US Stove Company 6039HF - Manual
US Stove Company 6039HF – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Heat Output, Maximum; SPECIFICATIONS; Hearth Focus Multifuel Pellet; You've purchased one of America's Finest Multifuel Burning
- Page 3 – Assembly; Initial burn off may cause slight smoke and
- Page 4 – SAFETY STEPS; permits or inspection guidelines before installing the product.; DISCONNECT THE POWER CORD BEFORE SERVICING THIS STOVE!; BURNING SOLID FUELS
- Page 5 – FLOOR PROTECTION; INSTALLATION REQUIREMENTS; SHELLED CORN; WOOD PELLETS; CAUTION: DO NOT PLACE SUCH FUELS WITHIN THE SPACE HEATER’S INSTALLA-
- Page 6 – CLEARANCES TO COMBUSTIBLES; SIDE WALL; BACK WALL
- Page 7 – GUIDELINES FOR EXHAUST VENTING SYSTEMS DESIGN; DO NOT CONNECT TO ANY AIR DISTRIBUTION DUCT OR SYSTEM
- Page 8 – DESIGN GUIDELINES FOR OUTSIDE COMBUSTION AIR CONNECTION; 0 DEGREE BEND TERMINATION; Wind Hood
- Page 9 – FREESTANDING STOVE INSTALLATION REQUIREMENTS; MOBILE HOME INSTALLATION REQUIREMENTS; REQUIREMENTS ARE MANDATORY FOR INSTALLATION IN A MOBILE HOME:; WARNING; DO NOT INSTALL IN SLEEPING ROOM; CAUTION; ROOF MUST BE MAINTAINED.; Check with your local building official as other codes may apply.; INSTALLATION CONFIGURATIONS
- Page 10 – Dimensional tolerance; ’ Minimum
- Page 12 – REMOVAL OF BROKEN OR DAMAGED CERAMIC GLASS; CLEANING THE GLASS; GLASS MAINTENANCE, REMOVAL AND REPLACEMENT; GLASS CLIPS
- Page 13 – UNDERSTANDING THE CONTROL BOARD; CONTROL PANEL
- Page 14 – LIGHTING INSTRUCTIONS
- Page 15 – MAINTENANCE INSTRUCTIONS; Daily Maintenance; Soot and Flyash - Formation and Need for Removal; DISPOSAL OF ASHES; Disposal of Ashes
- Page 16 – FUEL ADDITIVE; These automatic safety features must not be bypassed; AUTOMATIC SAFETY FEATURES; Weekly Maintenance
- Page 17 – CIRCUIT BOARD FUNCTIONS
- Page 18 – ERROR CODES and DISPLAY INDICATORS
- Page 19 – TROUBLE SHOOTING; Unplug stove before performing any maintenance; PROBLEM
- Page 20 – WIRING DIAGRAM
- Page 21 – REPAIR PARTS DIAGRAM-6039HF
- Page 24 – THE PART DESCRIPTION; HOW TO ORDER REPAIR PARTS; United States Stove Company
USSC
1
851672
CORN & PELLET MULTIFUEL STOVE
6039HF
OWNER’S MANUAL
Installation - Operation - Maintenance Instructions - Repair Parts
READ THIS ENTIRE MANUAL, THOROUGHLY, BEFORE ATTEMPTING TO INSTALL AND/OR
BURN YOUR NEW HEARTH FOCUS CORN AND PELLET MULTI-FUEL STOVE. FAILURE TO FOL-
LOW THESE INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE, BODILY INJURIES OR
EVEN DEATH.
SAVE THESE INSTRUCTIONS
UNITED STATES STOVE COMPANY GRANTS NO WARRANTY, IMPLIED OR STATED,
FOR THE INSTALLATION OR MAINTENANCE OF THE STOVE AND ASSUMES NO
RESPONSIBILITY FOR ANY CONSEQUENTIAL DAMAGE(S).
UNITED STATES STOVE COMPANY - 227 INDUSTRIAL PARK ROAD-SOUTH PITTSBURG, TN. 37380
TECHNICAL ASSISTANCE (423) 837-2100 - (423) 837-2109 FAX
Safety Notice: If this stove is not properly installed, a house fire may result.
For your safety, follow the installation directions. Contact local building or fire officials
about restrictions and installation requirements peculiar to your area. Do Not Plug
this appliance into an electrical outlet before reading and understanding all operations
and always unplug the unit before attempting any work or maintenance. Do not
connect this stove to any chimney flue already serving another appliance. Carefully
observe and maintain all clearances to combustibles.
A note about fuel: Use only dried shelled corn with a moisture content of 14%
or less (11 to 12% provides the best results); any pellet fuel used should have
an ash content of 1% or less. If not, efficiency will suffer, and your warranty may be
voided.
Your Hearth Focus Corn/Pellet Stove operates on a negative pressure. Therefore, all
venting connections (elbows, T-pipe) must be sealed and airtight.
Use Hi-Temp silicone at each joint or connection.
K e e p i n g
K e e p i n g
K e e p i n g
K e e p i n g
K e e p i n g
N o r t h
N o r t h
N o r t h
N o r t h
N o r t h A m e r i c a W
A m e r i c a W
A m e r i c a W
A m e r i c a W
A m e r i c a W a r m
a r m
a r m
a r m
a r m
S i n c e 1 8 6 9
S i n c e 1 8 6 9
S i n c e 1 8 6 9
S i n c e 1 8 6 9
S i n c e 1 8 6 9
Hearth Focus
Hearth Focus
Hearth Focus
Hearth Focus
Hearth Focus
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 USSC Heat Input, Maixmum 52,200 BTU/HR Heat Output, Maximum , , , , , 48,280 BTU/HR Heating Capacity 1,200 Sq. Ft 0 Fuel Storage Capacity 60 Lbs. Width 29 in./737mm Height 31 in./787mm Depth 28 in./711mm SPECIFICATIONS United States Stove Company ( manufacturer of the Hearth Focus Multifuel Pellet...
USSC 3 6039HF ASSEMBLY Assembly 1. Unpack unit and make sure all components are included; (4) Legs and all hardware for installation.2. Inside the unit are two(2) Ash Dump Covers located to the left and right of the burnpot. Remove these for leg and guiderail assembly. (See pg. 15 for ash dump cover...
4 USSC Ashes will have to be Removed from the stove periodically. See cleaning procedure. Your Hearth Focus stove, due to the nature of solid fuels, will require brief periodic attention. Please do not expect to light your stove and walk away from it. A few moments of adjustment and cleaning from ti...
