Page 3 - CONTENTS
1 CONTENTS Introduction 3Safety and warnings 4 Before you begin 9 Lighting instructions 10 Burner adjustment 14 Care and cleaning 15 Troubleshooting 16Warranty and service 17
Page 5 - INTRODUCTION
3 INTRODUCTION Expand your outdoor kitchen options with quick cooking on the griddle. The large griddle surface with precise temperature control, separate temperature zones and even heat distribution gives you cooking versatility and the ability to maintain a consistent temperature. Designed with fl...
Page 6 - SAFETY AND WARNINGS; Electric Shock Hazard; Failure to follow this advice may result in; Fire Hazard; Failure to follow this advice may result in a
4 SAFETY AND WARNINGS ! WARNING! Electric Shock Hazard Failure to follow this advice may result in electric shock or death. • This appliance is equipped with a three-prong or four-prong grounding plug for your protection against shock hazard and should be plugged directly into a properly grounded po...
Page 7 - Hot Surface Hazard; Failure to follow this advice may result in fire,; Excessive weight Hazard
5 SAFETY AND WARNINGS ! WARNING! Hot Surface Hazard Failure to follow this advice may result in fire, burns, scalds or personal injury. • Accessible parts may become hot during use.• When in use, do not touch the burner, grate, or immediate surrounding area as these areas become extremely hot. Clean...
Page 8 - Explosion Hazard; steam explosion may result. Turn all burners off,; Servicing
6 ! WARNING! Explosion Hazard Failure to follow this advice may result in injury or death • If you smell gas, do not use the appliance. • Do not use water on grease fires, a violent steam explosion may result. Turn all burners off, then smother fire or flame or use dry chemical or foam-type extingui...
Page 9 - General Use
7 z Do not store a full LP tank in direct sunlight. z After a period of storage or non-use, the appliance should be checked for gas leaks, deterioration, proper assembly, and burner obstructions before use. General Use z This appliance is not intended to be installed in or on recreational vehicles, ...
Page 10 - Gas requirements
8 Gas requirements z This appliance can be used with any brand of 20lb LP gas tank provided it is compatible with a proper retention device (not supplied). z The LP gas cylinder must be: z Designed for use with a Type 1 system only. z Constructed and marked in accordance with the Specifications for ...
Page 11 - BEFORE YOU BEGIN
9 BEFORE YOU BEGIN z Ensure the installer has completed the final checklist in the installation instructions. z Read this guide, taking special note of the Safety and warnings section. z Remove all packaging and dispose of it responsibly. Recycle items that you can. Seasoning the griddle 1 Clean the...
Page 12 - LIGHTING INSTRUCTIONS
10 LIGHTING INSTRUCTIONS If burner does not light after several attempts turn the dial to OFF and refer to the troubleshooting section. 2 3 The griddle is equipped with a thermocouple and safety valve system which monitors the burner. This will turn the gas off if the burner isn’t lit. 1 Push in and...
Page 14 - LEAK TESTING
12 2 1 3 Remove the 2 screws securing the valve panel to the unit using a Phillips screwdriver. Remove all dials by pulling outwards. Pull the valve panel down then outward and unplug any wires. Removing the valve panel LEAK TESTING A complete gas tightness check must be performed at the installatio...
Page 16 - GRIDDLE PLATE
14 GRIDDLE PLATE 2 1 3 Remove the vent assembly by pulling up gently from the product, and set aside on a protected surface. Grip the griddle plate from under the brackets at the front and rear of the product as shown. The griddle plate will need to be removed to access the burners for routine clean...
Page 18 - BURNER ADJUSTMENT
16 BURNER ADJUSTMENT Flames should be blue and stable with no yellow tips, excessive noise or lifting (Note: LP units may have some yellow tipping). If any of these conditions exist, check the air shutter and burner ports are clear. If cleaning these does not improve performance, the air shutter can...
Page 19 - CARE AND CLEANING
17 CARE AND CLEANING Regulator and hose replacement The pressure regulator and hose assembly supplied with the unit must be used. If replacements are needed, contact customer care at dcsappliances.com. Resetting the flow control Failure to follow the steps in the order shown may cause the Flow Limit...
Page 20 - TROUBLESHOOTING; PROBLEM
18 TROUBLESHOOTING PROBLEM POSSIBLE CAUSES WHAT TO DO The griddle won't light when the ignition is pushed There is no gas flowing to the unit. Check gas supply and connections. Ensure no air is trapped in line. There is a something blocking the air or gas flow. Check all openings for blockages. Chec...
Page 21 - WARRANTY AND SERVICE
19 WARRANTY AND SERVICE Before you call for service or assistance Refer to the installation instructions and your user guide and check that: z Your product is correctly installed. z You are familiar with its normal operation. z Model number (can be found on the inside, right side panel behind the dr...
Page 22 - U S C A
U S C A 5 9 2 0 67 1 1 .1 9 DCSAPPLIANCES.COM © Fisher & Paykel Appliances 2019. All rights reserved. The product specifications in this document apply to the specific products and models described at the date of issue. Under our policy of continuous product improvement, these specifications may...
