Quadra-Fire QV-ST - Manual
Quadra-Fire QV-ST – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Installers Guide; DO NOT; Owners Guide; ALERTED; Safety and Warning Information
- Page 3 – Table of Contents
- Page 4 – Part number list on following page.; Log Assembly; Service Parts List
- Page 5 – SERVICE PARTS LIST; supply serial and model numbers to ensure correct service parts.; ITEM
- Page 6 – Service Parts
- Page 8 – IT EM
- Page 9 – Appliance Certification; The Quadra-Fire fireplace models discussed in this; Certification; Underwriters Laboratories; Installation Codes
- Page 10 – Getting Started; Introducing the Quadra-Fire Gas Fireplaces; Pre-install Preparation; Do not install any
- Page 13 – Installing the Fireplace; Step 1. Locating the Fireplace; Fireplace Locations/Dimensions with
- Page 14 – Step 2. Framing the Fireplace
- Page 15 – Model; Framing Dimensions
- Page 17 – Step 3. Installing the Vent System
- Page 18 – On vertical venting; Flue Restrictor Instructions; BREAK; . Center the Flue Restrictor on vent and secure in; Vertical
- Page 20 – Figure 15. Venting with Two 90° Elbows
- Page 21 – Figure 17. Venting with Two 90° Elbows
- Page 22 – Figure 18. Venting with three 90° elbows
- Page 23 – Figure 19. Venting with three 90° elbows
- Page 24 – Venting Out Vertically
- Page 27 – = AREA WHERE TERMINAL IS NOT PERMITTED; Figure 29. Vent Termination Minimum Clearances; public
- Page 29 – Step 5. The Gas Control System; Figure 32. Gas Control System; IPI PILOT; THE FIREPLACE JUNCTION BOX IN A IPI SYSTEM.
- Page 30 – Pressure; Figure 33. Gas Supply Line
- Page 31 – Appliance Requirements
- Page 33 – Only non-combustible materials; F. MINIMUM SEALANT MATERIAL; Hearth Extensions; r e q u i r e h e a r t h; Figure 40. Sealant Material
- Page 34 – overlap onto the front face. The joints; FULL OPEN; ANDIRONS; BEND TAB UNDER
- Page 36 – Placing the Ember Material; To place the ember material:; Replace the glass door and a front trim door on the unit.; Figure 53. Placement of the Ember Material
- Page 37 – Step 11. Before Lighting the Fireplace; Step 12. Lighting the Fireplace
- Page 38 – Maintaining and Servicing Your Fireplace; Fireplace Maintenance; Placing Ember Material
- Page 39 – Troubleshooting; Intellifire Ignition System; Symptom
- Page 40 – that wire harness is firmly connected to module.
- Page 41 – Lifetime Warranty; LIMITED LIFETIME WARRANTY
1
Quadra-Fire • QV-PIER, QV-ST Series: HV-IPI • 2005-901 Rev. G • 2/06
Models:
QV-Pier
QV-ST
Series: HV-IPI
Owner’s Manual
Installation and Operation
DO NOT DISCARD THIS MANUAL
CAUTION
Important operating
and maintenance
instructions included.
•
•
•
DO NO
DO NO
DO NO
DO NO
DO NO
TTTTT
DISCARD
DISCARD
DISCARD
DISCARD
DISCARD
Read, understand and follow
t h e s e i n s t r u c t i o n s f o r s a f e
installation and operation.
Leave this manual with
party responsible for
use and operation.
• Do not store or use gasoline or other flam-
mable vapors and liquids in the vicinity of this
or any other appliance.
• What to do if you smell gas
- Do not try to light any appliance
- Do not touch any electrical switch. Do not
use any phone in your building.
- Immediately call your gas supplier from a
neighbor’s phone. Follow the gas suppli-
er’s instructions.
- If you cannot reach your gas supplier, call
the fire department.
• Installation and service must be performed by
a qualified installer, service agency, or the gas
supplier.
In the Commonwealth of Massachusetts:
• installation must be performed by a licensed plumber
or gas fitter;
• a CO detector shall be installed in the room where the
appliance is installed.
WARNING: If the information in these
instructions is not followed exactly, a fire
or explosion may result causing prop-
erty damage, personal injury, or death.
Please contact your Quadra-Fire dealer with any questions
or concerns.
For the number of your nearest Quadra-Fire dealer,
please call 1-800-926-4356.
Quadra-Fire, a brand of Hearth & Home Technologies Inc.
1445 North Highway, Colville, WA 99114
Î
WARNING: IMPROPER INSTALLATION,
ADJUSTMENT, ALTERATION, SERVICE OR
MAINTENANCE CAN CAUSE INJURY OR
PROPERTY DAMAGE. REFER TO THIS
MANUAL. FOR ASSISTANCE OR ADDITION-
AL INFORMATION CONSULT A QUALIFIED
INSTALLER, SERVICE AGENCY, OR THE
GAS SUPPLIER.
This appliance may be installed in an aftermarket,
permanently located, manufactured (mobile) home,
where not prohibited by local codes.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is not
convertible for use with other gases, unless a certi-
fied kit is used.
Printed in U.S.A.
Copyright 2006
This product may be covered by one or more of the following patents: (United States) 4593510, 4686807, 4766876, 4793322, 4811534, 5000162, 5016609, 5076254, 5113843, 5191877, 5218953, 5263471, 5328356,
5341794, 5347983, 5429495, 5452708, 5542407, 5601073, 5613487, 5647340, 5688568, 5762062, 5775408, 5890485, 5931661, 5941237, 5947112, 5996575, 6006743, 6019099, 6048195, 6053165, 6145502, 6170481,
6237588, 6296474, 6374822, 6413079, 6439226, 6484712, 6543698, 6550687, 6601579, 6672860, 6688302B2, 6715724B2, 6729551, 6736133, 6748940, 6748942, 6769426, 6774802, 6796302, 6840261, 6848441,
6863064, 6866205, 6869278, 6875012, 6880275, 6908039, 6919884, D320652, D445174, D462436; (Canada) 1297749, 2195264, 2225408, 2313972; (Australia) 780250, 780403, 1418504 or other U.S. and foreign
patents pending.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 Quadra-Fire • QV-PIER, QV-ST Series: HV-IPI • 2005-901 Rev. G • 2/06 These units MUST use one of the vent systems described in the Installing the Fireplace section ofthe Installers Guide . NO OTHER vent systems or components MAY BE USED. This gas fireplace and vent assembly MUST be vented directly...
3 Quadra-Fire • QV-PIER, QV-ST Series: HV-IPI • 2005-901 Rev. G • 2/06 Table of Contents Safety and Warning Information .................................................. 2 Service Parts List ......................................................................... 4 Approvals and Codes ...............
4 Quadra-Fire • QV-PIER, QV-ST Series: HV-IPI • 2005-901 Rev. G • 2/06 Part number list on following page. 6 Log Assembly (NG, LP) Exploded Parts Diagram Service Parts List QV-Pier-HV-IPI Beginning Manufacturing Date: 6-03Ending Manufacturing Date: ______ 7 8 10 11 12 7 9 13 5 2 1 3 4
