Bakers Pride CG - Manuals - manualsarea.com

Page 2 - IMPORTANT FOR FUTURE REFERENCE; Model Number Serial Number Date Purchased

2 IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment. For Warranty Service and/or Parts, this information is required. Model Number Serial Number Date Purchased Notes:

Page 3 - INDEX; I. INSTALLATION INSTRUCTIONS

INDEX I. INSTALLATION INSTRUCTIONS SECTION ITEM PAGE 1 General Description 4 2 Installation 4 3 Clearances 4 4 Gas Connection 4 5 Burners 5 6 Radiants 5 7 Top Grates 6 8 Lighting 6 9 Griddle Plates 6 10 Additional Installation Requirements 6 11 Installation with Casters 6 II. OPERATING INSTRUCTIONS ...

Page 4 - BE SURE TO CAP WHICHEVER SIDE IS NOT CONNECTED.; ACCEPTABLE CLEARANCES:; I MASSACHUSETTS; MINIMUM CLEARANCE FROM NON-COMBUSTIBLE CONSTRUCTION

4. GAS CONNECTION: The gas pressure regulator supplied must be installed at the gas inlet of each broiler. Each regulator is adjusted to yield a manifold pressure of 5 in. water column for natural gas or 10 in. water column for propane gas. No pressure regulator is required for propane gas in Canada...

Page 6 - Wait five minutes before attempting to re-light.; ADDITIONAL INSTALLATION INSTRUCTIONS; INSTALLATION WITH CASTERS

7. TOP GRATES: Place a grate over each of the radiants. For normal operation, the pointed side of the grate is facing up. For use with foods that require extra support, the flat side may be used. On XX Models, grates can be placed on three levels; two positions are built into the rear of the unit; t...

Page 7 - II. OPERATING INSTRUCTIONS

II. OPERATING INSTRUCTIONS 1. LIGHTING PROCEDURE: See section 8 of INSTALLATION INSTRUCTIONS. Once the pilot burners are lit, the broiler may be turned “ON” or “OFF” by turning the control valves on or off as necessary. 2. BROILING PROCEDURE: BROILER TOP GRATES MUST BE HOT ENOUGH TO MAKE BLACK CHAR-...

Page 9 - III. TROUBLE SHOOTING GUIDE; BURNER FLAME ADJUSTMENT:; IMMEDIATELY; ONE BURNER FAILS TO LIGHT:; If the pilot is not lit

III. TROUBLE SHOOTING GUIDE CAUTION: Take extreme care to assure that, if a valve is opened, a flame is present. If a valve is left open without a flame, turn the valve off and wait at least five minutes before attempting to (re)light. Service should be performed only by a qualified gas technician. ...

Page 10 - If the pilot is lit, positioned correctly,; VALVE ASSEMBLY VIEWS: (; FIGURE 2 Air Mixer Cap And Pilot Burners

(d) If the pilot is lit, positioned correctly, and has a proper flame, close all the burner valves , allow to cool and then remove the top grate and radiant over the burner. Remove the burner by lifting the rear of the burner off the support pin, slide it towards the rear of the broiler, enough to c...

Page 11 - Gas Char Broiler; BAKERS; Figure B; Burner / Accessories

XX-4, 6, 8, 10, 12 Gas Char Broiler 30 Pine Street • New Rochelle • New York • 10801 914 / 576 - 0200914 / 576 - 0605 1 - 800 - 431 - 2745 www.bakerspride.com faxUS & Canadaweb address BAKERS PRIDE Page 4 of 4 Note: When ordering, ALWAYS specify Part #, Model #, Serial #, Voltage/Phase & typ...

Page 12 - Figure A; Fish Grate

30 Pine Street • New Rochelle • New York • 10801 914 / 576 - 0200914 / 576 - 0605 1 - 800 - 431 - 2745 www.bakerspride.com faxUS & Canadaweb address BAKERS PRIDE Page 2 of 4 Note: When ordering, ALWAYS specify Part #, Model #, Serial #, Voltage/Phase & type of Gas. 2/05 XX-4, 6, 8, 10, 12 Ga...

Page 14 - Exploded View

58 57 51 48 47 56 55 49 50 54 53 52 46 Gas Char Broiler 30 Pine Street • New Rochelle • New York • 10801 914 / 576 - 0200914 / 576 - 0605 1 - 800 - 431 - 2745 www.bakerspride.com faxUS & Canadaweb address BAKERS PRIDE Figure A Exploded View Page 2 of 4 Note: When ordering, ALWAYS specify Part #,...

Page 16 - V. BAKERS PRIDE LIMITED WARRANTY

16 WHAT IS COVERED This warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that:* The equipment has not been accidentally or intentionally damaged, altered or misused;* The equipment is properly installed, adjusted, operated and...