Makita DLM533Z User Manual - Free PDF Download

Page 2 - SPECIFICATIONS; Symbols; Intended use

2 ENGLISH SPECIFICATIONS Model: DLM533 Mowing width (blade diameter) 534 mm No load speed 2,300 min -1 Maximum speed 2,800 min -1 Part number of replacement mower blade Straight mower blade 191D52-7 Swing back mower blades *1 191D50-1 Swing back mower blades *2 191D48-8 Dimensions (L x W x H) L: 1,6...

Page 3 - Vibration; EC Declaration of Conformity; SAFETY WARNINGS; IMPORTANT SAFETY INSTRUCTIONS; Save all warnings and instruc-

3 ENGLISH NOTE: The declared noise emission value(s) has been measured in accordance with a standard test method and may be used for comparing one tool with another. NOTE: The declared noise emission value(s) may also be used in a preliminary assessment of exposure. WARNING: Wear ear protection. WAR...

Page 6 - Important safety instructions for; SAVE THESE INSTRUCTIONS.; Tips for maintaining maximum; ASSEMBLY; Installing the handle

6 ENGLISH 8. After removing the battery from the machine or charger, be sure to attach the battery cover to the battery and store it in a dry place. 9. Do not replace the battery with wet hands. Service 1. Have your power tool serviced by a qualified repair person using only identical replacement pa...

Page 7 - Removing the mulching plug

7 ENGLISH 1. Align the holes in the lower handle with the holes in the mower body, and then tighten 4 bolts temporarily. 2 1 ► 1. Lower handle 2. Bolt 2. Firmly tighten 4 bolts which were temporarily tightened in step 1 using box wrench 13. 3. Align the hole in the lower handle with the hole in the ...

Page 8 - Installing or removing the grass; FUNCTIONAL; Installing or removing battery

8 ENGLISH Installing or removing the grass basket To install the grass basket, follow the steps below. 1. Open the rear cover. 1 ► 1. Rear cover 2. Hold the handle of the grass basket, and then hook the grass basket on the rod of the mower body as shown in the figure. 1 2 3 ► 1. Rod 2. Handle 3. Gra...

Page 9 - Switching the battery cartridges; Overload protection; Overheat protection

9 ENGLISH To install the battery cartridge;1. Pull up the locking lever, and then open the battery cover. 12 ► 1. Battery cover 2. Locking lever 2. Align the tongue on the battery cartridge with the slot on the machine, and then slide the cartridge until it locks in place with a little click. 12 3 ►...

Page 10 - Control panel; Mode switching button

10 ENGLISH Indicating the remaining battery capacity Only for battery cartridges with the indicator 1 2 ► 1. Indicator lamps 2. Check button Press the check button on the battery cartridge to indi- cate the remaining battery capacity. The indicator lamps light up for a few seconds. Indicator lamps R...

Page 11 - Switch action; Adjusting the mowing height

11 ENGLISH Indicating the remaining battery capacity Press the check button to indicate the remaining battery capacities. The battery indicators correspond to each battery. Battery indicator status Remaining battery capacity On Off 50% - 100% 20% - 50% 0% - 20% NOTE: The indicator lamps for remainin...

Page 12 - Grass level indicator

12 ENGLISH The mowing height can be adjusted in the range of between 20 mm and 100 mm.Remove the lock key, and then pull the mowing height adjusting lever outward of the mower body and move it to your desired mowing height. 1 ► 1. Mowing height adjusting lever The table below shows the relationship ...

Page 13 - Adjusting the handle height; Adjusting the traveling speed; Using the rear discharge

13 ENGLISH Adjusting the handle height CAUTION: Before removing the bolts, hold the upper handle firmly. Otherwise, the handle may fall and cause an injury. The handle height can be adjusted in two levels. 1. Remove the upper bolts of the lower handle using box wrench 13, and then loosen the lower b...

Page 14 - OPERATION; Mowing; Mowing a long-grass lawn

14 ENGLISH OPERATION Mowing WARNING: Before mowing, clear away sticks and stones from mowing area. Furthermore, clear away any weeds from mowing area in advance. WARNING: Always wear the safety goggles or safety glasses with side shields when operating the mower. CAUTION: If the cut grass or foreign...

Page 15 - Emptying the grass basket; MAINTENANCE; Maintenance

15 ENGLISH NOTE: Mowing long grass to a short length all at once may cause the grass to die. The cut grass may also block up inside of the mower body. Emptying the grass basket WARNING: To reduce a risk of accident, reg- ularly check the grass basket for any damage or weakened strength. Replace the ...

Page 16 - Carrying the mower; Storing; For models equipped with straight mower

16 ENGLISH Carrying the mower When carrying the mower, hold the front grip and rear grip with two people as shown in the figure. 1 2 ► 1. Front grip 2. Rear grip Storing Store mower indoors in a cool, dry and locked place. Don't store the mower and charger in locations where the temperature may reac...

Page 18 - Installing the mower blade; TROUBLESHOOTING

18 ENGLISH NOTICE: When tightening the nuts to install the individual mower blades, apply 30 N•m as tighten- ing torque. NOTICE: When installing the individual mower blade, be sure to attach the spring washer in the direction as shown in the figure. NOTICE: When installing the individual mower blade...