Quadra-Fire QV32EV-B - Manuals

Quadra-Fire QV32EV-B – Manual in PDF format online.

Manuals:

Manual

Manual Quadra-Fire QV32EV-B

Summary

Page 2 - Location on heater:; Listing Label Information/Location; MODEL XXXX

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 2 Read this manual before installing or operating this heater. Please retain this owner’s manual for future reference. Congratulations on selecting a Quadra-Fire electric ﬁ replace. The insert you have selected is designed ...

Page 3 - ) found in the text signifi es change in content.; Table of Contents

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 3 Note: An arrow ( ) found in the text signiﬁ es change in content. Table of Contents 1 Listing and Code Approvals 4 A. Certiﬁ cation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 2 Getting Started 5 A...

Page 4 - This heater has been tested in accordance with the; Standards; for fi xed and location-dedicated electric room; UL; or; CSA; Listing and Code Approvals

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 4 A. Certiﬁ cation This heater has been tested in accordance with the UL2021 Standards for ﬁ xed and location-dedicated electric room heaters in the United States, the current CSA C22.2 No. 46 in Canada and has been listed ...

Page 5 - Not intended for use as a primary heat source.; This; A. Important Instructions; Getting Started; D o n o t; WARNING

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 5 Not intended for use as a primary heat source. This heater is tested and approved as a decorative heater. It should not be factored as a primary heat source in residential heating calculations. Improper installation, adju...

Page 6 - B. Design and Installation Considerations; CAUTION; D. Inspect Heater and Components; Fire Risk; C. Tools and Supplies Needed

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 6 B. Design and Installation Considerations Check building codes prior to installation.• Installation MUST comply with local, regional, state and national codes and regulations. • Consult insurance carrier, local building i...

Page 7 - A. Selecting Heater Location

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 7 3 Framing and Clearances A. Selecting Heater Location Several options are available to you when choosing a loca-tion for your heater. This heater may be used as a room divider, installed along a wall, across a corner or u...

Page 8 - Header Height

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 8 C. Framing Figure 3.2 shows a typical framing (using 2 x 4 lumber) of the heater, assuming combustible materials are used. All re-quired clearances to combustibles around the heater must be adhered to. 36-1/4 in.* (921 mm...

Page 9 - This heater must be electrically wired and grounded; National Electric Code ANSI/NFPA 70-latest; or the; Shock Risk; A. 120VAC Wall Outlet Installation; Follow all national and local electrical codes.; Wiring; Model

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 9 Note: This heater must be electrically wired and grounded in accordance with local codes or, in the absence of local codes, with National Electric Code ANSI/NFPA 70-latest edition or the Canadian Electric Code, CSA C2.1 a...

Page 10 - C. 240VAC Hardwire Installation

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 10 B + B A - A LAMP LAMP FLAME M0TOR 120 VAC LAMPS REMOTE HEAT CONTROL REMOTE OR WALL ON/OFF SWITCH 12VDC SUPPLY POWER WHITE HEAT SWITCH OPTIONAL -12VDC SPEED CONTROL R2 D1 DIODE THERMOSTAT RELAY DIMMER PE N L1 L2 120 V 120...

Page 11 - Heater Preparation; A. Secure and Level the Heater; Nailing Flanges

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 11 5 Heater Preparation A. Secure and Level the Heater Shock Risk Improperly grounded outlets could cause electrical shock.• Always use properly grounded, fused and polarized outlets. • Always use ground fault protection wh...

Page 12 - Finishing; A. Finishing Material; • Combustible; The heater is a zero clearance fi replace and may; B. Finishing Checklist; may

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 12 6 Finishing A. Finishing Material • Combustible Material M a ter i al whi ch is made of or surfaced wit h wo o d , compressed paper, plant ﬁ bers, plastics, or any material capable of igniting and burning, whether ﬂ ame ...

Page 13 - temperature rise and fi re hazard.

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 13 C. Mantel Mantel height listed is measuredfrom the BASE of the heater. 3/4 in. - 12 in.(19 mm - 305 mm) 35 in. (889 mm) (CEILING) 30 in. min. (762 mm) Figure 6.4 Mantel Speciﬁ cations Fire Risk Do NOT obstruct air inlet ...

Page 14 - Heater Setup; Grate placement holes; A. Remove Shipping Materials; DO NOT; Refer to instructions included with accessory.; D. Install Refractory; Remove protective cover to access fi nal installation items.; Remove Log Assembly; Lift log set straight up and place in safe place.; Install Side Refractory

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 14 7 Heater Setup Grate placement holes Log tabs Figure 7.3 Install Grate A. Remove Shipping Materials • Remove shipping pack from front of ﬁ replace taking care not to damage grate. See Figure 7.1. • Remove grate from ship...

Page 15 - Access Controls; Operating Instructions

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 15 Fire Risk • Do not operate heater before reading and understanding operating instructions. Failure to operate heater properly may cause ﬁ re. WARNING A. Manual Controls Access Controls • Controls are located behind the l...

Page 16 - B. Hand Held Remote Control Transmitter

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 16 B. Hand Held Remote Control Transmitter RCE-QUAD-B (Optional) • The RCE-QUAD-B is an optional accessory listed with the Crestﬁ re Series heaters. • The transmitter is a radio frequency remote control. The frequency can b...

Page 17 - C. Wall Switch Control; Canadian Equipment Requirements; This device complies with

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 17 • Remote Transmitter Function - The hand held remote transmitter is only an ON/OFF control. When the transmitter is active, the remote LED light will be RED. Upon initial use, there may be a delay of three seconds before...

Page 18 - Troubleshooting; A. Troubleshooting Guide; Issues

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 18 9 Troubleshooting A. Troubleshooting Guide Issues Possible Causes Solutions Heater doesn’t turn on with the main switch or remote transmitter. 1. Power switch is off. 1. Turn the power switch to the “ON” position. 2. Cir...

Page 19 - Maintenance and Service; circuit breaker to the heater.; Bulbs; B. Cleaning the Back Acrylic Panel; • Turn off circuit breaker or unplug heater before replacing; Burn Risk; bulbs to cool before touching them.

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 19 10 10 Maintenance and Service Shock RiskBurn Risk Cleaning, performing maintenance or moving this electric heater without disconnecting power and allowing the heater to cool could create a shock or burn hazard.• Turn con...

Page 20 - E. Maintenance Task List; • Turn off the circuit breaker/unplug the heater before; Inspect

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 20 E. Maintenance Task List D. Heater/Blower Assembly Maintenance • Turn off the circuit breaker/unplug the heater before servicing the heater/blower assembly. • Allow heater to cool before removing.• Open the lower grille ...

Page 21 - Reference Materials

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 21 11 11 Reference Materials A. Heater Dimensions 16-7/8 in. (429 mm) 36 in. (914 mm) 14 in. (356 mm) 31 in. (787 mm) 30 in. (762 mm) 31-1/8 in. (791 mm) 3-1/8 in. (79 mm) 6-1/2 in. (165 mm) QV32E-B/QV32EV-B

Page 22 - B. Optional Components; Fronts

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 22 B. Optional Components ON OFF 12V BATTERY COMPARTMENT FRONT BACK SIGNAL LIGHT ON/OFF BUTTONS RCE-QUAD-B Remote Control WSK-21 WSK-21-W Wall Switch Kit Fronts QV32E-B Series Part # Description Finish Part # Description Fi...

Page 23 - Quick Tile Black and Brass Surrounds; Trim Kits; Flush Surrounds

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 23 VTS-550 VTS-550-BK Quick Tile Black and Brass Surrounds Trim Kits Surrounds PB = Polished Brass Finish BK = Black Finish PBT-550 BKT-550 Cabinet Trim no sufﬁ x = Polished Brass Finish BK = Black Finish Flush Surrounds (c...

Page 24 - Service Parts; VILLAGE COLLECTION; Beginning Manufacturing Date: Apr 2005; 1 - Light Tray Assembly

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 24 C. Service Parts Exploded Parts DiagramQV32E-B Series Service Parts VILLAGE COLLECTION Beginning Manufacturing Date: Apr 2005 Ending Manufacturing Date: Active 3 9 5 1 11 4 2 16 15 11 - Light Tray Assembly 14 13 12

Page 25 - Beginning Manufacturing Date: Apr 20905; # Description of Part

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 25 Service Parts ListQV32E-B Series Service Parts VILLAGE COLLECTION Beginning Manufacturing Date: Apr 20905 Ending Manufacturing Date: Active # Description of Part QV32E-B Series Qty. Reﬂ ective Flame Decal 4021-190 1 11 L...

Page 26 - This page intentionally left blank.

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 26 This page intentionally left blank.

Page 27 - WARRANTY

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 27 D. Limited Warranty Hearth & Home Technologies Inc. 1445 North Highway Colville, WA 99114-2124 WARRANTY Hearth & Home Technologies Inc. (HHT) Electric Fireplaces are tested and inspected prior to shipment and are...

Page 28 - – NOTES –; E. Contact Information; DO NOT DISCARD THIS MANUAL

Quadra-Fire • Village Collection Electric Fireplace • 4030-782 Rev D • 11/05 28 Hearth & Home Technologies Inc. 1445 North Highway Colville, WA 99114-2124 Please contact your Quadra-Fire dealer with any questions or concerns. For the number of your nearest Quadra-Fire dealer, please call 1-800-9...