Vermont Casting DTV38s2 - Manuals

5 Chateau™ Direct Vent Gas Fireplace 20011957 Y D A B C E Y X LU584 Locating unit DVT38S2 3/17/04 djt Locating Your Fireplace LU584-1 Fig. 2 Locate gas fireplace. A) Flat on wall B) **Island C) *Room divider D) *Flat on wall corner E) Chase installation Y) 6” minimum Note (Fig. 2): ** Island (B) and ...

6 Chateau™ Direct Vent Gas Fireplace 20011957 Top of Unit to Ceiling ................................ 36” (914 mm) Front of Unit to Combustibles (both sides) 36” (914 mm) Appliance Top Standoffs .............................................. 0” (0 mm) Bottom* ...........................................

7 Chateau™ Direct Vent Gas Fireplace 20011957 A hearth is not mandatory but is recommended for aesthetic purposes. We recommend a noncombustible hearth which projects out 12” (305 mm) or more from the front of the fireplace. The hearth cannot exceed 1 ¹⁄₂ ” (38 mm) in height from bottom of fireplace f...

8 Chateau™ Direct Vent Gas Fireplace 20011957 Gas Inlet and Manifold Pressures Natural LP (Propane) Minimum Inlet Pressure 5.5” w.c. 11.0” w.c. Maximum Inlet Pressure 14.0” w.c. 14.0” w.c. Manifold Pressure 3.5” w.c. 10.0” w.c. High Elevations Input ratings are shown in BTU per hour and are certified...

9 Chateau™ Direct Vent Gas Fireplace 20011957 Control System The gas control system is located on the right hand side of the firebox behind an access panel and the decora-tive brick panel. The fireplace is operated using only the hand held remote control unit. The system wiring diagram is shown in Fig...

10 Chateau™ Direct Vent Gas Fireplace 20011957 19.If you choose to install the optional wireless wall mounted remote control (Part No. 20012267), install two (2) button batteries provided with the remote control by removing four (4) screws holding the back cover in place. Carefully remove the circui...

11 Chateau™ Direct Vent Gas Fireplace 20011957 Hand-Held Remote Control Transmitter Operating Instructions Introduction This transmitter operating range is approximately 20 feet (6 m). The transmitter operates on one of 1,048,576 security codes that are programmed into the transmitter at the factory...

12 Chateau™ Direct Vent Gas Fireplace 20011957 ����� ���� ��� ���� ���� ���� ���� ���� ���� ��� FP1820F-C display9/07 Screen while de-pressing ON key Screen while de-pressing OFF key Screen after 3 sec-ond default Screen after 3 sec-ond default Screen whild de-pressing OFF key Screen after 3 second ...

13 Chateau™ Direct Vent Gas Fireplace 20011957 ���� ��� FP1821set temp9/07 ���� ��� ���� ���� ���� ���� ���� ���� ����� To Change the Set Temperature Press and hold the SET key until the desired set tem-perature is reached. (By pressing and holding the set key, the LCD screen set numbers will increa...

14 Chateau™ Direct Vent Gas Fireplace 20011957 Operational Notes: The Thermostatic feature on the transmitter operates the appliance whenever the ROOM TEMPERATURE varies a certain number of degrees from the SET TEMPERATURE. This variation is called the “SWING” or TEMPERATURE DIFFERENTIAL. The normal...

15 Chateau™ Direct Vent Gas Fireplace 20011957 Pilot Main AF-4000 DC Motor Red Black White or Green Green or White Orange or White Black Brown Red Orange MainModule Black Gnd Brown Brown Black Red (SWI)(SWI) Extension Harness FP1795Chateau wiring diagram3/07 White or Orange S I AC Adaptor Power Modu...

16 Chateau™ Direct Vent Gas Fireplace 20011957 V V V V V V V X X X D E B B B C B M B A J K F L VENT TERMINATION AIR SUPPLY INLET AREA WHERE TERMINAL IS NOT PERMITTED H I ����� ������ Operable Operable Fixed Closed V B CFM145aDV Termin Location5/01/01 Rev. 12/05/01 sta INSIDE CORNER DETAIL V A G N N ...

17 Chateau™ Direct Vent Gas Fireplace 20011957 Outside Corner Inside Corner Termination Clearances Termination clearances for buildings with combustible and noncombustible exteriors. G = Combustible 6" (152 mm) Noncombustible 2" (51 mm) F = Combustible 6" (152 mm) Noncombustible 2" (...

18 Chateau™ Direct Vent Gas Fireplace 20011957 Horizontal Termination The vent must rise vertically a minimum of 24” (610 mm) off the top of the unit, before the first elbow. The horizontal run may extend up to 20’ (6 m) and include a vertical rise of up to 40’ (12 m). (Fig. 15) Hori-zontal terminati...

19 Chateau™ Direct Vent Gas Fireplace 20011957 When the vent termination exits through foundations less than 20” (508 mm) below siding outcrop, the vent pipe must be flush with the siding.It is always best to locate the fireplace in such a way that minimizes the number of offsets and horizontal vent l...

20 Chateau™ Direct Vent Gas Fireplace 20011957 STEP 2 Measure wall thickness and cut zero clearance sleeve parts to proper length (MAXIMUM 12”/305 mm). As-semble sleeve using #8 sheet metal screws (supplied). (Fig. 20) Install firestop assembly. (Fig. 35) VO584-100 Vent Opening 2/99 djt Vent Opening ...

21 Chateau™ Direct Vent Gas Fireplace 20011957 FP1458 Fig. 23 Through the wall. FP1457 Fig. 22 Horizontal length requirement. X FP1460 Fig. 24 Secure termination to wall. Support horizontal pipes every 3’ (914 mm) with metal pipe straps. Check fireplace to make sure it is levelled and properly positi...

22 Chateau™ Direct Vent Gas Fireplace 20011957 FP1461 thru wall trim 3/17/04 djt 2” (51mm) 1” (25mm) Min. 1” (25mm) Min. 16 ¹⁄₄ ” x 16 ¹⁄₄ ” (413 x 413mm) Opening FP1461 Fig. 25 A 2” (51mm) thick trim is required around opening. Sealing firestop gaps with high temperature sealant will restrict cold a...

23 Chateau™ Direct Vent Gas Fireplace 20011957 Vertical Through-the-Roof Applications Use of Restrictor Plate for Vertical Venting Application The primary purpose for the vent restrictor is to regain flame height under certain venting conditions as outlined below. Flue Restrictor Plate Installation R...

24 Chateau™ Direct Vent Gas Fireplace 20011957 plicable. When using the unitized 30°, 45° or 90° elbows, apply 1/4” bead of high temperature, 550°F or higher, sealant (milpack or stove cement) to the joint of the inner pipe (flue pipe) and the straight section as it is impossi-ble to be taped. The ou...

25 Chateau™ Direct Vent Gas Fireplace 20011957 This Gas Fireplace has been approved for, • Vertical installations up to 40’ (12 m) in height. Up to a 20’ (6 m) horizontal vent run can be installed within the vent system using a maximum of three (3) 90° elbows. (Fig. 34) • A 2’ (610 mm) vertical sect...

26 Chateau™ Direct Vent Gas Fireplace 20011957 FP593 SR/C 11/20/97 Attic Installation Ceiling Installation Nails (4) Firestop Spacer Joist Joist Firestop Spacer Nails (4) FP593 Fig. 36 Installing firestop spacer. FP263 MBUF 5/9/96 Attic Insulation Shield Ceiling Base Flanges Nails (4 Re- quired) Atti...

27 Chateau™ Direct Vent Gas Fireplace 20011957 Chimney Components Horizontal Starter Kit Contains 24”-40” telescopic pipe* for minimum vertical SK8DVSK rise from collar pipe, 90° elbow, horizontal through-wall starter pipe, zero clearance sleeve, metal adhesive tape, sidewall termination and firestop...

28 Chateau™ Direct Vent Gas Fireplace 20011957 Only glass approved by CFM Corporation should be used on this fireplace. 1. Turn the fireplace OFF (including the pilot).2. If the unit has been operating allow time for the components to cool. 3. Using a Phillips screwdriver, unfasten two (2) screws loca...

29 Chateau™ Direct Vent Gas Fireplace 20011957 firebox. Tilt it carefully toward the side until the piece is in place. Using the two (2) brackets and four (4) screws provided with the refractory kit, fasten each bracket to the top of the firebox on each side. NOTE: Use existing holes in firebox. 4. Pla...

30 Chateau™ Direct Vent Gas Fireplace 20011957 1. Ensure the four (4) screws that attach the fettle to the burner are secure. 2. Set the andirons in place by hooking the tabs on the back of the andirons over the webs of the fettle. (Fig. 43) Repeat process for and-irons on both sides of burner. ����...

31 Chateau™ Direct Vent Gas Fireplace 20011957 6. Position the log burner overlay. (Fig. 46) The overlay is very fragile and must be handled with extra care. Hold the overlay with the flat surface facing down. The notched corners of the overlay should be on the side of the pilot. Set the overlay on t...

33 Chateau™ Direct Vent Gas Fireplace 20011957 It is important to periodically perform a visual check of the pilot and burner flames. Compare them to Figures 52.If the flame patterns appear abnormal contact a qualified service provider for service and adjustment. Flame Characteristics �����������������...

34 Chateau™ Direct Vent Gas Fireplace 20011957 �������������������� Trim Installation CAUTION: Allow fireplace to cool if it has been in operation. Trim components: 2 each, top frame assembly, bottom trim assembly, right and left trim assem-blies. NOTE: Only one trim set is used when Vista Door is in...

35 Chateau™ Direct Vent Gas Fireplace 20011957 Lighting & Operating Instructions For Fireplaces equipped with American Flame Automatic Control System (IN or IP) A. This fireplace is equipped with an ignition device which automatically lights the pilot and main burner. The pilot and burner light a...

36 Chateau™ Direct Vent Gas Fireplace 20011957 Troubleshooting If erratic system behavior is observed that cannot be resolved by the methods outlined below, ensure that there is not a transmitter with batteries installed that may be interfering. If a transmitter is packed with batteries installed, i...

37 Chateau™ Direct Vent Gas Fireplace 20011957 Troubleshooting American Flame Gas Control System (continued) Pilot is burning, but ignitor continues to spark • Check that flame sensor is fully inpinged by pilot flame. If not, adjust pilot. • Check end-to-end continuity of sensor. If sensor has continu...

38 Chateau™ Direct Vent Gas Fireplace 20011957 American Flame Gas Control System Error Codes Ignition Safety: Protection for Ignition System Error Code: One beep every one second Description of Fault: Warn users if the pilot is not successfully ignited in 60 seconds. How to Clear: Press OFF then ON ...

39 Chateau™ Direct Vent Gas Fireplace 20011957 Fuel Conversion Instructions WARNING! This conversion kit shall be installed by a qualified service agency in accordance with the manufacturer’s instructions and all applicable codes and requirements of the authority having ju-risdiction. If the informat...

40 Chateau™ Direct Vent Gas Fireplace 20011957 CO134 AF pilot orifice 3/07 Index Tab Snap Ring Allen Wrench CO134 Fig. 57 Remove pilot orifice. 1. Remove two (2) screws holding the pilot assembly to the burner assembly. Move the pilot assembly toward the back wall. 2. Using a back-up wrench, disconne...

41 Chateau™ Direct Vent Gas Fireplace 20011957 22. Turn on gas supply and operate valve with remote control as needed to indicate gas pressure. The manifold pressure for LP should be approximately 10.0” wcp. CAUTION: Turn off the valve and gas supply before removing test port adaptor and replac-ing ...

42 Chateau™ Direct Vent Gas Fireplace 20011957 Maintenance Burner and Burner Compartment It is important to keep the burner and the burner compartment clean. At least once per year the logs and lava rock/ember material should be removed and the burner compartment vacuumed and wiped out. Remove and r...

45 Chateau™ Direct Vent Gas Fireplace 20011957 DVT38S2 (continued) Ref. Description DVT38S2 26. Trim Kit Complete (2 per fireplace) 20010894 26a. Top Trim (2 per fireplace) 20010901 26b. Right Side Trim (2 per fireplace) 20010902 26c. Left Side Trim (2 per fireplace) 20010903 26d. Bottom Trim (2 per fire...

46 Chateau™ Direct Vent Gas Fireplace 20011957 Accessories Back-up Battery Kit All Models: DVTBBKFollow instructions provided with the kit and on Page 9 for installation. Wall Mountable Wireless Remote Transmitter All Models: Part # 20012267.Refer to Page 9 for installation.

47 Chateau™ Direct Vent Gas Fireplace 20011957 LIMITED LIFETIME WARRANTY CFM Corporation (hereinafter referred to as CFM) warrants that all cast iron parts, the combustion chamber, ceramic burner, and heat exchanger of every Vermont Castings gas product will be free of defective material or workmans...

Efficiency Ratings Model EnerGuide Ratings Fireplace Efficiency (%) DVT38S2IN 47.1 DVT38S2IP 47.1 2695 Meadowvale Blvd. • Mississauga, Ontario, Canada L5N 8A3 800-668-5323 • www.cfmcorp.com CFM Corporation