Vanguard NLFB32NC - Manuals

Vanguard NLFB32NC – Manual in PDF format online.

Manuals:

Manual

Manual Vanguard NLFB32NC

Summary

Page 2 - TABLE OF CONTENTS

www.desatech.com 105604-01H 2 WARNING: Improper installation, adjustment, altera-tion, service, or maintenance can cause injury or prop-erty damage. Refer to this manual for correct installation and operational procedures. For assistance or addi-tional information consult a qualiﬁed installer, servi...

Page 3 - SAFETY INFORMATION; ries

www.desatech.com 105604-01H 3 SAFETY INFORMATION WARNING: This product con- tains and/or generates chemicals known to the State of California to cause cancer or birth defects, or other reproductive harm. IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, operate,...

Page 4 - Air for Combustion and Ventila-; LOCAL CODES; National Electrical Code,; UNPACKING; Continued; PRODUCT; Figure 1 - Firebox Front View

www.desatech.com 105604-01H 4 5. Vent-free gas log heaters installed in these ﬁreboxes require fresh air ventilation to run properly. See Air for Combustion and Ventila- tion, page 6. 6. Do not run ﬁrebox • where ﬂammable liquids or vapors are used or stored • under dusty conditions 7. Do not use th...

Page 5 - PRODUCT FEATURES; OPERATION; LOCATING FIREBOX

www.desatech.com 105604-01H 5 12 1 / 2 " 2 3 / 4 " 1 1 / 2 " 9 3 / 4 " 4 5 / 8 " 2 1 / 2 " 6" 32 3 / 16 " 33 11 / 16 " Figure 2 - Firebox Side View Gas Line Access Standoffs (Models FB32NCA and NLFB32NC only) Electrical Access Hole Electrical Access Hole with Bush...

Page 6 - National Fuel

www.desatech.com 105604-01H 6 AIR FOR COMBUSTION AND VENTILATION WARNING: This ﬁrebox shall not be installed in a conﬁned space or unusually tight construc- tion unless provisions are provid- ed for adequate combustion and ventilation air. Read the following instructions to insure proper fresh air f...

Page 7 - Ventilation Air From Inside Building; National Fuel Gas Code,

www.desatech.com 105604-01H 7 DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION Determining if You Have a Conﬁned or Unconﬁned Space Use this work sheet to determine if you have a conﬁned or unconﬁned space. Space: Includes the room in which you will install heater plus any adjoining rooms with doorles...

Page 8 - VENTILATION AIR; National Fuel Gas; Ventilation Air From Outdoors; Section 5.3, Air for Combustion and Ventilation; INSTALLATION

www.desatech.com 105604-01H 8 AIR FOR COMBUSTION AND VENTILATION Continued VENTILATION AIR Ventilation Air From Inside Building This fresh air would come from an adjoining un- conﬁned space. When ventilating to an adjoining unconﬁned space, you must provide two perma- nent openings: one within 12...

Page 9 - INSTALLATION CLEARANCES; MINIMUM CLEARANCE TO; Top

www.desatech.com 105604-01H 9 IMPORTANT: Vent-free gas log heaters add moisture to the air. Although this is beneﬁcial, installing firebox in rooms without enough ventilation air may cause mildew to form from too much moisture. See Air for Combustion and Ventilation , page 6. IMPORTANT: Make sure th...

Page 10 - INSTALLING BLOWER ACCESSORY; Figure 8 - Removing Screws from

www.desatech.com 105604-01H 10 INSTALLING BLOWER ACCESSORY (Model FB32CA only) You may install blower accessory GA3700 with conventional installation (below) or with built-in installation (page 11) with models FB32CA and NLFB32C only. Conventional Installation of Blower Accessory NOTICE: If a log se...

Page 11 - WARNING: Never touch the; NOTICE: A qualified electrician; The National Electrical Code; Built-In Installation of Blower Accessory; Figure 11 - Installing Plastic Bushing for; Operating the Blower

www.desatech.com 105604-01H 11 7. Plug in blower power cord. a. If your ﬁrebox is installed as a freestanding unit, determine whether the power cord will exit the left side or the right side of the ﬁrebox. Install 1 plastic bushing provided into the 1 1 / 2 " hole in the ﬂoor support on the exit...

Page 12 - Installing Blower Accessory; Figure 14 - Cutting Brackets; Heater Base; INSTALLING FIREPLACE HOOD; NOTICE: The firebox canopy

www.desatech.com 105604-01H 12 INSTALLING LOG HEATER IN FIREBOX CAUTION: Do not remove the data plates attached to the heater base assembly. The data plates contain important warranty and safety information. CAUTION: Do not pick up log base assembly by burners. This could damage burners. Only handle...

Page 13 - INSTALLING FIREPLACE SCREEN; Figure 16 - Installing Fireplace Screen; son must connect firebox to gas; Hearth

www.desatech.com 105604-01H 13 Electrical Outlet INSTALLING FIREPLACE SCREEN 1. Insert each rod through nine rings located at top of screen. 2. Insert ﬁrst rod into rear hole in left side of ﬁrebox. Fasten rod to rear hole near center of ﬁrebox using black shoulder screw. 3. Insert other rod into fr...

Page 14 - BUILT-IN FIREBOX INSTALLATION

www.desatech.com 105604-01H 14 7. Break off nailing ﬂanges (see Figure 19) with hammer or pliers. IMPORTANT: When installing Brass Trim Kit, see instructions included with mantel accessory. 8. Place cardboard or other protective material on top of hearth base. Carefully set ﬁrebox on protective mate...

Page 15 - Figure 23 - Attaching Firebox to Wall; REPLACEMENT PARTS; PARTS UNDER WARRANTY; TECHNICAL SERVICE

www.desatech.com 105604-01H 15 2. Install gas piping to ﬁrebox location. This installation includes an approved flexible gas line (if allowed by local codes) after the manual shutoff valve. The ﬂexible gas line must be the last item installed on the gas pip- ing. See Connecting to Gas Supply in log ...

Page 16 - ACCESSORIES; Use with Models FB32CA and NLFB32C only.; CABINET MANTEL

www.desatech.com 105604-01H 16 ACCESSORIES Purchase these ﬁrebox accessories from your local dealer. If they can not supply these accessories, call DESA Heating Productsʼ Sales Department at 1-866-672-6040 for information. You can also write to the address listed on the back page of this manual. EQU...

Page 18 - ILLUSTRATED PARTS BREAKDOWN

www.desatech.com 105604-01H 18 ILLUSTRATED PARTS BREAKDOWN MODELS FB32NCA AND NLFB32NC 5 14 16 16 16 13 15 17 17 17 16 6 1 7 16 18 10 8 20 12 19 9 4* 2* 3* 2* 16 11 18

Page 19 - PARTS LIST; listed under

www.desatech.com 105604-01H 19 KEY PART NUMBER NO. FB32NCA NLFB32NC DESCRIPTION QTY. 1 101872-03 101872-03 Firebox Top 1 2 101889-01 * Firebrick Retainer 3 3 101929-04 * Rear Firebrick 1 4 101932-04 * Side Firebrick 2 5 103207-01 103207-01 Outer Casing 1 6 103208-01 103208-01 Outer Shell Base 1 7 **...

Page 21 - KEY

www.desatech.com 105604-01H 21 PARTS LIST This list contains replaceable parts used in your ﬁrebox. When ordering parts, follow the instructions listed under Replacement Parts on page 15 of this manual. KEY PART NUMBER NO. FB32CA NLFB32C DESCRIPTION QTY. 1 101872-03 101872-03 Firebox Top 1 2 101889-...

Page 22 - NOTES

www.desatech.com 105604-01H 22 NOTES _______________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________...

Page 24 - NOT A UPC; WARRANTY INFORMATION; KEEP THIS WARRANTY; Model; LIMITED WARRANTY

2701 Industrial DriveP.O. Box 90004Bowling Green, KY 42102-9004www.desatech.com 105604-01Rev. H07/04 NOT A UPC WARRANTY INFORMATION KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory.We reserve the right to amend these speci...