Nilfisk ALTO 560 B - Manual

Page 3 - USER MANUAL; ENGLISH

USER MANUAL ENGLISH 146 2590 000(1)2005-03 A FLOORTEC 560 B 1 INTRODUCTION ................................................................................................................................... 2 MANUAL PURPOSE AND CONTENTS ..................................................................

Page 4 - INTRODUCTION

ENGLISH USER MANUAL 2 FLOORTEC 560 B 146 2590 000(1)2005-03 A INTRODUCTION MANUAL PURPOSE AND CONTENTS The purpose of this Manual is to provide the operator with all necessary information to use the machine properly in a safe and autonomous way. It contains information about technical characteristic...

Page 5 - SYMBOLS

USER MANUAL ENGLISH 146 2590 000(1)2005-03 A FLOORTEC 560 B 3 SYMBOLS GENERAL INSTRUCTIONS Specific warnings and cautions to inform about potential damages to people and machine are shown below. DANGER! – To perform maintenance/repair procedures turn the machine ignition key to OFF position and disc...

Page 6 - UNPACKING; OPERATION CAPABILITIES

ENGLISH USER MANUAL 4 FLOORTEC 560 B 146 2590 000(1)2005-03 A – In case of part replacement, order ORIGINAL spare parts from an authorised Dealer or Retailer. – To ensure the proper and safe operation of the machine, have the scheduled maintenance, detailed in the related chapter of this Manual, per...

Page 7 - TECHNICAL DATA; Available batteries; Color code; ELECTRICAL FUSES

USER MANUAL ENGLISH 146 2590 000(1)2005-03 A FLOORTEC 560 B 5 Under-hood compartment(See Fig. U) 1. Hood (open position) 2. Batteries 3. Battery connector 4. Electronic battery charger (optional) 5. Battery charger electrical cable 6. Main fuse 7. Side broom motor fuse 8. (Lead) battery caps 9. Lead...

Page 8 - USE; Lower the hood and check that it is correctly; Without battery; Buy an appropriate battery (See Technical; Machine setting; DANGER

ENGLISH USER MANUAL 6 FLOORTEC 560 B 146 2590 000(1)2005-03 A USE While reading this Manual, the Operator must pay particular attention to these symbols. Do not cover these adhesives for any reason, in case of damage replace them immediately. BATTERY CHECK/SETTING ON A NEW MACHINE The machine requir...

Page 9 - STARTING AND STOPPING THE MACHINE; Starting the machine; MACHINE OPERATION; : turn the ignition key to “0”; Electric filter-shaker; NOTE

USER MANUAL ENGLISH 146 2590 000(1)2005-03 A FLOORTEC 560 B 7 STARTING AND STOPPING THE MACHINE At every start-up 1. Insert the ignition key (2, Fig. B) in the control panel; turn it to “I” position [without pulling the lever (4, Fig. C)], then check that the green warning light (5, Fig. B) turns on...

Page 10 - Release the lever to stop the machine.; AFTER USING THE MACHINE; First period of use; MAINTENANCE

ENGLISH USER MANUAL 8 FLOORTEC 560 B 146 2590 000(1)2005-03 A HOPPER EMPTYING 1. Release the lever to stop the machine. 2. Turn the ignition key (2, Fig. B) to “0” position. 3. Disengage the hook (18, Fig. C) by pulling its inferior end. 4. By means of the handle (19, Fig. C) pull out the hopper (17...

Page 11 - SCHEDULED MAINTENANCE TABLE; Drive the machine on a level ground

USER MANUAL ENGLISH 146 2590 000(1)2005-03 A FLOORTEC 560 B 9 SCHEDULED MAINTENANCE TABLE (*): For the related procedure, see the Service Manual(1): Or at every start-up. MAIN BROOM HEIGHT CHECK 1. Check the main broom for proper ground clearance, proceeding as follows:– Drive the machine on a level...

Page 13 - Check the filter body for tears.; SKIRT HEIGHT AND OPERATION CHECK; Side skirt check

USER MANUAL ENGLISH 146 2590 000(1)2005-03 A FLOORTEC 560 B 11 DUST FILTER CLEANING AND INTEGRITY CHECK 1. Drive the machine on a level ground and activate the pedal brake (26, Fig. C) (if present). 2. Turn the ignition key (2, Fig. B) to “0” position. 3. Disengage the retainer (18, Fig. C). 4. Remo...

Page 14 - Reassemble the removed components in the reverse; BATTERY CHARGING; Connect the battery charger to the electrical mains.

ENGLISH USER MANUAL 12 FLOORTEC 560 B 146 2590 000(1)2005-03 A 9. If necessary, adjust the skirt height by using the slots (3, Fig. R). 10. Activate the front skirt lifting lever (27, Fig. C) and check that the front flap (1, Fig. Q) rotates upward of 90° (as shown in figure); release the lever and ...

Page 15 - SAFETY FUNCTIONS; HOOD SAFETY SWITCH; TROUBLESHOOTING; Battery

USER MANUAL ENGLISH 146 2590 000(1)2005-03 A FLOORTEC 560 B 13 SAFETY FUNCTIONS HOOD SAFETY SWITCH It is activated when the machine hood is raised. It stops all functions.In case of machine start even when the hood is open, contact an authorized Service Center or Retailer. TROUBLESHOOTING For furthe...

Page 16 - EC CERTIFICATE OF CONFORMITY; HVWVDQGDSSURYDOV; URGXFW

ENGLISH USER MANUAL 14 FLOORTEC 560 B 146 2590 000(1)2005-03 A EC CERTIFICATE OF CONFORMITY $OWR'HXWVFKODQG*PE+*XLGR2EHUGRUIHU6WUDH'%HOOHQEHUJ 'LSO,QJ:ROIJDQJ1LHXZNDPS 7HVWVDQGDSSURYDOV 3URGXFW 6ZHHSHU 0RGHO )/2257(&% 'HVFULSWLRQ 9 7KHGHVLJQRIWKHDSSOLDQFHFRUUHVSRQGVWRWKHIROORZLQJSHUWLQHQWUHJXOD...

Nilfisk ALTO 560 B - Manual

Table of Contents:

Summary

Other Nilfisk ALTO Models