Heat & Glo 6000TR-OAK-IPI - Manual
Heat & Glo 6000TR-OAK-IPI – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Installers Guide; DO NOT; Owners Guide; ALERTED; SAFETY AND WARNING INFORMATION
- Page 3 – TABLE OF CONTENTS
- Page 4 – Part number list on following page.; Log Set Assembly; Service Parts
- Page 5 – STANDING PILOT IGNITION ONLY*; Service Parts List
- Page 6 – ITEM; Intermittent Pilot Ignition
- Page 7 – Standing Pilot Ignition
- Page 8 – Appliance Certification; The Heat & Glo fireplace models discussed in this; Certification; Underwriters Laboratories; Installation Codes
- Page 9 – The following requirements reference various
- Page 10 – Getting Started; Introducing the Heat & Glo Gas Fireplaces; Pre-install Preparation; Do not install any
- Page 12 – Installing the Fireplace; Step 1. Locating the Fireplace; Vertical Sections; Constructing the Fireplace Chase
- Page 13 – Framing Dimensions; Step 2. Framing the Fireplace
- Page 15 – Step 3. Installing the Vent System; SERIES
- Page 16 – STRAIGHT UP; VERTICAL VENTING; Flue Restrictor Instructions; Figure 8. Flue Restrictor; On vertical venting
- Page 17 – HORIZONTAL VENTING; Figure 11. Corner Installation; Match the amount of vertical you have in the sys-; . Center the Flue Restrictor on vent and secure in
- Page 18 – On vertical venting configurations, where; Figure 12. Venting with One 90° Elbow; elbow is first attached to the unit,
- Page 19 – ELBOWS
- Page 20 – Figure 16. Venting with three 90° elbows; V H H + H
- Page 21 – Figure 17. Venting with three 90° elbows
- Page 22 – B. Installing Vent Components; Venting Out Rear
- Page 25 – If the area above the ceiling; IS; an attic, position and secure; Figure 27. Attic Firestop; Figure 28. Trapezoid Termination Cap
- Page 26 – = AREA WHERE TERMINAL IS NOT PERMITTED; Figure 29. Minimum Clearances for Terminations; public; NOT
- Page 28 – Installing the Optional Heat-Zone-Gas Kit; FORE; Step 6. The Gas Control Systems; Standing Pilot Ignition System; INTERMITTENT PILOT IGNITION
- Page 29 – Figure 34. Gas Supply Line; Step 7. The Gas Supply Line; Pressure
- Page 30 – Step 9. Wiring the Fireplace; This appliance
- Page 32 – require; Figure 39 Sealant Material; FINISH WALL MATERIAL MAY BE; HIGH TEMPERATURE (300; There are 3 metal tabs holding the non-combustible
- Page 34 – Step 12. Before Lighting the Fireplace
- Page 35 – Maintaining and Servicing Your Fireplace; Fireplace Maintenance; Placing Ember Material; Step 13. Lighting the Fireplace
Heat & Glo • 6000TR-OAK, 6000TR-OAK-IPI • 383-901 Rev. K • 5/06
1
Underwriters
Laboratories Listed
Models:
6000TR-OAK
6000TR-OAK-IPI
Owner’s Manual
Installation and Operation
Î
- Do not store or use gasoline or other
flammable vapors and liquids in the vi-
cinity of this or any other appliance.
-
What to do if you smell gas
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Do not use any phone in your build-
ing.
• Immediately call your gas supplier from
a neighbor's phone. Follow the gas
supplier's instructions.
• If you cannot reach your gas supplier,
call the fire department.
- I n s t a l l a t i o n a n d s e r v i c e m u s t b e
performed by a qualified installer, service
agency, or the gas supplier.
W A R N I N G : I M P R O P E R I N S TA L L A -
TION, ADJUSTMENT, ALTERATION,
S E R V I C E O R M A I N T E N A N C E C A N
CAUSE INJURY OR PROPERTY DAM-
AGE. REFER TO THIS MANUAL. FOR
ASSISTANCE OR ADDITIONAL INFOR-
MATION CONSULT A QUALIFIED IN-
STALLER, SERVICE AGENCY, OR THE
GAS SUPPLIER.
READ THIS MANUAL BEFORE INSTALLING OR
OPERATING THIS APPLIANCE. THIS INSTALLERS
GUIDE MUST BE LEFT WITH APPLIANCE FOR
FUTURE REFERENCE.
1. This appliance may be installed in an af-
termarket, permanently located, manufac-
tured (mobile) home, where not prohibited
by local codes.
2. This appliance is only for use with the type
of gas indicated on the rating plate. This
appliance is not convertible for use with
other gases, unless a certified kit is used.
Please contact your Heat & Glo dealer with any
questions or concerns. For the number of your nearest
Heat & Glo dealer, please call 1-888-427-3973.
Printed in U.S.A. Copyright 2005
Heat & Glo, a brand of Hearth & Home Technologies Inc.
20802 Kensington Boulevard, Lakeville, MN 55044
WARNING: IF THE INFORMATION
IN THESE INSTRUCTIONS IS NOT
FOLLOWED EXACTLY, A FIRE OR
EXPLOSION MAY RESULT CAUS-
ING PROPERTY DAMAGE, PER-
SONAL INJURY, OR DEATH.
This product may be covered by one or more of the following patents: (United States) 4593510, 4686807, 4766876, 4793322, 4811534, 5000162, 5016609, 5076254, 5113843, 5191877, 5218953, 5263471,
5328356, 5341794, 5347983, 5429495, 5452708, 5542407, 5601073, 5613487, 5647340, 5688568, 5762062, 5775408, 5890485, 5931661, 5941237, 5947112, 5996575, 6006743, 6019099, 6048195, 6053165,
6145502, 6170481, 6237588, 6296474, 6374822, 6413079, 6439226, 6484712, 6543698, 6550687, 6601579, 6672860, 6688302B2, 6715724B2, 6729551, 6736133, 6748940, 6748942, 6769426, 6774802,
6796302, 6840261, 6848441, 6863064, 6866205, 6869278, 6875012, 6880275, 6908039, 6919884, D320652, D445174, D462436; (Canada) 1297749, 2195264, 2225408, 2313972; (Australia) 780250,
780403, 1418504 or other U.S. and foreign patents pending.
In the Commonwealth of Massachusetts:
• installation must be performed by a licensed
plumber or gas fitter;
See Table of Contents for location of additional
Commonwealth of Massachusetts requirements.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Heat & Glo • 6000TR-OAK, 6000TR-OAK-IPI • 383-901 Rev. K • 5/06 2 These units MUST use one of the vent systems described in the Installing the Fireplace section ofthe Installers Guide . NO OTHER vent systems or components MAY BE USED. This gas fireplace and vent assembly MUST be vented directly ...
Heat & Glo • 6000TR-OAK, 6000TR-OAK-IPI • 383-901 Rev. K • 5/06 3 TABLE OF CONTENTS Safety and Warning Information ................................................ 2 Service Parts Lists ..................................................................... 4 Section 1: Approvals and Codes ..........
Heat & Glo • 6000TR-OAK, 6000TR-OAK-IPI • 383-901 Rev. K • 5/06 4 Part number list on following page. 5 4 6 Log Set Assembly 2 1 3 11 1 0 1 2 8 7 9 1 3 (NG, LP) Exploded Parts Diagram Service Parts 6000TR-OAK 6000TR-OAK-IPI Beginning Manufacturing Date: 4-01 Ending Manufacturing Date: 6-06
