Quadra-Fire CB1200-B - Manual
Quadra-Fire CB1200-B – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – and Welcome to the Quadra-Fire Family; SAMPLE SERIAL NUMBER / SAFETY LABEL LOCATION:; SA; Report Number
- Page 3 – TABLE OF CONTENTS
- Page 4 – Listing and Code Approvals; A. Appliance Certification
- Page 5 – Getting Started; Considerations; Clearances may only be reduced by means approved; CAUTION; • Do NOT connect this unit to a chimney flue servicing; WARNING; • Do not operate appliance before reading; Appliance Location
- Page 6 – C. Tools And Supplies Needed; Or any such action that may cause a fire hazard.
- Page 7 – Page 7; Dimensions and Clearances; A. Appliance Dimensions; CL; Figure 7.2 - Top View with Top Vent Adapter
- Page 9 – Hearth Pad Requirements
- Page 10 – Vent surfaces get HOT, can cause burns if; A. Chimney and Exhaust Connection; approved venting specifically designed for corn. Follow; Substitute or damaged vent components may; B. Venting Termination Requirements; Vent Information
- Page 11 – D. Pipe Selection Chart; ALTITUDE IN THOUSANDS OF FEET; Example 1
- Page 12 – Venting Systems; Illustrations reflect typical installations and are FOR; All minimums listed are to a combustible surface.; Alcove Installation
- Page 13 – Page 1; Straight Out; Horizontal termination cap must be a minimum of 12 inches.; Illustration shows venting going in both directions.
- Page 15 – F. Alternate Masonry
- Page 16 – Mobile Home; pages 8; You must use a Quadra-Fire Outside Air Kit
- Page 17 – A. Outside Air Kit Instructions; Never draw outside combustion air from:; Rear Installation; Floor Installation; Secure Collar
- Page 18 – B. Top Vent Adapter Installation; Installing the Top Vent Adapter; C. Rear Vent and Rear Vent to Top Vent
- Page 19 – D. Optional Brick Set Installation; Note: Figure 19.5 shows the finished shape of the brick; Installed Clip; E. Brick Clip Installation
- Page 20 – Logs are FRAGILE. Use extreme care when handling or; LOCATING PINS; Top Log; Install Logo; Do not open top all the way back so the weight of the; It will damage the; It will be necessary to prop the top up with
- Page 21 – J. Thermostat Installation; • Do NOT remove grounding prong from plug.; I. Door Installation; Rod and nut
- Page 22 – Operating Instructions; A. Fuel Size And Material; If you; Shelled Field Corn; B. General Operating Information; Thermostat Calls For Heat
- Page 23 – set loose at the factory; F. Feed Rate Adjustment Instructions
- Page 24 – page; H. Frequently Asked Questions; ISSUES; Figure 24.1 - DO NOT LEAVE FIREPOT FLOOR OPEN
- Page 25 – Troubleshooting; Symptom; Possible Cause
- Page 28 – Maintaining & Servicing Your Appliance; C. General Maintenance; Shock and Smoke Hazard; A. Proper Shutdown Procedure; Cleaning or Inspection; Frequency; B. Quick Reference Maintenance Chart; Follow the detailed instructions found in this
- Page 29 – Cleaning Firepot with Cleaning Rod & Firepot
- Page 30 – Handle glass assembly with care.; Contact your local dealer.
- Page 31 – in Exhaust Venting System.; Cleaning the Top Vent Adapter; There are heavy duty vacuum cleaners specifi
- Page 32 – D. High Ash Fuel Content Maintenance; Convection Blower Replacement; E. Blower Replacement; Figure
- Page 33 – Exhaust Blower Replacement; G. Igniter Replacement; Igniter; Remove existing blower:
- Page 34 – H. Glass Replacement; latch, you must remove the door latch first
- Page 35 – Reference Materials; Heat Output Switch; When describing the location of a component,; Convection Blower
- Page 36 – Wiring Harness
- Page 37 – B. Component Locations; Power Outlet; Cleaning Rods
- Page 38 – Page 8
- Page 41 – D. Service Parts and Accessories
- Page 43 – Page 4; Appliance; Classic Bay 1200 Freestanding Pellet Stove; Accessories
- Page 44 – E. Service And Maintenance Log
- Page 46 – Hearth & Home Technologies LIMITED WARRANTY; CONDITIONS, EXCLUSIONS & LIMITATION OF LIABILITY
- Page 48 – CONTACT INFORMATION; For the number of your nearest Quadra-Fire dealer; NOTICE; DO NOT DISCARD THIS MANUAL; DO NOT
R
www.quadrafire.com
7014-082D
September 1, 2008
CLASSIC BAY 1200 PELLET STOVE
O - T L
Tested and
Listed by
Portland
Oregon USA
OMNI-Test Laboratories, Inc.
C
US
Owner’s Manual
Installation and Operation
CB1200-B
Model:
DO NOT DISCARD THIS MANUAL
NOTICE
• Important operating and
maintenance instruc
-
tions included.
•
Leave this manual with
party responsible for use
and operation.
•
Read, understand and
follow these instruc
-
tions for safe installa
-
tion and operation.
DO NOT
DISCARD
WARNING
Please read this entire manual
before installation and use of this
pellet fuel-burning room heater.
Failure to follow these instructions
could result in property damage,
bodily injury or even death.
•
Do not store or use gasoline or other flam
-
mable vapors and liquids in the vicinity of this
or any other appliance.
• Do not overfire - If any external part starts to
glow, you are overfiring. Reduce feed rate.
Overfiring will void your warranty.
• Comply with all minimum clearances to com
-
bustibles as specified. Failure to comply may
cause house fire.
Check building codes prior to installation.
• Installation MUST comply with local, regional, state and national
codes and regulations.
• Consult local building, fire officials or authorities having jurisdic
-
tion about restrictions, installation inspection, and permits.
CAUTION
Tested and approved for wood pellets and shelled
field corn fuel only. Burning of any other type of fuel
voids your warranty.
CAUTION
WARNING
Hot glass will cause burns.
• Do not touch glass until it is cooled
• NEVER allow children to touch glass
• Keep children away
• CAREFULLY SUPERVISE children in same room as
fireplace.
• A l e r t c h i l d r e n a n d a d u l t s t o h a z a r d s o f h i g h
temperatures.
High temperatures may ignite clothing or other
flammable materials.
• Keep clothing, furniture, draperies and other flammable
materials away.
HOT SURFACES!
Glass and other surfaces are
hot during operation AND
cool down.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Page 2 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R and Welcome to the Quadra-Fire Family ! Hearth & Home Technologies welcomes you to our tradi - tion of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality, durabil - ity, and performance.Th...
R R R September 1, 2008 7014-082D Page CB 1200 Pellet Stove Section 1: Listing and Code Approvals A. Appliance Certifications ...................... 4 B. Mobile Home Approved ...................... 4 C. Glass Specifications ............................ 4 D. Electrical Rating ...........................
Page 4 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 1 Listing and Code Approvals A. Appliance Certification C. Glass Specifications E. BTU & Efficiency Specifications This appliance is equipped with 5mm ceramic glass. Replace glass only with 5mm ceramic glass. Please contact your deale...
