Quadra-Fire CB1200M-MBK - Manual
Quadra-Fire CB1200M-MBK – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Page 2; and Welcome to the Quadra-Fire Family; SA; SAMPLE SERIAL NUMBER / SAFETY LABEL LOCATION:; Report Number
- Page 3 – Page 3; TABLE OF CONTENTS; Safety Alert Key:
- Page 4 – Listing and Code Approvals; A. Appliance Certification; NOTE: Some generator or battery back-up systems
- Page 5 – ations; Warning! Risk of Fire; Getting Started
- Page 6 – C. Thermostat Location; WARNING
- Page 7 – G. Tools And Supplies Needed; Or any such action that may cause a fire hazard.
- Page 8 – Page 8; Dimensions and Clearances; A. Appliance Dimensions; CL; CL; Figure 8.2 - Top View with Top Vent Adapter
- Page 10 – Hearth Pad Requirements
- Page 11 – Do not terminate vent; CAUTION; A. Chimney and Exhaust Connection; INSTALL VENT AT CLEARANCES SPECIFIED BY THE; Substitute or damaged vent components may; B. Venting Termination Requirements; Vent Information; Vent surfaces get HOT, can cause burns if
- Page 12 – D. Pipe Selection Chart; ALTITUDE IN THOUSANDS OF FEET; Example 1
- Page 13 – Venting Systems; Illustrations reflect typical installations and are FOR; All minimums listed are to a combustible surface.; Alcove Installation
- Page 14 – Straight Out; In Canada, where passage through a wall or partition of; Illustration shows venting going in both directions.
- Page 15 – C. Vertical into Existing Class A Chimney
- Page 16 – F. Alternate Masonry
- Page 17 – Mobile Home; pages 9; THE STRUCTURAL INTEGRITY OF THE MANUFAC-; • Any supporting material that would affect the structural; NEVER INSTALL IN A SLEEPING ROOM.; Installation must comply with Manufactured Home and; You must use a Quadra-Fire Outside Air Kit; Never draw outside combustion air from:
- Page 18 – A. Outside Air Kit Instructions; Rear Installation; Floor Installation; Secure Collar
- Page 19 – B. Top Vent Adapter Installation; Installing the Top Vent Adapter; C. Rear Vent and Rear Vent to Top Vent
- Page 20 – D. Optional Brick Set Installation; Note: Figure 20.5 shows the finished shape of the brick; Installed Clip; E. Brick Clip Installation; • Brick may have small wires protruding from
- Page 21 – Logs are FRAGILE. Use extreme care when handling or; LOCATING PINS; Top Log; Install Logo; Do not open top all the way back so the weight of the; It will damage the; It will be necessary to prop the top up with
- Page 22 – J. Thermostat Installation; • Do NOT remove grounding prong from plug.; Power Outlet; I. Door Installation; H inge; Rod and nut
- Page 23 – Operating Instructions; A. Fuel Size And Material; If you; Shelled Field Corn; B. General Operating Information; Thermostat Calls For Heat; Heat Output Controls; Keep combustible materials, gasoline; • Do NOT store flammable materials in the appliance’s; KEROSENE, CHARCOAL LIGHTER FLUID OR; • Keep all such liquids well away from the heater while it
- Page 24 – set loose at the factory; F. Feed Rate Adjustment Instructions
- Page 25 – page; H. Frequently Asked Questions; ISSUES; Back side of Firepot; Figure 24.1 - DO NOT LEAVE FIREPOT FLOOR OPEN
- Page 26 – Troubleshooting; action to be taken.; Symptom; Possible Cause
- Page 29 – Maintaining & Servicing Your Appliance; C. General Maintenance; Depending on the type of fuel you are burning will dictate; Shock and Smoke Hazard; A. Proper Shutdown Procedure; B. Quick Reference Maintenance Chart; Follow the detailed instructions found in this; Cleaning or Inspection; Frequency; Not properly
- Page 31 – There are heavy duty vacuum cleaners specifically; Handle glass assembly with care.
- Page 32 – Cleaning the Top Vent Adapter; There are heavy duty vacuum cleaners specifi
- Page 33 – Ash Build Up in Firebox; D. High Ash Fuel Content Maintenance; Convection Blower Replacement; The motor is mounted on a removable bracket. Remove the; E. Blower Replacement; is shown in; Figure
- Page 34 – Exhaust Blower Replacement; G. Igniter Replacement; Igniter; Remove existing blower:
- Page 35 – H. Glass Replacement; latch, you must remove the door latch first
- Page 36 – Reference Materials; Heat Output Switch; When describing the location of a component,; Convection Blower
- Page 37 – Wiring Harness
- Page 38 – B. Component Locations; Cleaning Rods
- Page 39 – Service Parts; Classic Bay Freestanding; Beginning Manufacturing Date: April 2009; Part number list on following page.
- Page 40 – ITEM; e Assembly
- Page 41 – #10 Firepot Assembly and Associated Parts
- Page 43 – #39 Feed Motor Assembly
- Page 45 – ACCESSORIES
- Page 48 – For the number of your nearest Quadra-Fire dealer; NOTICE; DO NOT DISCARD THIS MANUAL; DO NOT
R
www.quadrafire.com
7014-179D
December 16, 2011
CLASSIC BAY 1200 PELLET STOVE
O - T L
Tested and
Listed by
Portland
Oregon USA
OMNI-Test Laboratories, Inc.
C
US
Owner’s Manual
Installation and Operation
CB1200M-MBK
Model:
DO NOT DISCARD THIS MANUAL
NOTICE
• Important operating and
maintenance instruc
-
tions included.
•
Leave this manual with
party responsible for use
and operation.
•
Read, understand and
follow these instruc
-
tions for safe installa
-
tion and operation.
DO NOT
DISCARD
WARNING
Please read this entire manual
before installation and use of this
pellet fuel-burning room heater.
Failure to follow these instructions
could result in property damage,
bodily injury or even death.
•
Do not store or use gasoline or other flam
-
mable vapors and liquids in the vicinity of this
or any other appliance.
• Do not overfire - If any external part starts to
glow, you are overfiring. Reduce feed rate.
Overfiring will void your warranty.
• Comply with all minimum clearances to com
-
bustibles as specified. Failure to comply may
cause house fire.
Check building codes prior to installation.
• Installation MUST comply with local, regional, state and national
codes and regulations.
• Consult local building, fire officials or authorities having jurisdic
-
tion about restrictions, installation inspection, and permits.
CAUTION
Tested and approved for wood pellets and shelled
field corn fuel only. Burning of any other type of fuel
voids your warranty.
CAUTION
WARNING
Hot glass will cause burns.
• Do not touch glass until it is cooled
• NEVER allow children to touch glass
• Keep children away
• CAREFULLY SUPERVISE children in same room as
fireplace.
• Alert children and adults to hazards of high
temperatures.
High temperatures may ignite clothing or other
flammable materials.
• Keep clothing, furniture, draperies and other flammable
materials away.
HOT SURFACES!
Glass and other surfaces are
hot during operation AND
cool down.
To obtain a French translation of this manual, please
contact your dealer or visit www.quadrafire.com
Pour obtenir une traduction française de ce manuel,
s’il vous plaît contacter votre revendeur ou visitez
www.quadrafire.com
NOTE
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Page 2 7014-179D December 16, 2011 R CB 1200 Pellet Stove and Welcome to the Quadra-Fire Family ! Hearth & Home Technologies welcomes you to our tradition of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality, durability, and perfor - mance.This comm...
R December 16, 2011 7014-179D Page 3 CB 1200 Pellet Stove Section 1: Listing and Code Approvals A. Appliance Certifications ...................... 4 B. Mobile Home Approved ...................... 4 C. Glass Specifications ............................ 4 D. Electrical Rating .............................
Page 4 7014-179D December 16, 2011 R CB 1200 Pellet Stove 1 Listing and Code Approvals A. Appliance Certification C. Glass Specifications E. BTU & Efficiency Specifications This appliance is equipped with 5mm ceramic glass. Replace glass only with 5mm ceramic glass. Please contact your dealer fo...
