Vermont Casting DVR28IN - Manual

Table of Contents:

• Page 2 – Vermont Castings DVR28 Direct Vent Gas Fireplace; PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS; Table of Contents; Installation & Operating Instructions
• Page 3 – PLEASE REVIEW THE FOLLOWING CAREFULLY; Certified To; Vented Gas Fireplace Heaters; Proposition 65 Warning:; Fuels used in gas, woodburning or
• Page 4 – DVR28 Fireplace Dimensions; Fireplace specifications and framing dimensions.; Minimum Side Wall Clearance; Minimum clearances.
• Page 5 – Locating Your Fireplace; Locate gas fireplace.; Appliance; Clearance to Combustibles; CAUTION: DO NOT place fireplace on floor; Secure wall mounting bracket in desired location.
• Page 6 – Secure fireplace to wall mounting bracket.; High Elevations; Inlet Minimum; Gas Inlet and Manifold Pressures; Natural; Recommended gas line installation.; Air; open; Gas Specifications
• Page 7 – Restrictor Plate Installation; Some installations may require some adjust-; Installation; Remove front glass assembly. Refer to Window; Examples for Extended Run/Restrictor Plate Settings; Install restrictor plate for optimum flame appearance.; DVR28 wiring diagram.; Wireless Remote
• Page 8 – If vent termination is installed in an accessible loca-; General Venting; There must not be any obstruction
• Page 9 – General Venting Information - Termination Location; Canadian Installations
• Page 10 – Termination clearances.; General Information Assembling Vent Pipes; Canadian Installations:; Termination Clearances; of Caps; Twist Lock Pipes
• Page 11 – How to Use the Vent Graph; Horizontal dimension from the outside face of the; ertical dimension from the fl; rear vent no elbows; Rear Vent Top View
• Page 12 – Combustible Walls; Hole opening must; Adjustable zero clearance sleeve.; Vent Opening for Combustible Wall; Locate vent opening on wall.; Rear Wall Installation
• Page 13 – Vertical Sidewall Applications; Maximum vent run with elbows.; According to the vent graph (Page 11) the; Total angular variation = 270°; Maximum elbow usage.
• Page 14 – Below Grade Installations; Below grade installation.
• Page 16 – Minimum termination to roof clearance.
• Page 17 – Elbow; Vent components; Vent Components; Vent components; Venting Components; Venting Components; vent components
• Page 18 – Glass Information; Care must be taken to avoid breakage of the glass.; Operating Instructions; Window Frame Assembly Removal; Remove front trim face by tilting bottom out and lift-; Window frame assembly removal.; Glass Cleaning; Hang Curve Face in place.
• Page 19 – Flame & Temperature Adjustment; Flame adjustment for American Flame valve.; Correct DVR28 flame. Center flame should be ap-
• Page 20 – Lighting & Operating Instructions; For Your Safety, Read the Following Warnings; result, causing property damage, personal injury and loss of life.; Lighting Instructions; DO NOT; Valve in the; “ON”; position
• Page 21 – Troubleshooting
• Page 22 – Troubleshooting AF4000 Valve; Pilot will not light/stay lit; A proper ground is essential to spark; Figure 39: Wall Transmitter Face
• Page 23 – Verify the gas supply is turned on.; Main flame will not light; Figure 40: Battery Pack - Battery Compartment
• Page 24 – Burner and Burner Compartment; Cleaning the Standing; If repair is necessary, it should be per-; Maintenance
• Page 26 – Optional Accessories; Curve Face Kit; Color; Rustic Bronze
• Page 27 – IF WARRANTY SERVICE IS NEEDED...; ) Contact your supplier. Make sure you have your warranty,; LIMITED LIFETIME WARRANTY; PRODUCT COVERED BY THIS WARRANTY
• Page 28 – CFM Corporation; Efficiency Ratings; Model