Vanguard VN3000TB - Manual
Vanguard VN3000TB – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – INFRARED NATURAL GAS HEATER; Carbon Monoxide Poisoning:; Early signs; WARNINGS; DANGER: Carbon monoxide
- Page 3 – OWNER’S MANUAL; LOCAL CODES; American National Standards Institute, Inc.; Control Knob; SAFETY DEVICE; UNPACKING; Remove heater from carton.; Burners
- Page 4 – Unusually Tight Construction; per
- Page 5 – Determining if You Have a Confined or Unconfined Space; Continued
- Page 6 – Figure 3 - Ventilation Air from Outdoors; Ventilation Air From Outdoors; Do not provide openings for; Figure 2 - Ventilation Air from Inside Building
- Page 7 – INSTALLATION; CHECK GAS TYPE; WARNING: Never install the; CAUTION: If you install the
- Page 8 – Attaching to wall stud; Attaching to wall stud:; This method; Marking Screw Locations; Figure 7 - Mounting Bracket Clearances; Only mark last hole on each end; WARNING: Maintain minimum; Mounting Bracket; Figure 6 - Removing Front Panel Of Heater; Removing Front Panel Of Heater; Figure 5 - Mounting Bracket Location
- Page 9 – Mark screw locations on wall.; Attaching To Wall Stud Method; For attaching mounting bracket to wall studs; Attaching To Wall Anchor Method; Fold wall anchor as shown in Figure 8.; Figure 8 - Folding Anchor; Horizontal Slots
- Page 10 – Figure 12 - Gas Connection; WARNING: A qualified service; Typical Inlet Pipe Diameters; Hold pressure regulator; WARNING: Never connect; Tee Joint; Install an equipment shutoff
- Page 11 – WARNING: Never use an open; Correct all leaks at once.; Figure 13 - Equipment Shutoff Valve; Closed; Figure 14 - Checking Gas Joints; Gas Meter; FOR YOUR SAFETY
- Page 12 – Shutting Off Heater; CAUTION: Do not try to adjust
- Page 13 – Figure 18 - Correct Pilot Flame Pattern; Thermocouple; Figure 19 - Incorrect Pilot Flame Pattern; Pilot Burner; Figure 20 - Correct Burner Flame Pattern; Figure 21 - Incorrect Burner Flame Pattern; Air Passageways; CAUTION: You must keep; Figure 22 - Pilot Inlet Air Hole; Pilot Assembly
- Page 14 – TROUBLESHOOTING; OBSERVED PROBLEM; All troubleshooting items are listed in
- Page 15 – REMEDY
- Page 16 – POSSIBLE CAUSE; IMPORTANT
- Page 17 – SPECIFICATIONS; When Gas Pressure Is Too Low; PARTS UNDER WARRANTY
- Page 18 – BURNER ASSEMBLY
- Page 19 – PARTS LIST; KEY
- Page 22 – ACCESSORIES; FLOOR MOUNTING STAND
- Page 23 – NOTES
- Page 24 – KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; LIMITED WARRANTY; For information about this warranty write:; NOT A UPC; INTERNATIONAL
INFRARED VENT-FREE NATURAL GAS HEATER
OWNER’S OPERATION AND INSTALLATION MANUAL
Save this manual for future reference.
WARNING: If the information in this manual is not
followed exactly, a fire or explosion may result
causing property damage, personal injury, or loss
of life.
— Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
— WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not use
any phone in your building.
•
Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s
instructions.
•
If you cannot reach your gas supplier, call the
fire department.
— Installation and service must be performed by a
qualified installer, service agency, or the gas
supplier.
WARNING: This is an unvented
gas-fired heater. It uses air (oxy-
gen) from the room in which it is
installed. Provisions for ad-
equate combustion and ventila-
tion air must be provided. Refer
to
Air for Combustion and Ven-
tilation on page 4 of this manual.
WARNING: Improper installa-
tion, adjustment, alteration,
service, or maintenance can
cause injury or property dam-
age. Refer to this manual for
correct installation and op-
erational procedures. For as-
sistance or additional infor-
mation consult a qualified in-
staller, service agency, or the
gas supplier.
* Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer
This appliance may be installed in an aftermarket*, permanently located, manufac-
tured (mobile) home, where not prohibited by local codes.
This appliance is only for use with the type of gas indicated on the rating plate. This
appliance is not convertible for use with other gases.
®
VN1800TB
VN3000TB
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 104820 INFRARED NATURAL GAS HEATER ® 1. This appliance is only for use with thetype of gas indicated on the rating plate.This appliance is not convertible for usewith other gases. 2. If you smell gas• Shut off gas supply.• Do not try to light any appliance.• Do not touch any electrical switch; do ...
3 104820 OWNER’S MANUAL PRODUCTIDENTIFICATION LOCAL CODES Install and use heater with care. Follow alllocal codes. In the absence of local codes, usethe latest edition of National Fuel Gas CodeANS Z223.1, also known as NFPA 54*. *Available from: American National Standards Institute, Inc. 1430 Broad...
4 104820 INFRARED NATURAL GAS HEATER ® AIR FORCOMBUSTION ANDVENTILATION Today’s homes are built more energy effi-cient than ever. New materials, increasedinsulation, and new construction methodshelp reduce heat loss in homes. Home ownersweather strip and caulk around windows anddoors to keep the col...
