Wagner 9900 - Manual - manualsarea.com

Page 2 - Contents; +2 years guarantee for professional finishing; Safety Regulations for FineCoat Spraying

2 GB Page Safety regulations for FineCoat spraying ............................... 3 Introduction to spraying using the FineCoat procedure ....... 4 Description of functions ........................................................... 4 Applications ......................................................

Page 3 - Earthing Instructions; PE

3 GB HAZARD: EXPLOSION OR FIRESolvent and paint fumes can explode or ignite. Severe injury and/or property damage can occur.PREVENTION : • Provide extensive exhaust and fresh air introduction to keep the air within the spray area free from accumulation of flammable vapors. • Avoid all ignition sourc...

Page 5 - Preparing the coating material; Coating material purity:; Starting operation; Determine the settings for the spray pattern, spray; Setting the FineCoat Spray Gun; A = vertical flat jet

5 GB Preparing the coating material Observe the manufacturer’s instructions for the use of the coating material on the paint tin or on the technical instruction sheet. Coating material purity: An absolute pre-condition for the trouble-free operation of the fine-spray system is that the coating mater...

Page 6 - Setting the ascending feed pipe

6 GB Setting the spray jet width (fig. 4) Adjusting ring Turn to the right = wider spray jet Turn to the left = narrower spray jet Note : The adjusting ring does not fasten the air cap! 4 Setting the amount of material (fig. 5) Set the amount of material by turning the material adjustment knob.Turn ...

Page 7 - Spraying technique; • In case of excessive paint mist formation, adjust; Breaks in work; Only use solvents with a flash point above 21 °C.

7 GB Spraying technique Hold the paint spray gun upright and maintain a constant distance of about 3 - 20 cm to the object being sprayed.Move the paint spray gun evenly either from side to side or up and down. If the gun is moved evenly, it will produce an even surface finish. No runs will occur if ...

Page 8 - Changing the nozzle

8 GB 9. Switch the unit off. 10. Clean the outer surfaces of the paint container and paint spray gun with a cloth soaked in solvent or water. Note: Do not leave the FineCoat spray gun immersed in solvent for extended periods! (The seals and air pipe on non-return valve may swell, preventing them fro...

Page 9 - Spray gun accessories and spare parts; Turbo-blower maintenance; Air filter and motor air filter

9 GB Spray gun accessories and spare parts Nozzle sets: The spray nozzle set consists of an air cap, a tip and a needle (fig. 17). Air cap Tip Needle 4 4 4 17 Table of nozzle sets Set (complete) Marking Part No. Tip size 2 0276 254 Ø 0,8 mm 3 0276 227 Ø 1,3 mm 4 0276 228 Ø 1,8 mm (Standard) 5 0276 2...

Page 10 - Special accessories; Area of application; When coating materials can be used?; Power Cart

10 GB Special accessories RN 30 Extension Tip (fig. 19) for ribbed radiators, length 30cm. Part No. 0261 020 19 WSL 50 Spray lance (fig. 20) Area of application Removating and repair work For ceilings and walls Material supply by means of a commercially available pressure tank. Part No. 0261 023 20 ...

Page 11 - Troubleshooting; Problem

11 GB Troubleshooting Problem A. The unit will not start. B. No coating material flow from the tip. C. Tip drips. D. Spray pattern sickle-shaped. E. Spray jet flutters. F. Leaks around the needle (3)*. *see page 12-13 Cause 1. No mains voltage. 2. Carbon brushes in motor worn. 3. Fine-wire fuse defe...

Page 12 - Spare Parts List, FineCoat spray gun

12 GB 34 33 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 28 29 23 22 21 20 16 19 26 17 25 30 32 50 49 48 47 45 44 43 46 42 41 40 39 38 3 3 35 18 24 52 27 Spare Parts List, FineCoat spray gun

Page 14 - Spare Parts List, turbo-blower FineCoat 9900

14 GB Spare Parts List, turbo-blower FineCoat 9900 1 2 4 5 13 14 15 16 17 18 19 20 21 14 15 16 22 23 24 25 26 29 30 27 28 10 11 12 78 9 6 33 35 34 36 32 31 39 40 41 37 38 42 43 44 46 45 47 13 3

Page 16 - Spare Parts List, air hose FineCoat 9900; Item

16 GB 2 4 1 3 Spare Parts List, air hose FineCoat 9900 Item Part No. Description 1 0276 439 Seal quick-release coupling 2 0275 625 Hose quick-release coupling 3 0277 234 Air hose, 7,5 m 4 0524 405 Hose whip 152 cm long

Page 17 - Connection Diagram

17 GB 17 Connection Diagram (P/N 0277 194, 230V) (P/N 0277 193, 110V) (P/N 0279 426) (P/N 9850 936) (P/N 0508 103, 230V) (P/N 9850 937, 110V) (P/N 0277 940, 230V) PE (P/N 0277 938, 110V) (P/N 0276 595, 230V) (P/N 0277 207, 110V) (P/N 0524 598) (P/N 9850 577) 1 2 2 3 4 4 4 4 4 3 1 1 1 1 1 1 Black 4 G...

Page 20 - Declaration of conformity; Wagner Spray Tech

20 GB Note on disposal: In observance of the European Directive 2002/96/ EC on waste electrical and electronic equipment and implementation in accordance with national law, this product is not to be disposed of together with household waste material but must be recycled in an environmentally friendl...

Wagner 9900 - Manual

Table of Contents:

Summary

Other Wagner Models