Vanguard SBVRBP - Manual
Vanguard SBVRBP – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – WARNING: Any change to; WARNINGS; DANGER: Carbon monoxide; Carbon Monoxide Poisoning:
- Page 3 – OWNER’S MANUAL; American National Standards Institute, Inc.; LOCAL CODES; OPERATION
- Page 4 – Figure 3 - Clearances for Standard Installation; CAUTION: This stove with; Figure 4 - Clearance for Corner Installation
- Page 5 – STOVE BODY ASSEMBLY; Remove plastic bag from stove body.; Figure 7 - Laying Down Stove On Side; Continued; Figure 9 - Locating Threaded Holes for Legs and Door Attachment
- Page 6 – Figure 11 - Attaching Stove Door
- Page 7 – Figure 16 - Removing Rear Cover and Bottom Cover from Stove Body
- Page 8 – INSTALLING REAR COVER; Figure 20 - Control Valve Terminals; WARNING: Never touch the; Figure 18 - Blower Wiring Layout; Green Ground Wire
- Page 9 – WARNING: This gas stove with; Round Top
- Page 10 – CHECKING VENT CAPACITY; Figure 25 - Test for Proper Venting; When installing in a chase, you should; WARNING: Installation should; Figure 24 - Venting Through a Side Wall
- Page 12 – CHECK GAS TYPE; • Using a draft meter to determine if; FLUE GAS SPILLAGE
- Page 13 – Installation Items Needed; Figure 29 - Gas Connection; Cap Pipe Nipple Tee Joint
- Page 14 – Figure 31 - Equipment Shutoff Valve; WARNING: Never use an open; Open lower door panel.; Figure 30 - Flexible Gas Line
- Page 15 – Figure 32 - Checking Gas Joints for Propane/LP Gas Burner System; Gas Valve; Figure 33 - Checking Gas Joints for Natural Gas Burner System; Figure 34 - Control Valve Terminals; WARNING: Installation must
- Page 16 – Installing Remote Receiver; Open bottom door on stove body.; Figure 37 - Installing Battery in Receiver; Receiver; Figure 38 - Installing Remote Receiver; WARNING: Do not connect; The wire; Figure 35 - Back View of Thermostat Base; Terminal “W”; Set the temperature adjustment to the
- Page 17 – CAUTION: Do not operate this
- Page 18 – WARNING: Failure to position
- Page 19 – Figure 48 - Control Valve; Piezo Ignitor
- Page 20 – OPTIONAL REMOTE; Thermostat Control Operation; Lighting; GHRC Series Operation:; Flame Adjustment Knob; Shows Temperature Setting
- Page 21 – • turn burner system off (see To Turn Off; Figure 51 - Pilot Assembly; Thermopile
- Page 22 – WARNING: Turn off burner; GLASS DOOR; CAUTION: Wear gloves and; LOGS; ment Parts on page 26.; VENTING SYSTEM
- Page 23 – TROUBLESHOOTING; POSSIBLE CAUSE; nance, page 22) or replace pilot assembly; OBSERVED PROBLEM
- Page 24 – tenance, page 22) or replace burner orifice
- Page 26 – SERVICE HINTS; When Gas Pressure is Too Low:; WIRING DIAGRAM; CAUTION: Label all wires prior; PARTS UNDER WARRANTY
- Page 27 – SPECIFICATIONS; SBVRBN; ACCESSORIES
- Page 29 – PARTS LIST; PART NUMBER
- Page 31 – KEY; Bottom Door (Porcelain Enamel Teal Green); PARTS AVAILABLE — NOT SHOWN; Touch-up Paint Bottle with Brush (Porcelain Enamel Teal Green)
- Page 32 – For information about this warranty write:; INTERNATIONAL; KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; NOT A UPC
CAST IRON STOVE AND B-VENT
(FREESTANDING FIREPLACE HEATER)
BURNER SYSTEM
®
OWNER’S OPERATION AND INSTALLATION MANUAL
NATURAL GAS BURNER SYSTEM SBVRBN
PROPANE/LP GAS BURNER SYSTEM SBVRBP
REMOTE READY
Save this manual for future reference.
FOR YOUR SAFETY
WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch
• Do not use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s in-
structions.
• If you cannot reach your gas supplier, call the
fire department.
WARNING: Improper installation,
adjustment, alteration, service, or
maintenance can cause injury or
property damage. Refer to this
manual for correct installation and
operational procedures. For as-
sistance or additional information
consult a qualified installer, ser-
vice agency, or the gas supplier.
WARNING: If the information in this manual is not
followed exactly, a fire or explosion may result
causing property damage, personal injury, or loss
of life.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
— Installation and service must
be performed by a qualified in-
staller, service agency, or the
gas supplier.
IMPORTANT: This B-vent burner system must be installed into approved Vanguard cast iron
stove bodies, models SCIVFC series and PSCIVFC series ONLY. See page 3 of this manual.
This appliance may be installed in an aftermarket*, permanently located manufactured
(mobile) home, where not prohibited by state or local codes.
— This appliance is only for use
with the type of gas indicated on
the rating plate. This appliance is
not convertible for use with other
gases, unless a certified kit is used.
* Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 ® CAST IRON STOVE AND BURNER SYSTEM 106707 For more information, visit www.desatech.com SBVRBN AND SBVRBP SAFETYINFORMATION 1. This appliance is only for use with thetype of gas indicated on the rating plate.This appliance is not convertible for usewith other gases unless a certified kitis used. 2...
3 106707 OWNER’S MANUAL For more information, visit www.desatech.com P IL O T LO HI OFF ON PRODUCTIDENTIFICATION Install and use stove and burner system withcare. Follow all local codes. In the absenceto local codes, use the current National FuelGas Code ANS Z223.1, also known asNFPA 54* (USA) or th...
4 ® CAST IRON STOVE AND BURNER SYSTEM 106707 For more information, visit www.desatech.com SBVRBN AND SBVRBP LOCATION AND SPACEREQUIREMENTS Determine the safest and most efficient loca-tion for your Vanguard B-vent cast ironstove. Make sure that rafters and wall studsare not in the way of the venting...
