Vanguard VYS24PWA - Manual
Vanguard VYS24PWA – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – DANGER: Carbon monoxide; Carbon Monoxide Poisoning:; WARNINGS; WARNING: Any change to
- Page 3 – OWNER’S MANUAL; Continued; LOCAL CODES; OPERATION; UNPACKING; CAUTION: Do not remove the; Figure 1 - Product Identification; Vintage Oak Logs; Control Knob
- Page 4 – Unusually Tight Construction; per kw) of the aggregate input
- Page 5 – DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION; Determining if You Have a Confined or Unconfined Space
- Page 6 – Ventilation Air From Outdoors; Do not provide openings for; Figure 3 - Ventilation Air from Outdoors
- Page 7 – INSTALLATION; CHECK GAS TYPE; A. Clearances from the side of the fireplace
- Page 8 – If Not Using Mantel; If using a mantel, proceed to If Using; Noncombustible; Noncombustible material OK.; If Using Mantel; If you cannot meet these; Installing Damper
- Page 9 – flue damper open; FLOOR CLEARANCES; A. If installing appliance on the floor level,; Figure 6 - Minimum Mantel Clearances Without Using Hood; Figure 7 - Minimum Mantel Clearances When Using Hood; Hearth
- Page 10 – Area of Various Standard; Damper; Manufactured Fireplace; Installation Items Needed
- Page 11 – Attach base assembly to fireplace floor; Fitting; Items Included for Installation; • Switch; Connecting To Log Set; WARNING: Do not connect; The wire may be shortened; WARNING: A qualified service; • external regulator (supplied by installer,; Figure 13 - Connecting Wire Terminals; Switch
- Page 12 – Figure 15 - Gas Connection; WARNING: Never connect; Install an equipment shutoff; CAUTION: Avoid damage to; Correct all leaks at once.
- Page 13 – Figure 16 - Equipment Shutoff Valve; WARNING: Failure to position; INSTALLING LOGS; Place lava rock around base of heater.; CAUTION: After installation
- Page 14 – FOR YOUR SAFETY; • If fireplace has glass doors,; WARNING: Damper handle
- Page 15 – Pilot Burner; CAUTION: Do not try to adjust; Shutting Off Heater; Lighting; Thermostat Control Operation
- Page 16 – This remote control; Figure 24 - Correct Pilot Flame Pattern; PILOT FLAME PATTERN; • turn heater off (see To Turn Off Gas to; BURNER PRIMARY AIR HOLES
- Page 17 – TROUBLESHOOTING; WARNING: Turn off heater; POSSIBLE CAUSE; All troubleshooting items are listed in
- Page 18 – OBSERVED PROBLEM; nance, page 21) or replace burner orifice
- Page 19 – IMPORTANT
- Page 20 – SPECIFICATIONS; Vintage Oak; SERVICE HINTS; When Gas Pressure Is Too Low; WIRING DIAGRAM; PARTS UNDER WARRANTY
- Page 21 – WARNING: Turn off heater; LOGS; • If you remove logs for cleaning, refer to; MAIN BURNER; Figure 27 - Pilot Inlet Air Hole
- Page 23 – PARTS LIST; KEY
- Page 24 – ACCESSORIES; FIREPLACE HOOD
- Page 25 – NOTES
- Page 26 – KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; LIMITED WARRANTY; NOT A UPC
UNVENTED (VENT-FREE)
PROPANE/LP GAS LOG HEATER
®
Save this manual for future reference.
WARNING: If the information in this manual
is not followed exactly, a fire or explosion
may result causing property damage, per-
sonal injury, or loss of life.
— Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do
not use any phone in your building.
• Immediately call your gas supplier from
a neighbor’s phone. Follow the gas
supplier’s instructions.
• If you cannot reach your gas supplier,
call the fire department.
— Installation and service must be per-
formed by a qualified installer, service
agency, or the gas supplier.
WARNING: Improper installation, adjust-
ment, alteration, service, or maintenance
can cause injury or property damage.
Refer to this manual for correct installa-
tion and operational procedures. For as-
sistance or additional information con-
sult a qualified installer, service agency,
or the gas supplier.
WARNING: This appliance is for installa-
tion only in a solid-fuel burning masonry
or UL127 factory-built fireplace, or in an
approved ventless firebox. It is design
certified for these installations in accor-
dance with ANSI Z21.11.2. Exception: Do
not install this appliance in a factory-
built fireplace that includes instructions
stating it has not been tested or should
not be used with unvented gas logs.
WARNING: This is an unvented gas-fired heater. It uses air (oxygen) from the room in
which it is installed. Provisions for adequate combustion and ventilation air must be
provided. Refer to
Air for Combustion and Ventilation section on page 4 of this manual.
PIL
O T
O
F
F
O
N
LO
OFF
ON
AUTO
HI
FLAME-MAX
®
Models VYS18PWA,
VYS24PWA, and
VYS30PWA (Millivolt)
Remote Ready
VARIABLE MANUALLY-CONTROLLED MODELS ALSO
DESIGN-CERTIFIED AS VENTED DECORATIVE APPLIANCES
OWNER’S OPERATION AND INSTALLATION MANUAL
Patent Pending
* Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer
This appliance may be installed in an aftermarket*, permanently located, manufactured
(mobile) home, where not prohibited by local codes.
This appliance is only for use with the type of gas indicated on the rating plate. This
appliance is not convertible for use with other gases.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 105190 UNVENTED PROPANE/LP GAS LOG HEATER VANGUARD DANGER: Carbon monoxide poisoning may lead to death! Carbon Monoxide Poisoning: Early signs of carbon monoxide poisoning resemble the flu,with headaches, dizziness, or nausea. If youhave these signs, the heater may not be work-ing properly. Get fr...
3 105190 OWNER’S MANUAL 13. Do not use this heater to cook food or burn paper or other objects. 14. Do not use heater if any part has been exposed to or under water. Immediatelycall a qualified service technician to in-spect the room heater and to replace anypart of the control system and any gascon...
4 105190 UNVENTED PROPANE/LP GAS LOG HEATER VANGUARD PROVIDING ADEQUATEVENTILATION The following are excerpts from NationalFuel Gas Code ANSI Z223.1/NFPA 54, Sec-tion 5.3, Air for Combustion and Ventilation. All spaces in homes fall into one of the threefollowing ventilation classifications: 1. Unus...
