Bakers Pride COH-ED - Manuals

Bakers Pride COH-ED – Manual in PDF format online.

Manuals:

Manual

Manual Bakers Pride COH-ED

Summary

Page 2 - INDEX; INSTALLATION INSTRUCTIONS

INDEX INSTALLATION INSTRUCTIONS SECTION ITEM PAGE 1 Receiving 2 2 Location & Minimum Clearances 2 3A Set-Up & Mounting for COH-E1 3 3B Set-up & Mounting for CO1-E 3 4 Electrical Connections 4 5 Initial Start Up 5 6 System Check & Rotary Controls 5 7 Steam Injection (Optional) 6 OPERA...

Page 3 - MINIMUM CLEARANCES; Dow Corning RTV 732 Multipurpose Sealant or; SKETCH “A” - TOP VIEW; SKETCH “B” - FRONT VIEW; Install the shelf supports and the wire shelves.

MINIMUM CLEARANCES COH-E1 CO1-E1 Inches mm Inches mm Right 1 25 1 25 Left 1 25 2 50 Rear 1 25 1 25 Suitable for installation on combustible floors when installed on factory supplied legs or casters. 3A. SET-UP / MOUNTING FOR COH-E1 Counter-top installation must conform to one of the following method...

Page 4 - ELECTRICAL CONNECTIONS; Only use copper conductors rated at 90°C.

4 2. CO1-E2: INSTALLATION / MOUNTING 6” LEGS a. After unpacking the unit, remove legs and any other material from inside the oven.b. Tilt the bottom oven onto its left side and attach the two mounting plates to the right underside using ½” bolts and washers and tighten firmly. Screw the 6” legs into...

Page 5 - FIELD CONNECTIONS; Remove access panel from the right side of the oven.; SYSTEM CHECK: ROTARY CONTROL; Turn selector switch to “0” position.

2. FIELD CONNECTIONS a. Remove access panel from the right side of the oven. b. Feed power cable (supplied by the customer) through the access hole in the rear of the oven and pull the cable to the front of the oven under the access panel where it may be attached to the cable support bracket. c. Fol...

Page 6 - STEAM INJECTION OPTION; OPERATING INSTRUCTIONS; GENERAL INSTRUCTIONS

7. STEAM INJECTION OPTION The solenoid valve for steam injection is mounted behind the service panel on the right hand side of the unit on COH-E and on the back of the unit on CO1-E. It is pre-wired at the factory. The electronic timer is pre-set at the factory. A ¼” copper tubing with a compression...

Page 7 - Do not steam injection at temperatures below 275°F (135°C); PROGRAMMING MENUS: MiniChef or FAST Option

3. COOK & HOLD ROTARY CONTROL a. Close the oven door(s). b. Turn selector switch to “High” or “Low” position. The green indicator light near the selector switch will be illuminated. c. Turn the thermostat knob to the desired cooking temperature. d. Upon reaching the set temperature, the amber in...

Page 8 - submerge; CLEANING

8 OVEN INTERIOR: Clean The Racks And Rack Support Guides: Open the doors and remove all wire racks and rack support guides. Take them to the sink and thoroughly clean in warm water with mild detergent or soap. Use a nylon scouring pad or stiff nylon brush. DO NOT USE STEEL WOOL. Clean The Stainless ...

Page 9 - SERVICING; The power supply to the unit must be disconnected prior to service.; SKETCH “C” - CLEANING THE BLOWER WHEEL; ON

4. SERVICING 1. The power supply to the unit must be disconnected prior to service. 2. Most of the service to this unit can be performed from the front and/or the control panel side. 3. For proper service, access to the control panel side of the unit is required. 4. It is necessary to have access to...

Page 10 - WIRING

17 B L K 2 B L K A4 W H T C2 WHT A5 W H T A6 WHT 9 BLK 10 BLK H5 W H T H3 WHT H6 WHT 6 WHT 16 W H T 1 B L K COM NO L2 9 B L K 12 B L K S B L K A3BLK C1 BLK 13 WHT A3 BLK A4 WHT 4 3 2 P4 P3 P2 P1 BUZZER TIMER 2 1 4 S SELECT OR SWITCH PILOT LIGHT (POWER) DOOR SWITCH C NC NO BUTT CONNECT OR 208V 1 220-...

Page 12 - Full Size Electric Convection Oven; Figure A; Page 2 of 4

CO1-E Full Size Electric Convection Oven Figure A Exterior / Interior / Elements / Controls / Door B R K S A E B R K S A E E R P ID E R P ID w S r i o tc o h D w S r i o tc o h D 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 29 30 31 32 33 34 35 36 37 40 44 43 41 38 39 42 4...

Page 13 - Item Part # Description Item Part # Description

Exterior / Interior / Elements / Controls / Door Item Part # Description Item Part # Description 1 E3450X Door Seal, Top & Bottom (2) 47 Q1407A Screw, Hx Hd, #10x1/2 2 E3451K Door Seal, Sides (2) 48 K1375E Element Bracket, Flat (4) 3 E3466U Door Closure Strip 49 Q3017A Star Washer #10 4 S1317U D...

Page 14 - Figure B; Door Chain / Legs & Open Rack Stand; Description; Item

Figure B Door Chain / Legs & Open Rack Stand Part # Description Item Part # Description Steam Option (Not Shown) Door Chain Assy Legs & Open Rack Stand 1 2 3 4 6 7 8 10 11 12 13 14 15 16 17 18 19 20 9 5 21 22 23 24 1 S3228A Flange Bearing (4) 13 S1252T 24 1/2" S/S Leg (each) Used w/Caste...

Page 15 - /2 Size Electric Convection Oven

Figure A Exterior / Interior / Elements / Controls / Door 1 3 4 5 6 C ol o C ol o Dow n Dow n Up Se t lec Se t lec M nu e M nu e S r ta t S r ta t S o p t S o p t Down Down g i He at n g i He at n a Ste m a Ste m 2 2 3 1 4 5 6 7 8 9 10 11 12 13 14 12 13 14 15 16 17 18 19 21 20 22 23 24 25 26 27 33 3...

Page 16 - Item Part # Description Item Part # Description; Optional Steam Injection

Exterior / Interior / Elements / Controls / Door Item Part # Description Item Part # Description Optional Steam Injection (Not Shown) 1 E1178K Outer Shell 44 U1169A Motor Rotation Arrow, Label 2 E1179K Outer Side (Right) 45 S1195X Blower Wheel 3 E1180X Access Cover Assy. 46 Q2318A Bolt, Wheel Puller...

Page 17 - Door Latch / Electrical Components; Rea

34 Figure B Door Latch / Electrical Components Item Part # Description Item Part # Description r Rea 1 2 3 5 4 8 6 7 9 10 12 13 14 15 16 17 19 21 20 22 23 24 25 26 29 30 31 27 32 33 24 28 18 1 U1210A Installation Warning, Label 18 K1087E Spring Bracket 2 U1120A Element Terminal, Plate 19 Q3017A Star...

Page 19 - BKI LIMITED WARRANTY

19 WHAT IS COVERED This warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: ♦ The equipment has not been accidentally or intentionally damaged, altered or misused; ♦ The equipment is properly installed, adjusted, operated a...

Page 20 - BKI Worldwide Headquarters

Phone: (864) 963-3471 Fax: (864) 963-5316 Toll Free: (800) 927-6887 Website: www.bkideas.comE-mail: [email protected] BKI Worldwide Headquarters PO Box 80400 Simpsonville, SC 29680-0400 USA 20