Bakers Pride VH1620E - Manual
Bakers Pride VH1620E – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – GENERAL INFORMATION; THIS MANUAL SHOULD BE RETAINED FOR FUTURE REFERENCE; Bakers Pride; SAFETY PRECAUTIONS
- Page 3 – IMPORTANT FOR FUTURE REFERENCE; Model Number
- Page 4 – TABLE OF CONTENTS; SECTION
- Page 5 – I. INSTALLATION INSTRUCTIONS; rating plate attached to the control box door panel.; MODELS COVERED
- Page 6 – ELECTRICAL CONNECTIONS; General Instructions; assembly, remember that each oven has; EACH CONVEYOR OVEN REQUIRES A SEPARATE CONNECTION; Volts
- Page 7 – FOR 3 PHASE UNITS ONLY:; SINGLE-PHASE CONNECTION
- Page 13 – OPERATOR MAINTENANCE; During normal operation of the oven, lubrication is not required.; AIR PLENUM FINGER ASSEMBLY
- Page 15 – CONVEYOR INSTALLATION
- Page 16 – CONVEYOR BELT SPEED CALIBRATION; Idler Shaft; Time of Delivery
- Page 18 – TROUBLESHOOTING GUIDE; THE PROBLEM
- Page 19 – terminal block
- Page 21 – Temperature control not working properly; If resistance reads value within range of
- Page 23 – TEMPERATURE CONTROL CONVERSION CHART; Ohms
- Page 24 – WIRE DESIGNATIONS; POWER BLOCK; CONTROL BOX DOOR; Solid State Relay; Conveyor Ovens; Circuit Leads
- Page 25 – ELEMENT WATTAGE; Dual Air Models: VH, VHVA1828E Conveyor Ovens; Single Phase Units
- Page 26 – ELECTRICAL SCHEMATICS & WIRING DIAGRAMS
- Page 27 – MAIN
- Page 29 – l O
- Page 43 – All Components Shown
- Page 44 – Figure G Main Power Control Box; Not Shown
- Page 45 – Figure H Electric Control Box
- Page 47 – BAKERS PRIDE LIMITED WARRANTY
- Page 48 – 0 Pine Street
INSTALLATION
AND
OPERATING
INSTRUCTIONS
INTENDED FOR OTHER THAN HOUSEHOLD USE
Models:
VH1620E, VHVA1620E, VH1828E & VHVA1828E
RETAIN THIS MANUAL FOR FUTURE REFERENCE
OVEN MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES
P/N U4173A 12/05
1
This equipment has been engineered to provide you with year-round dependable service when used
according to the instructions in this manual and standard commercial kitchen practices.
Initial heating of oven may generate smoke or fumes and must be done in a well ventilated area.
Overexposure to smoke or fumes may cause nausea or dizziness.
FOR YOUR SAFETY:
Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance.
!
!
WARNING:
Improper installation, adjustment, alteration, service or maintenance can
cause property damage, injury or death. Read the Installation, Operating and
Maintenance Instructions thoroughly before installing or servicing this equipment.
!
!
ANSI/NSF4
BAKERS PRIDE OVEN CO., INC
.
30 Pine Street
New Rochelle, NY 10801
(914) 576-0200 Phone
(800) 431-2745 US & Canada
(914) 576-0605 Fax
www.bakerspride.com Web Address
COUNTERTOP MODEL
ELECTRIC CONVEYOR OVENS
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 ! WARNING: This symbol refers to a potential hazard or unsafe practice, which could result in serious injury or death. ! ! ! DANGER: This symbol warns of imminent hazard which will result in serious injury or death. ! ! CAUTION: This symbol refers to a potential hazard or unsafe practice, which ma...
3 ! ! WARNING: Never clean any electrical unit by immersing it in water. Turn off before cleaningsurface. ! ! WARNING: An earthing cable must connect the appliance to all other units in the complete installation and from there to an independent earth connection. ! ! NOTICE: This product is intended ...
TABLE OF CONTENTS SECTION ITEM PAGE 1 Receiving 5 2 Location & Minimum Clearances 5 3 Installation 5 4 Stacking 6 5 Electrical Connections 6 6 System Check 8 7 Initial Start-Up 10 8 Shutdown 11 9 Special Features 11 10 Cleaning 12 11 Operator Maintenance 13 12 Rating Plate 14 13 Conveyor Removal...
