R February 4, 2005 250-5763B Lifetime Warranty LIMITED LIFETIME WARRANTY The Hearth & Home Technologies limited Lifetime Warranty guarantees that the following components will work as designed for the lifetime of the stove or Hearth & Home Technologies will rep...

Page 28 - CAUTION; Hearth & Home Technologies; CONTACT INFORMATION; For the number of your nearest Quadra-Fire dealer,; Your Records for Model:

R February 4, 2005 Page 28 • Do NOT discard this manual.• Important operating and maintenance instructions included. • Read, understand and follow these instruci- tons for safe installation and operation. • Leave this manual with party responsible for use and operation. CAUTION This product may be c...