Bakers Pride CO1-G - Manuals

Page 2 - INDEX; INSTALLATION INSTRUCTIONS; When the oven arrives, it should consist of:

I. INSTALLATION INSTRUCTIONS SECTION ITEM PAGE A Receiving B Set-Up Mounting C Installation with Casters (Optional) D Location and Minimum Clearances E Gas Connection F Electrical Connection G Flue Connections-Ventilation H Burner Operation I System Check - Rotary Control II. OPERATING INSTRUCTIONS ...

Page 6 - II. OPERATING INSTRUCTIONS; NOTE: TIMER DOES NOT CONTROL THE OVEN.

II. OPERATING INSTRUCTIONS 1. GENERAL INSTRUCTIONS: (a) This equipment has an Electronic Temperature Control and Electronic Hot Surface Direct Ignition System. (b) Due to the increased efficiency of this oven, the temperature of standard recipes may be reduced 50°F (30°C). (c) Always load each shelf...

Page 7 - CLEANING

(5) Load the oven with product to be cooked. (6) Turn the timer knob to the desired bake time and timer will start counting down. (7) When timer reaches zero, a buzzer will sound. (8) Turn the Timer knob to '0' position to reset. (9) Turn the thermostat knob to the desired hold temperature. (10) Rem...

Page 10 - ELECTRICAL SCHEMATIC (ROTARY CONTROL); NC; ooox; oxoo; RAM; CO; Power; Timer; Coil; Interior Lights

6. ELECTRICAL SCHEMATIC (ROTARY CONTROL) CO1-G Flame Sensor Ignitor Gas Control therm. ignitor valve ground sensor l1 4 3 2 1 P4 P3 P2 P1 120VAC SSAC X 0 - O 0...60' X 0...60' O 0 - 5 4 2 1 NOTO 3 7 6 COM HI LO GC-20 NO COM L2 L1 NO NC ooox ooxo oxoo oxxo 24V 120V BUZZER TIMER M450 1 2 4 S Fan Rotar...

Page 11 - LO

timerM450 flame rod combination controlVR 8205 4 3 2 1 P4 P3 P2 P1 light switch COM NO L2 L1 NC NO C flame sensor ground valve hot thermostat L1-24vac ignitor 3 4 5 6 2 1 7 steam switch steam timer potentiometer blk yelred blu solenoidvalve FF PILOT IN 120v 24v ignitor 120VAC 1 2 3 4 S RotarySwitch ...

Page 13 - Full Size Gas Convection Oven; Figure B; Safety Valve; Item; Burners; U6003A-BKI 8/07

CO1-G Full Size Gas Convection Oven Figure B Burners / Valve / Door Chain / Legs (864) 963-3471(864) 963-5316(800) 927-6887 [email protected] faxUS & Canadaweb address OUT IN IN Safety Valve Legs & Open Rack Stand Door Chain Assy Steam Option (Not Shown) Item Part # Description Ite...

Page 14 - Figure A; tc

Figure A Exterior / Interior / Controls / Doors 95 94 1 2 3 4 5 6 8 10 11 12 13 14 15 17 18 19 20 23 24 25 26 27 28 29 30 31 32 34 35 36 37 38 39 40 41 42 43 44 45 47 46 48 49 9 50 51 52 53 54 56 55 57 58 58 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 74 75 75 75 73 76 78 79 80 81 82 83 84 85 86 87...

Page 15 - Exterior / Interior / Controls / Doors; Item Part # Description Item Part # Description

Exterior / Interior / Controls / Doors Item Part # Description Item Part # Description Conversion Kit (Natural to LP) Conversion Kit (LP to Natural) 1 E3450X Door Seal, Top or Bottom, each (2) 49 P6007X Elec Line Cord, 250V (UK) 2 E3451K Door Seal, Sides, each (2) 50 N5048P Rear Pipe Connection 3 E3...

Page 16 - BKI LIMITED WARRANTY

16 WHAT IS COVERED This warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: ♦ The equipment has not been accidentally or intentionally damaged, altered or misused; ♦ The equipment is properly installed, adjusted, operated a...