U-Line 0 U-CLRCO2175B-40 - Manual

2 u-line.com Model Features: High daily ice production and storage. The CLR2160 produces up to 60 pounds of ice per day and stores up to 30 pounds. While the CLRCO2175 can produce up to 40 pounds of ice per day and store up to 15 pounds. Electronic control module. Automatically adjusts for changes i...

u-line.com 3 Air Flow NOTICE The unit requires proper air flow to perform at its highest efficiency. Do not block the front grille or internal fans at any time, or the unit will not perform as expected. Do not install the unit behind a door. Initial Startup All U-Line controls are preset at the fact...

4 u-line.com Checking Product Temperature To check the actual product temperature in the unit. 1. Partially fill a plastic (nonbreakable) bottle with water. 2. Insert an accurate thermometer. 3. Tighten the bottle cap securely. 4. Place the bottle in the desired area for 24 hours. 5. Avoid opening t...

u-line.com 5 Electronic Control Quick Guide Task Touch Touch Display Comment Turn ON/OFF Hold 5 seconds Release when °F flashes. or Adjust Temperature CLRCO2175 or Touch and release or Touch to change temperature °F flashes after first touch, set-point saved after 5 seconds of inactivity and °F stop...

6 u-line.com Clear Ice Maker Cleaning Cycle Units with a serial number beginning with an 09 or greater have an automatic clean alert function. Cleaning cycles should be run as notified. Otherwise, To maintain operational efficiency the unit should be cleaned every three months. Depending on water co...

u-line.com 7 NOTICE • Discard all ice produced in the first harvest.• Should power to the unit be interrupted during the self-clean cycle, it will be necessary to repeat the complete cleaning cycle after power is restored. Refresh Kit Due to variations in water quality or inadequate maintenance your...

8 u-line.com Leveling NOTICE Unit must be level, for proper door and ice maker (if equipped) operation. For Models with adjustable leveling feet: 1. Use a level to check the levelness of the unit from front to back and from side to side. Place the level along top edge and side edge as shown (1). 2. ...

u-line.com 9 Removing and Installing Grille WARNING ! Disconnect electric power to the unit before removing the grille. WARNING ! DO NOT touch the condenser fins (4). The condenser fins are SHARP and can be easily damaged. Removing the grille. 1. Disconnect power to the unit. 2. Loosen the two screw...

10 u-line.com Door Alignment and Adjustment Align and adjust the door if it is not level, or is not sealing properly. If the door is not sealed the unit may not cool properly, or excessive frost may form in the interior. NOTICE • Properly aligned, the door’s gasket should be firmly in contact with t...

u-line.com 11 Reversing Black or White Doors • The hinge hardware will be removed and reinstalled on the opposite side of the cabinet. • The top hinge hardware will be reinstalled on the bottom of the opposite side of the cabinet. • The bottom hinge hardware will be reinstalled on the top of the opp...

12 u-line.com Remove preexisting bottom hinge. 1. Remove the preexisting bottom hinge (three screws) (2). Reinstall hinge to top opposite. 1. Install the hinge just removed from the bottom to the TOP opposite side of the cabinet (three screws) (2). Reinstall Hole Plugs. 1. Install plastic screw plug...

u-line.com 15 . Exterior Cleaning Vinyl Clad (Black or White) Models: • Clean surfaces with a mild detergent and warm water solution. Do not use solvent-based or abrasive cleaners. Use a soft sponge and rinse with clean water. Wipe with a soft, clean towel to prevent water spotting. • Clean any glas...

16 u-line.com Condenser Cleaning Interval - Every Three Months To maintain operational efficiency, keep the front grille free of dust and lint, and clean the condenser every three months. Depending on environmental conditions, more or less frequent cleaning may be necessary. WARNING ! Disconnect ele...

u-line.com 17 Before Calling for Service If you think your U-Line product is malfunctioning, read the OPERATION section of this guide to clearly understand the function of the control. If the problem persists, read the NORMAL OPERATING SOUNDS and TROUBLESHOOTING GUIDE section of this guide to help y...

® USE AND CARE GUIDE ©2013 U-Line Corporation Publication Number 30268 4/2013 Rev.G The American Built-In Undercounter Leader Since 1962 U-LINE.COM BUILDING ON THREE GENERATIONS OF INNOVATION For over five decades and through three generations, U-Line continues to be the leader in innovation, qualit...