Heat & Glo 7000XLS - Manual

Heat & Glo 7000XLS – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

Page 2 – ALERTED; SAFETY AND WARNING INFORMATION
Page 3 – TABLE OF CONTENTS
Page 4 – Appliance Certification; Installers; Certification; Approvals and; High Altitude Installations; Systems registered
Page 5 – Getting Started; Introducing the Heat-N-Glo Gas Fireplaces; Pre-install Preparation; Installers Guide
Page 7 – Installing the Fireplace; Step 1. Locating the Fireplace; Step 2. Framing the Fireplace; MEASURE FIREPLACE DIMENSIONS AND
Page 8 – Figure 4. D-Series Direct Vent Component Specifications
Page 9 – Step 3. Installing the Vent System; Identifying Vent Components
Page 10 – Figure 7. Venting with One 90° Elbow
Page 11 – Figure 9. Venting with three 90° elbows; V H H + H
Page 12 – B. Installing Vent Components
Page 14 – NOTE: Model DVK-01TRD does not need an exterior; MUST BE
Page 15 – NOTE: Keep insulation away from the vent pipe at least; Figure 19. Attic Firestop
Page 20 – Pressure
Page 21 – Step 8. Wiring the Fireplace; This appliance
Page 23 – and Ember Material; CAUTION: IT IS STRONGLY RECOMMENDED THAT
Page 24 – Step 11. Before Lighting the Fireplace; Step 12. Lighting the Fireplace
Page 25 – Maintaining and Servicing Your Fireplace; Fireplace Maintenance

Loading the manual

- Do not store or use gasoline or other flam-

mable vapors and liquids in the vicinity of this

or any other appliance.

What to do if you smell gas

Do not try to light any appliance.
Do not touch any electrical switch.
Do not use any phone in your building.
Immediately call your gas supplier from a

neighbor's phone. Follow the gas supplier's

instructions.

If you cannot reach your gas supplier, call

the fire department.

- Installation and service must be performed by a

qualified installer, service agency, or the gas

supplier.

Models:

7000XLS

6000XLSB

Installers Guide

WARNING: IMPROPER INSTA L L A -

TION, ADJUSTMENT, ALTERATION,

SERVICE OR MAINTENANCE CAN

CAUSE INJURY OR PROPERTY DAM-

AGE. REFER TO THIS MANUAL. FOR

ASSISTANCE OR ADDITIONAL INFOR-

MATION CONSULT A QUALIFIED IN-

STALLER, SERVICE AGENCY, OR THE

GAS SUPPLIER.

Underwriters

Laboratories Listed

390-900F 9/00

READ THIS MANUAL BEFORE INSTALLING OR

OPERATING THIS APPLIANCE. THIS

INSTALLERS

GUIDE

MUST BE LEFT WITH APPLIANCE FOR

FUTURE REFERENCE.

1. This appliance may be installed in an af-

termarket, permanently located, manufac-

tured (mobile) home, where not prohibited

by local codes.

2. This appliance is only for use with the type

of gas indicated on the rating plate. This

appliance is not convertible for use with

other gases, unless a certified kit is used.

Please contact your Heat-N-Glo dealer for any

questions or concerns. For the number of your

nearest Heat-N-Glo dealer, please call 952-985-6000.

Printed in U.S.A. Copyright 2000,
Heat-N-Glo, a division of Hearth Technologies Inc.

20802 Kensington Boulevard, Lakeville, MN 55044

WARNING: IF THE INFORMATION

IN THESE INSTRUCTIONS IS NOT

FOLLOWED EXACTLY, A FIRE OR

EXPLOSION MAY RESULT CAUS-

ING PROPERTY DAMAGE, PER-

SONAL INJURY, OR DEATH.

This product is covered by one or more of the following patents: (United States) 4,112,913; 4,408,594; 4,422,426; 4,424,792; 4,520,791; 4,793,322;

4,852,548; 4,875,464; 5,000,162; 5,016,609; 5,076,254 5,191,877; 5,218,953; 5,328,356; 5,429,495; 5,452,708; 5,542,407; 5,613,487; (Australia)

543790; 586383; (Canada) 1,123,296; 1,297,746; 2,195,264; (Mexico) 97-0457; (New Zealand) 200265; or other U.S. and foreign patents pending.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - ALERTED; SAFETY AND WARNING INFORMATION

2 These units MUST use one of the vent systems described in the Installing the Fireplace section of the Installers Guide . NO OTHER vent systems or components MAY BE USED . This gas fireplace and vent assembly MUST be vented directly to the outside and MUST NEVER be attached to a chimney serving a s...

Page 3 - TABLE OF CONTENTS

3 TABLE OF CONTENTS Safety and Warning Information ................................................ 2 Service Parts Lists ..................................................................... 4 Section 1: Approvals and Codes ............................................... 8 Approval Listings and Cod...

Page 4 - Appliance Certification; Installers; Certification; Approvals and; High Altitude Installations; Systems registered

8 Appliance Certification The Heat-N-Glo fireplace models discussed in this Installers Guide have been tested to certification standards and listed by the applicable laboratories. Certification MODELS: 7000XLS, 6000XLSB LABORATORY: Underwriters Laboratories TYPE: Direct Vent Gas Fireplace Heaters ST...