Teledyne 3010MB - Manual

Teledyne 3010MB

Teledyne 3010MB – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
57 Page 57
58 Page 58
59 Page 59
60 Page 60
61 Page 61
62 Page 62
63 Page 63
64 Page 64
65 Page 65
66 Page 66
67 Page 67
68 Page 68
69 Page 69
70 Page 70
Page: / 70

Table of Contents:

  • Page 2 – i i; Teledyne Analytical Instruments; Copyright © 1999 Teledyne Analytical Instruments
  • Page 3 – iii; Percent Paramagnetic Oxygen Analyzer; Table of Contents
  • Page 4 – i v; Specific Model Information
  • Page 5 – Preface; Overview
  • Page 6 – v i; Main Features of the Analyzer; The Model 3010MB Percent Oxygen Analyzer is sophisticated yet
  • Page 7 – OPERATING INSTRUCTIONS; Model; MB; Oxygen Analyzer; NEMA 4 Bulkhead Mount
  • Page 8 – Tracking the O
  • Page 11 – Introduction; The Analytical Instruments Model 3010MB Analyzer Control Unit,; Control Unit Inner Control Panel; The standard 3010MB Control Unit is housed in a rugged NEMA 4
  • Page 12 – Figure 1-1: Front of Unmounted Control Unit
  • Page 13 – Analyze; CAUTION: The power must be disconnected to fully
  • Page 14 – Control Unit Interface Panel; The Control Unit interface panel, shown in Figure 1-2, contains the
  • Page 15 – Note: If you require highly accurate Auto-Cal timing, use external
  • Page 17 – Operational Theory; The Model 3010MB Oxygen Analyzer Control Unit uses an 80C31; Electronics and Signal Processing; Refer to Figure 2-1, Block Diagram of the 3010MB CU Electronics:
  • Page 18 – Figure 2-1: Block Diagram of the 3010TB CU Electronics
  • Page 19 – Installation; Unpacking the Control Unit
  • Page 20 – Figure 3-1: Front Panel of the Model 3010MB Control Unit
  • Page 21 – Figure 3-2: Required Front Door Clearance; Electrical Connections; Figure 3-3 shows the Control Unit interface panel. Connections for; Figure 3-3: Interface Panel of the Model 3010MB Control Unit
  • Page 22 – The universal power supply requires a 100-; DANGER: Power is applied to the instrument's circuitry as; Figure 3-4: Primary Input Power Connections; There are eight DC output signal connectors on
  • Page 23 – The analog output signal has a voltage which depends on the oxygen
  • Page 24 – Voltage Signal; Range; LO
  • Page 25 – • Can be configured as high (actuates when concen-
  • Page 26 – ZERO; Remote Calibration Protocol: To properly time the Digital Remote
  • Page 29 – The voltage from the solenoid outputs is nominally 0 V for the OFF; CU
  • Page 30 – Testing the System; Power up the system, and test it by performing the following
  • Page 31 – Operation; Enter
  • Page 33 – Monospaced; The; The subfunctions of the; : Used to define an automatic calibration sequence; Figure 4-1: Hierarchy of Functions and Subfunctions; ANALYZE
  • Page 34 – by default. This allows; : Logging out prevents an unauthorized tampering with; to get a new screen with additional; : The instrument performs a self-diagnostic test to; show negative readings or not.; : The operator sets whether the instrument analog; PSWD Logout More
  • Page 35 – Auto–Cal
  • Page 36 – Span; Span Every 0 d; System; Auto—Cal; NOTE: If you use password security, it is advisable to keep a copy of; Entering the Password; ENTER
  • Page 37 – TETAI; PSWD; TBEAI; Installing or Changing the Password
  • Page 38 – T E T A I; Characters Available for Password Definition:; A A A A A
  • Page 39 – A L — 1; NOTE: If you previously logged off the system , you will now be; Logout; Protected Until; OK; Note: Remote Probe connector must be connected to the Analysis
  • Page 40 – More; Version Self—Test; Self–Test; RUNNING DIAGNOSTIC; Press Any Key
  • Page 41 – Shut off the gas pressure before connecting it to the analyzer, and
  • Page 42 – CELL FAILURE; Auto Mode Zeroing; AUTO
  • Page 43 – Zero; keys; NOTE: It takes several seconds for the true; Slope; Cell Failure
  • Page 44 – Auto Mode Spanning; arrow keys to enter the oxygen-concentration mode. Use
  • Page 45 – Manual Mode Spanning; keys to toggle between
  • Page 47 – Alarm
  • Page 48 – AL—1 AL—2; Dft—N Fs—N Ltch—N; Alarms
  • Page 49 – Note: The ranges must be increasing from low to high, for example,
  • Page 50 – NOTE: When performing analysis on a fixed range, if the oxygen
  • Page 51 – Signal Output; The standard Model 3010MB Percent Paramagnetic Oxygen Analyzer
  • Page 52 – IMPORTANT: In the event of loss of flow through the analyzer, if the
  • Page 53 – Maintenance; WARNING: SEE WARNINGS ON THE TITLE PAGE OF THIS; Fuse Replacement; The fuses are located inside the main housing on the Electrical
  • Page 54 – Figure 5-1: Removing Fuse Block Cap and Fuse from Housing; System Self Diagnostic Test; Power
  • Page 55 – O K; Major Internal Components; The major components in the Control Unit are shown in Figure 5-3.; Figure 5-3: Control Unit Major Internal Components
  • Page 56 – The 3010MB Control Units contain the following major components:; See the drawings in the Drawings section in back of this manual
  • Page 59 – The analyzer is composed of three subsystems:; Precise Paramagnetic Sensor; The heart of the 3010M is a paramagnetic type oxygen sensor that is
  • Page 60 – Operational Theory
  • Page 61 – Cross Interference; changing from pure nitrogen to 100% of one of the gases listed.
  • Page 63 – Routine Maintenance; WARNING: SEE WARNINGS ON TITLE PAGE OF THIS MANUAL.
  • Page 64 – Maintenance
  • Page 65 – Appendix; Autoranging with range ID output.; Sample System: Positive pressure service.; one 5 digit LED display.
  • Page 66 – Password Access: Can be user-configured for password
  • Page 69 – Zero Cal
  • Page 70 – Manual Mode Zeroing; NOTE: It takes several seconds for the true Slope value to display.
Loading the manual

i

Percent Paramagnetic Oxygen Analyzer

Teledyne Analytical Instruments

OPERATING INSTRUCTIONS

Model

3010

MB

Percent Paramagnetic

Oxygen Analyzer

Bulkhead Mount Control Unit, PN D-71385

Bulkhead Mount Analysis Unit, PN D-71394

HIGHLY TOXIC AND OR FLAMMABLE LIQUIDS OR GASES MAY BE PRESENT IN THIS MONITORING
SYSTEM.

PERSONAL PROTECTIVE EQUIPMENT MAY BE REQUIRED WHEN SERVICING THIS SYSTEM.

HAZARDOUS VOLTAGES EXIST ON CERTAIN COMPONENTS INTERNALLY WHICH MAY PERSIST
FOR A TIME EVEN AFTER THE POWER IS TURNED OFF AND DISCONNECTED.

ONLY AUTHORIZED PERSONNEL SHOULD CONDUCT MAINTENANCE AND/OR SERVICING. BEFORE
CONDUCTING ANY MAINTENANCE OR SERVICING CONSULT WITH AUTHORIZED SUPERVISOR/
MANAGER.

DANGER

P/N xxxxxx

12/21/99

ECO: #99-0000

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - i i; Teledyne Analytical Instruments; Copyright © 1999 Teledyne Analytical Instruments

i i Model 3010MB Teledyne Analytical Instruments Copyright © 1999 Teledyne Analytical Instruments All Rights Reserved. No part of this manual may be reproduced, transmitted, transcribed, stored in a retrieval system, or translated into any other language or computerlanguage in whole or in part, in a...

Page 3 - iii; Percent Paramagnetic Oxygen Analyzer; Table of Contents

iii Percent Paramagnetic Oxygen Analyzer Teledyne Analytical Instruments Table of Contents Specific Model Information ................................ iv Preface ................................................................ v Part I: Control Unit, Model MB .............. Part I: 1-1 Part II: Anal...

Page 4 - i v; Specific Model Information

i v Model 3010MB Teledyne Analytical Instruments Specific Model Information The instrument for which this manual was supplied may incorporate one or more options not supplied in the standard instrument. Commonlyavailable options are listed below, with check boxes. Any that are incorpo-rated in the i...

Other Teledyne Models

All Teledyne Other