Vanguard UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER - Manual
Vanguard UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – UNVENTED PROPANE/LP GAS LOG HEATER; DANGER: Carbon monoxide; WARNINGS; WARNING: Any change to
- Page 3 – OWNER’S MANUAL; LOCAL CODES; CAUTION : Do not remove the; Figure 1 - Product Identification; Golden Oak Logs; Control Knob; OPERATION
- Page 4 – Unusually Tight Construction; per
- Page 5 – DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION; Determining if You Have a Confined or Unconfined Space; Continued
- Page 6 – Figure 3 - Ventilation Air from Outdoors; Ventilation Air From Outdoors; Do not provide openings for; Figure 2 - Ventilation Air from Inside Building
- Page 7 – INSTALLATION; CHECK GAS TYPE; B. Clearances from the top of the fireplace
- Page 8 – If Not Using Mantel; If using a mantel, proceed to If Using; Noncombustible; Noncombustible material OK.; Installing Damper; If you cannot meet these
- Page 9 – Figure 7 - Minimum Mantel Clearances When Using Hood; Figure 6 - Minimum Mantel Clearances Without Using Hood; MANTEL CLEARANCES; Hearth; FLOOR CLEARANCES; A. If installing appliance on the floor level,; flue damper open
- Page 10 – Make sure the heater burner; You prefer vented operation; Figure 10 - Attaching Damper Clamp; Damper; Masonry Fireplace
- Page 11 – Installation Items Needed; or masonry as applicable); Figure 11 - Attaching Flexible Gas Hose to Heater; Fitting
- Page 12 – Figure 14 - Gas Connection; CAUTION: Never connect; • external regulator (supplied by installer,; WARNING: Never connect
- Page 13 – Figure 15 - Manual Shutoff Valve; Open; Test Pressures In Excess Of 1/2 PSIG; opening propane supply tank valve.; WARNING: Never use an open; Correct all leaks at once.; Figure 16 - Checking Gas Joints; Open propane supply tank valve.
- Page 14 – WARNING: Failure to position; INSTALLING LOGS; Make sure; Figure 17 - Installing Golden Oak One-Piece Log Set; CAUTION: After installation; One Piece Log Set
- Page 15 – FOR YOUR SAFETY; • If fireplace has glass doors,
- Page 16 – Pilot Burner; CAUTION: Do not try to adjust; Shutting Off Heater; IMPORTANT; Thermostat Control Operation
- Page 17 – Figure 22 - Thermostat Hand-Held Remote Control Unit Selections; Figure 23 - Correct Pilot Flame Pattern; PILOT FLAME PATTERN; • turn heater off (see To Turn Off Gas to; BURNER PRIMARY AIR HOLES; This remote control
- Page 18 – WARNING: Turn off heater; Figure 26 - Pilot Inlet Air Hole; LOGS; • If you remove logs for cleaning, refer to; MAIN BURNER
- Page 19 – TROUBLESHOOTING; POSSIBLE CAUSE; All troubleshooting items are listed in
- Page 20 – OBSERVED PROBLEM; tenance, page 18) or replace burner orifice
- Page 22 – GOLDEN OAK
- Page 23 – PARTS LIST; KEY
- Page 24 – PARTS UNDER WARRANTY; SPECIFICATIONS; Golden Oak; SERVICE HINTS; When Gas Pressure Is Too Low; WIRING DIAGRAM; Note
- Page 25 – ACCESSORIES; FIREPLACE HOOD
- Page 26 – KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; LIMITED WARRANTY; For information about this warranty write:; INTERNATIONAL; NOT A UPC
®
Patent Pending
PIL
O T
O
F
F
O
N
LO
REMOTE
OFF
HI
FLAME-MAX
®
Golden Oak Log
Design
18", 24", 30", and 36"
Remote Ready Model
UNVENTED (VENT-FREE)
PROPANE/LP GAS LOG HEATER
®
Save this manual for future reference.
WARNING: If the information in this manual
is not followed exactly, a fire or explosion
may result causing property damage, per-
sonal injury, or loss of life.
— Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do
not use any phone in your building.
• Immediately call your gas supplier from
a neighbor’s phone. Follow the gas
supplier’s instructions.
• If you cannot reach your gas supplier,
call the fire department.
— Installation and service must be per-
formed by a qualified installer, service
agency, or the gas supplier.
WARNING: Improper installation, adjust-
ment, alteration, service, or maintenance
can cause injury or property damage.
Refer to this manual for correct installa-
tion and operational procedures. For as-
sistance or additional information con-
sult a qualified installer, service agency,
or the gas supplier.
WARNING: This appliance is for installa-
tion only in a solid-fuel burning masonry
or UL127 factory-built fireplace, or in an
approved ventless firebox. It is design
certified for these installations in accor-
dance with ANS Z21.11.2. Exception: Do
not install this appliance in a factory-
built fireplace that includes instructions
stating it has not been tested or should
not be used with unvented gas logs.
WARNING: This is an unvented gas-fired heater. It uses air (oxygen) from the room in
which it is installed. Provisions for adequate combustion and ventilation air must be
provided. Refer to
Air for Combustion and Ventilation section on page 4 of this manual.
This appliance may be installed in an aftermarket* manufactured (mobile) home, where not prohibited by state or
local codes.
* Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer
VARIABLE MANUALLY-CONTROLLED MODELS ALSO DESIGN-CERTIFIED AS A
VENTED DECORATIVE APPLIANCE
OWNER’S OPERATION AND INSTALLATION MANUAL
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 105274 UNVENTED PROPANE/LP GAS LOG HEATER VANGUARD FLAME-MAX ® SAFETYINFORMATION DANGER: Carbon monoxide poisoning may lead to death! Carbon Monoxide Poisoning: Early signs of carbon monoxide poisoning re-semble the flu, with headaches, dizziness,or nausea. If you have these signs, the heatermay n...
3 105274 OWNER’S MANUAL AUT O MAN OFF ST ATUS ON LO HI TEMP PRODUCTIDENTIFICATION LOCAL CODES Install and use heater with care. Follow alllocal codes. In the absence of local codes,use the latest edition of The National FuelGas Code ANS Z223.1, also known asNFPA 54*. *Available from: American Nation...
4 105274 UNVENTED PROPANE/LP GAS LOG HEATER VANGUARD FLAME-MAX ® PROVIDING ADEQUATEVENTILATION The following are excerpts from NationalFuel Gas Code. NFPA 54/ANS Z223.1, Sec-tion 5.3, Air for Combustion and Ventilation. All spaces in homes fall into one of the threefollowing ventilation classificati...
