Quadra-Fire CB1200-B - Manuals

Page 2 - and Welcome to the Quadra-Fire Family; SAMPLE SERIAL NUMBER / SAFETY LABEL LOCATION:; SA; Report Number

Page 2 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R and Welcome to the Quadra-Fire Family ! Hearth & Home Technologies welcomes you to our tradi - tion of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality, durabil - ity, and performance.Th...

Page 3 - TABLE OF CONTENTS

R R R September 1, 2008 7014-082D Page CB 1200 Pellet Stove Section 1: Listing and Code Approvals A. Appliance Certifications ...................... 4 B. Mobile Home Approved ...................... 4 C. Glass Specifications ............................ 4 D. Electrical Rating ...........................

Page 4 - Listing and Code Approvals; A. Appliance Certification

Page 4 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 1 Listing and Code Approvals A. Appliance Certification C. Glass Specifications E. BTU & Efficiency Specifications This appliance is equipped with 5mm ceramic glass. Replace glass only with 5mm ceramic glass. Please contact your deale...

Page 5 - Getting Started; Considerations; Clearances may only be reduced by means approved; CAUTION; • Do NOT connect this unit to a chimney flue servicing; WARNING; • Do not operate appliance before reading; Appliance Location

R R R September 1, 2008 7014-082D Page 5 CB 1200 Pellet Stove 2 Getting Started A. Design, Installation & Location Considerations B. Fire Safety Maintain the designated clearances to combustibles. Insu - lation must not touch the chimney. You must maintain the designated air space clearance arou...

Page 6 - C. Tools And Supplies Needed; Or any such action that may cause a fire hazard.

Page 6 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R D. Inspect Appliance & Components and Pre-Use Check List Reciprocating Saw Channel Locks Hammer Phillips Screwdriver Tape Measure Plumb Line Level Framing Material Hi-temp Caulking Material Gloves Safety Glasses Framing Square Electri...

Page 7 - Page 7; Dimensions and Clearances; A. Appliance Dimensions; CL; Figure 7.2 - Top View with Top Vent Adapter

R R R September 1, 2008 7014-082D Page 7 CB 1200 Pellet Stove 3 Dimensions and Clearances A. Appliance Dimensions 5.0 in (127mm) 4-5/8 in ( 1 18mm) 12-/8 in (14mm) 14-1/4 in (62mm) 2-1/2 in (64mm) C L 8-1/6 in. (205mm) 20- 7/16 in. (519mm) 28-1/2 in. (724mm) 27-5/8 in. (692mm) 25-/4 in. (654mm) C L ...

Page 9 - Hearth Pad Requirements

R R R September 1, 2008 7014-082D Page 9 CB 1200 Pellet Stove *L Exception for Horizontal Installations: USA INSTALLATIONS : A non-combustible floor protec - tion is recommended extending beneath the flue pipe when installed with horizontal venting or under the top vent adapter with vertical install...

Page 10 - Vent surfaces get HOT, can cause burns if; A. Chimney and Exhaust Connection; approved venting specifically designed for corn. Follow; Substitute or damaged vent components may; B. Venting Termination Requirements; Vent Information

Page 10 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R Do not terminate vent in any enclosed or semi-enclosed area such as a carport, garage, attic, crawl space, under a sun deck or porch, narrow walkway or closely fenced area, or any location that can build up a concentration of fumes such ...

Page 11 - D. Pipe Selection Chart; ALTITUDE IN THOUSANDS OF FEET; Example 1

R R R September 1, 2008 7014-082D Page 11 CB 1200 Pellet Stove Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to the owner’s information manual provided with this appli - ance. For assistance or additional information consult a qualif...

Page 12 - Venting Systems; Illustrations reflect typical installations and are FOR; All minimums listed are to a combustible surface.; Alcove Installation

Page 12 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 5 Venting Systems NOTE: • Illustrations reflect typical installations and are FOR DESIGN PURPOSES ONLY . • Illustrations/diagrams are not drawn to scale. • Actual installation may vary due to individual design preference. A. Alcove Figur...

Page 13 - Page 1; Straight Out; Horizontal termination cap must be a minimum of 12 inches.; Illustration shows venting going in both directions.

R R R September 1, 2008 7014-082D Page 1 CB 1200 Pellet Stove 12 in . (05mm) Minim u m Non-combustible Hearth Pad W all Thimble Horizontal Termination Cap 2 in. (51mm) Minimum 6 in. (152mm) Minimum From Glass Straight Out B. Through The Wall Horizontal termination cap must be a minimum of 12 inches....

Page 15 - F. Alternate Masonry

R R R September 1, 2008 7014-082D Page 15 CB 1200 Pellet Stove Fire HazardInspection of Chimney:• Masonry chimney must be in good condition.• Meets minimum standard of NFPA 211• Factory-built chimney must be 6 in. (152mm) UL10 HT. WARNING E. Masonry F. Alternate Masonry Non-Combustible Hearth Pad Ai...

Page 16 - Mobile Home; pages 8; You must use a Quadra-Fire Outside Air Kit

Page 16 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 6 Mobile Home 1. An outside air inlet must be provided for the combustion air and must remain clear of leaves, debris, ice and/or snow. It must be unrestricted while the appliance is in use to prevent room air starvation which causes smo...

Page 17 - A. Outside Air Kit Instructions; Never draw outside combustion air from:; Rear Installation; Floor Installation; Secure Collar

R R R September 1, 2008 7014-082D Page 17 CB 1200 Pellet Stove 7 Appliance Set-Up A. Outside Air Kit Instructions Flex Hose Hose Clamp Collar Assembly Trim Ring Termination Cap Assembly Hose Clamp Included in Kit: 1 piece of 2 inch x foot flex hose, 2 hose clamps, 1 collar assembly, termination cap ...

Page 18 - B. Top Vent Adapter Installation; Installing the Top Vent Adapter; C. Rear Vent and Rear Vent to Top Vent

Page 18 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 3 to 3 inch Top Vent Adapter 3 to 6 inch Top Vent Offset Adapter 1. Put a layer of high temperature silicone on the inch (76mm) exhaust outlet. 2. Slide the top vent adapter onto the rear exhaust outlet and adjust the assembly to a verti...

Page 19 - D. Optional Brick Set Installation; Note: Figure 19.5 shows the finished shape of the brick; Installed Clip; E. Brick Clip Installation

R R R September 1, 2008 7014-082D Page 19 CB 1200 Pellet Stove D. Optional Brick Set Installation 1. Remove the baffle first, follow instructions on page 33 . 2. Slide bottom of left rear brick in first; rotate top edge toward rear of appliance and then rotate outer edge toward rear of appliance, un...

Page 20 - Logs are FRAGILE. Use extreme care when handling or; LOCATING PINS; Top Log; Install Logo; Do not open top all the way back so the weight of the; It will damage the; It will be necessary to prop the top up with

Page 20 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R G. Optional Gold or Nickel Grille Assembly 1. Place the front log in first as shown in Figure 20.1 . Place log between firepot and face of appliance with charred area surrounding firepot. 2. Set the left and right logs onto the front log...

Page 21 - J. Thermostat Installation; • Do NOT remove grounding prong from plug.; I. Door Installation; Rod and nut

R R R September 1, 2008 7014-082D Page 21 CB 1200 Pellet Stove 1 . A 12 volt AC thermostat is required to operate this pellet appliance. You may use the included wall mount thermo - stat or purchase an optional programmable thermostat or remote control. It is equipped with an adjustable heat anticip...

Page 22 - Operating Instructions; A. Fuel Size And Material; If you; Shelled Field Corn; B. General Operating Information; Thermostat Calls For Heat

Page 22 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 8 Operating Instructions A. Fuel Size And Material 1. Wood Pellets Fuel pellets are made from sawdust or wood by-products. If the source material is hardwood, they can have a higher mineral content, creating more ash. Fuels containing ba...

Page 23 - set loose at the factory; F. Feed Rate Adjustment Instructions

R R R September 1, 2008 7014-082D Page 2 CB 1200 Pellet Stove E. Fire Characteristics A properly adjusted fire with the heat output control switch set on “high” has a short active flame pattern that extends out of the firepot approximately 4 to 6 inches (102 to 152mm). If the fire has tall flames wi...

Page 24 - page; H. Frequently Asked Questions; ISSUES; Figure 24.1 - DO NOT LEAVE FIREPOT FLOOR OPEN

Page 24 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R G. Ignition Cycles 1. During each ignition cycle, it is normal to see some smoke in the firebox. The smoke will stop once the fire starts. 2. The convection blower will automatically turn on after your appliance has reached the set tempe...

Page 25 - Troubleshooting; Symptom; Possible Cause

R R R September 1, 2008 7014-082D Page 25 CB 1200 Pellet Stove 9 Troubleshooting With proper installation, operation, and maintenance your appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a qualified service person in the di...

Page 28 - Maintaining & Servicing Your Appliance; C. General Maintenance; Shock and Smoke Hazard; A. Proper Shutdown Procedure; Cleaning or Inspection; Frequency; B. Quick Reference Maintenance Chart; Follow the detailed instructions found in this

Page 28 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 10 Maintaining & Servicing Your Appliance C. General Maintenance 1. Types of Fuel Depending on the type of fuel you are burning will dictate how often you have to clean your firepot. If the fuel you are burning has a high dirt or ash...

Page 29 - Cleaning Firepot with Cleaning Rod & Firepot

R R R September 1, 2008 7014-082D Page 29 CB 1200 Pellet Stove 5. Disposal of Ashes• Frequency: As needed • By: Homeowner Ashes should be placed in a metal container with a tight-fitting lid. The closed container of ashes should be placed on a non-combustible floor or on the ground, well away from a...

Page 30 - Handle glass assembly with care.; Contact your local dealer.

Page 0 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 7. Cleaning Beneath Heat Exchanger • Frequency: Monthly or after burning 1 ton of fuel • By: Homeowner a. Be sure the appliance is allowed to cool, has been unplugged and the exhaust blower is off . b. A more thorough cleaning is needed t...

Page 31 - in Exhaust Venting System.; Cleaning the Top Vent Adapter; There are heavy duty vacuum cleaners specifi

R R R September 1, 2008 7014-082D Page 1 CB 1200 Pellet Stove 15. Soot and Fly Ash: Formation & Need for Removal in Exhaust Venting System. • Frequency: Yearly or more frequently depending on ash build-up. • By: Qualified Service Technician/Homeowner Be sure the appliance is allowed to cool, has...

Page 32 - D. High Ash Fuel Content Maintenance; Convection Blower Replacement; E. Blower Replacement; Figure

Page 2 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R Correct Flame Size, Yellow/White in Colo r Correct Figure 32.3 Ash Build Up in Firebox Pellets Back Up In Feed Tube Firepot Overfills Tall, Lazy Flame, Orange in Colo r Incorrect Figure 32.1 Figure 32.2 D. High Ash Fuel Content Maintenanc...

Page 33 - Exhaust Blower Replacement; G. Igniter Replacement; Igniter; Remove existing blower:

R R R September 1, 2008 7014-082D Page CB 1200 Pellet Stove 2. Exhaust Blower Replacement G. Igniter Replacement F. Baffle Removal 1. Use proper shut down procedures to shut down the appliance and let it completely cool down and then unplug it and remove the ash drawer. 2. Follow instructions to rem...

Page 34 - H. Glass Replacement; latch, you must remove the door latch first

Page 4 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R H. Glass Replacement • Glass is 5mm thick high temperature heat- resistant ceramic glass. • DO NOT REPLACE with any other material.• Alternate material may shatter and cause injury. WARNING Figure 34.1 Top & Bottom Frame Door Latch Si...

Page 35 - Reference Materials; Heat Output Switch; When describing the location of a component,; Convection Blower

R R R September 1, 2008 7014-082D Page 5 CB 1200 Pellet Stove 11 Reference Materials 7. Heat Exchangers The heat exchangers transfer hot air from the exhaust system into convection air. Lift the stove top to access the heat exchangers. There are 2 clean out rods located under the heat exchangers. 8 ...

Page 36 - Wiring Harness

Page 6 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R 16. Snap Disc #1 (Convection Blower) 145°F Snap disc #1 is located on the right side of the appliance on the top of the heat exchanger box. There are 2 purple wires connected to it. This snap disc turns the convection blower on and off as...

Page 37 - B. Component Locations; Power Outlet; Cleaning Rods

R R R September 1, 2008 7014-082D Page 7 CB 1200 Pellet Stove B. Component Locations Heat Output Fan Speed Reset Button Call Light HIGH HIGH MED LOW LOW Power Outlet Terminal Block. Center 2 screws for Thermostat Wires Outside Air Flex Hose Convection Blower Cleaning Rods Heat Exchanger Tubes Figure...

Page 38 - Page 8

Page 8 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R Figure 38.1 - Door, Face, Glass & Door Latch Assembly Figure 38.2 - Firepot, Igniter & Thermocouple C. Exploded Views 1 2 4 5 6 7 8 9 Glass Size Center: 13-7/8” wide x 11” high Glass Size Sides: 5-1/8” wide x 11” high Nbr Descript...

Page 41 - D. Service Parts and Accessories

R R R September 1, 2008 7014-082D Page 41 CB 1200 Pellet Stove IMPORTANT: THIS IS DATED INFORMATION. The most current information is located on the Quadra- Fire web site at www.quadrafire.com . When ordering, supply serial and model numbers to ensure correct service parts. D. Service Parts and Acces...

Page 43 - Page 4; Appliance; Classic Bay 1200 Freestanding Pellet Stove; Accessories

R R R September 1, 2008 7014-082D Page 4 CB 1200 Pellet Stove Appliance Part No. Classic Bay 1200 Freestanding Pellet Stove CB1200-B Accessories Part No. Brick, Set, 4 pc 811-0601 Log Set, pc 811-0592 Door Assembly, Black DR-CB12-BK Door Assembly, Gold DR-CB12-GD Door Assembly, Nickel DR-CB12-NL Gri...

Page 44 - E. Service And Maintenance Log

Page 44 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R Date of Service Performed By Description of Service E. Service And Maintenance Log

Page 46 - Hearth & Home Technologies LIMITED WARRANTY; CONDITIONS, EXCLUSIONS & LIMITATION OF LIABILITY

Page 46 7014-082D September 1, 2008 R CB 1200 Pellet Stove R R G. Warranty Policy Hearth & Home Technologies LIMITED WARRANTY Hearth & Home Technologies (“HHT”) and its respective brands extends the following warranty for HHT gas, wood, pellet and electric appliances purchased from an author...

Page 48 - CONTACT INFORMATION; For the number of your nearest Quadra-Fire dealer; NOTICE; DO NOT DISCARD THIS MANUAL; DO NOT

R Hearth & Home Technologies 1445 North Highway Colville, WA 99114 Division of HNI INDUSTRIES www.quadrafire.com 7014-082D Septemer 1, 2008 Page 48 CONTACT INFORMATION : This product may be covered by one or more of the following patents: (United States) 459510, 4686807, 4766876, 47922, 481154, ...