U-Line U-2175RCB-00 - Manual

Page 2 - Table of Contents

1 - Safety Precautions Safety Alert Definitions......................................................................................................................................... 1General Precautions .................................................................................................

Page 3 - NOTICE; Safety Alert Definitions; General Precautions; DANGER; Safety Precautions

u-line.com 1 NOTICE • PLEASE READ all instructions before installing, operating, or servicing the appliance. • Proper installation procedures must be followed when completing an installation or relocation of a unit. An INSTALLATION GUIDE for the unit, providing complete installation information, is ...

Page 4 - Black and White Models:; for stainless steel on stainless surfaces (this includes; CAUTION; Model

2 u-line.com 2 Inspect & Plan Product Registration You have received a carton containing your U-Line Refrigerator, Refrigerator Freezer, Beverage Center or Wine Captain® unit with a package inside containing a Use and Care Guide, a Product Registration Card, and a water line kit. Please complete...

Page 5 - Electrical Specifications; WARNING; SHOCK HAZARD — Electrical Grounding Required.; Prepare Site

u-line.com 3 Your U-Line product has been designed for either free-standing or built-in installation. When built-in, your unit does not require additional air space for top, sides, or rear. However, the front grille must NOT be obstructed and clearance is required for an electrical connection in the...

Page 6 - Product Dimensions

4 u-line.com 4 Product Dimensions 2115R Series 2115WC / 2115WCOL Series 21175RC/RCG/RF Series 23-1/16" 34-1/8" 24" 2175R(C)(F) Black and White Models 2175R(C)(F)S(G) Stainless & Out Door Models 2175R(C)(F)S Overlay Models 24" 24" 34-1/8" 34-1/8" 3-13/16" 23-1/16&#...

Page 7 - 275ZWCOL Wood Overlay Model

u-line.com 5 34-1/8" 23-15/16" 22-5/8" 34-1/8" 2175BEVCS Stainless Steel Models 2175BEVCOL Wood Overlay Models 23-1/4" 3-13/16" 23-15/16" 3-13/16" 34-1/8" 24" 22-5/8" 34-1/8" 24" 2175WCCS Stainless Steel Models 2175WCCOL Wood Overlay Models 23-1/4&...

Page 8 - Door Swing Dimensions; Other Site Requirements; Power Supply

6 u-line.com 5 Door Swing Dimensions Units have a zero clearance for the door to open 90°. Stainless Steel models require 2-1/8" door clearance to accommodate the handle if installed next to a wall. Other Site Requirements Side-By-Side Installation For a complete refreshment center, install two ...

Page 9 - Door Alignment and Adjustment; • Properly aligned, the door’s gasket should be firmly in; Door Reversability

u-line.com 7 Door Alignment and Adjustment Align and adjust the door if it is not level, or is not sealing properly. If the door is not sealed the unit may not cool properly, or excessive frost may form in the interior. NOTICE • Properly aligned, the door’s gasket should be firmly in contact with th...

Page 10 - Reversing Black or White Doors; Remove Door; Remove existing top hinge.

8 u-line.com Reversing Black or White Doors • The hinge hardware will be removed and reinstalled on the opposite side of the cabinet. • The top hinge hardware will be reinstalled on the bottom of the opposite side of the cabinet. • The bottom hinge hardware will be reinstalled on the top of the oppo...

Page 11 - Reversing Stainless Steel Glass Doors; NOTCH; Screws; Pivot Plate

u-line.com 9 Remove preexisting bottom hinge. 1. Remove the preexisting bottom hinge (three screws) (2). Reinstall hinge to top opposite. 1. Install the hinge just removed from the bottom to the TOP opposite side of the cabinet (three screws) (2). Reinstall Hole Plugs. 1. Install plastic screw plugs...

Page 12 - Reinstall hinge to bottom opposite.

10 u-line.com 3. Grasp outer edge of stainless frame and firmly press inside edge of glass in while pulling stainless frame in opposite direction. 4. Unhinge frame from door. Assemble Stainless Frame 1. Prop frame against solid surface, handle side down and away 2. Insert door, logo forward, into fr...

Page 13 - Reinstall Hole Plugs.; Align and adjust the door:

u-line.com 11 Remove existing bottom hinge. 1. Remove the existing bottom hinge (three screws) (2). Reinstall hinge to top opposite. 1. Install the hinge just removed from the bottom to the TOP opposite side of the cabinet (three screws) (2). Reinstall Hole Plugs. 1. Install plastic screw plugs (thr...

Page 14 - • Your model may contain an electronic display panel in; Wood Trim Finishing; Staining and final finish application:

12 u-line.com CAUTION ! To prevent permanent damage to the inner liner of the unit, the wire rack wood trim MUST be removed from the unit for staining and/or finishing. Allow stain/finish to dry thoroughly (at least 24 hours) in accordance with the stain/finish manufacturer’s instructions, prior to ...

Page 15 - Door Panel Preparation; Panel Dimensions; Door Panel Installation

u-line.com 13 Custom 1/4'' Thick Door Panel Insert Door Panel Preparation A custom door panel may be inserted into the doorframe. Custom door panels can be flat or raised, as long as the maximum panel thickness, where inserted into the door reveal (channel), is no more than 1/4" thick. For raise...

Page 16 - Grille Overlay; Preparation; The grille overlay may only be installed on indoor units.; Installation; Hook and Loop Fastener Mount; Wood Grille Overlay

14 u-line.com Grille Overlay Your model’s grille is designed to accept a wood grille overlay. An overlay may be used to compliment a door overlay and provides a seamless look for your surrounding decor. Follow the instructions below to prepare and install your grille overlay. Be sure to read over th...

Page 17 - Grille Ov; Grille Drawing 24 inch

u-line.com 15 1/4 8-1/2 3-3/32 19-5/8 1/2 1/2 TYP 3X 5/16 TYP 2X (7/16 ) 5/16 10-5/16 11/64 2-1/8 1/2 22-7/8 23-7/8 FULL R Grille Ov erla y Dimensions 24 Inch Models Grille Drawing 24 inch

Page 18 - Grille Drawing 15inch

16 u-line.com 1/4 4-5/32 3-3/32 10-5/8 1/2 1/2 TYP 3X 5/16 TYP 2X (15/32 ) .275 5-29/32 11/64 2-1/8 1/2 13-7/8 14-7/8 FULL R Grille Ov erla y Dimensions 15 Inch Models Grille Drawing 15inch

Page 19 - Frame Preparation; 0 Overlay Frame; Dimension A Table; Dimension B Table

u-line.com 17 Frame Preparation 2115WCOL 2175WCCOL & 2175BEVCOL Models Only An overlay frame covers the door frame to give a built-in appearance. Appropriate hardware and a copy of these instructions will be included with the unit. NOTICE The thickness of the overlay panel must be 3/4". 1. U...

Page 20 - Prepare the New Overlay Panel; Attaching the Overlay Panel

18 u-line.com Prepare the New Overlay Panel NOTICE The overlay door panel must not weigh more than 20 lbs. The thickness of the door panel must be 3/4". 1. Place a towel, or similar, soft non-marking material out on a flat clean surface. Be sure the material is large enough to have the wood pane...

Page 21 - DO NOT; Assembling Door to Cabinet; Door closers

u-line.com 19 6. Use the door frame holes as a guide to drill pilot holes for the #6x1" pan head screws. 7. Attach the door to the overlay using #6x1" wood screws. NOTICE If you decide to drill pilot holes, remove the wood overlay from the door, and do not use a drill larger than 7/64". ...

Page 22 - Leveling Information; It is recommended that the unit is level.; 1 Installation; Relocating the Shelves; Glass Shelves on Right-Hand Hinge Units; Installation Troubleshooting; Problem

20 u-line.com 11 Leveling Information It is recommended that the unit is level. 13. Use a level to check the levelness of the unit from front to back and from side to side. Level should be placed along top edge and side edge as shown. 14. If the unit is not level, adjust the feet on the corners of t...

Page 23 - INSTALLATION GUIDE; The American Built-In Undercounter Leader Since 1962; BUILDING ON THREE GENERATIONS OF INNOVATION; choice and product that will fit any lifestyle.; PRODUCT INFORMATION

® INSTALLATION GUIDE ©2013 U-Line Corporation Publication Number 30282 4/2013 Rev.J The American Built-In Undercounter Leader Since 1962 U-LINE.COM BUILDING ON THREE GENERATIONS OF INNOVATION For over five decades and through three generations, U-Line continues to be the leader in innovation, qualit...

U-Line U-2175RCB-00 - Manual

Table of Contents:

Summary

Other U-Line Models