Schumacher SE-1010-2 - Manual
Schumacher SE-1010-2 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Wear complete eye protection and clothing; NEVER; smoke or allow a spark or flame in the vicinity of; GROUND AND AC POWER CORD CONNECTIONS
- Page 3 – OPERATING INSTRUCTION: CHARGING BATTERY IN VEHICLE; Position AC power cord and DC charging cords to reduce risk of; Negative GROUNDED POST; OPERATING INSTRUCTION: CHARGING BATTERY OUT OF VEHICLE; POSITIVE
- Page 4 – METER FUNCTIONS; PERCENT OF CHARGE; DC AMPS; CHARGING
- Page 6 – maintenance free batteries. Read instructions on battery.; LIMITED WARRANTY
1
GENERAL BATTERY SAFETY
1.
Before you use your battery charger, be sure to read all
instructions and cautions printed on:
• Battery Charger
• Battery
• Vehicle or unit using battery
2.
Use battery charger on LEAD ACID type rechargeable bat-
teries only, such as used in autos, trucks, tractors, airplanes,
vans, RV's, trolling, motors, etc. Charger is not intended to
supply power to low-voltage electrical system other than in
an automotive application.
WARNING:
Do not use battery charger for charging dry-
cell batteries that are commonly used with home appliances.
These batteries may burst and cause injury to persons and
damage to property.
3.
Use only attachments recommended or sold by manufac-
turer. Use of non-recommended attachments may result in
fire, electric shock, or injury.
4.
When disconnecting the battery charger, pull by the plug,
not by the cord. Pulling on the cord may cause damage to
cord or plug.
5.
Locate battery power cord so it cannot be stepped on, tripped
over, or subjected to damage or stress.
6.
Do not operate charger with damaged cord or plug. Have
cord replaced immediately.
7.
Do not operate charger if it has received a sharp blow, been
dropped, or otherwise damaged in any way. Take it to a
qualified professional for inspection and repair.
8.
Do not disassemble charger. Take it to a qualified profes-
sional when service or repair is required. Incorrect reas-
sembly may result in electric shock or fire.
9.
To reduce risk of electric shock, unplug charger from outlet
before attempting any maintenance or cleaning.
10. Do not use an extension cord unless absolutely necessary.
Use of an improper extension cord could result in fire or
electric shock. If an extension cord must be used, make
sure that:
• Pins on plug of extension cord are the same number,
size, and shape as those of plug on charger.
• Extension cord is properly wired and in good electrical
condition.
• Wire size is large enough for AC ampere rating of charger,
as specified below:
_____________________________________________
Length of cord (feet): 25
50 100 150
AWG size of cord:
16
14 10
8
_____________________________________________
11. Always charge battery in a well ventilated area.
NEVER
operate in a closed-in or restricted area without
adequate ventilation.
WARNING:
Risk of explosive gas.
12. Locate charger as far away from battery as DC charger
cables permit.
13. Do not expose charger to rain or snow.
14.
NEVER
charge a frozen battery. If battery fluid (electrolyte)
is frozen, bring into a warm area to thaw before charging.
15.
NEVER
allow battery acid to drip on charger when reading
specific gravity or filling battery.
16.
NEVER
set a battery on top of charger.
17.
NEVER
place charger directly above battery being charged.
Gases from battery will corrode and damage charger.
18.
NEVER
touch the battery clips together when the charger
is energized.
WARNING:
Battery chargers get hot during operation and must
have proper ventilation. Air needs to flow around entire
charger. Do not set on flammable items like carpeting, up-
holstery, paper, cardboard, etc. Charger
will damage leather
and melt plastic and rubber.
A.
00-00-000496/0103
Read Rules for Safe Operation and Instructions Carefully
Working in vicinity of a lead-acid battery is dangerous. Batteries generate explosive gases during normal
battery operation. For this reason, it is of utmost importance that each time before using your charger, you
read this manual and follow the instructions exactly.
Owner's Manual
–Save–
Important Safety Instructions
WARNING:
Handling the cord on this product or cords associated with accessories sold with this product, will expose you to lead, a
chemical known to the State of California to cause cancer and birth defects or other reproductive harm.
Wash hands after handling
.
SE-1010-2, SE-1012D
SE-1052, SE-1250
Battery
Charger
Models:
SCHUMACHER ELECTRIC CORPORATION
801 BUSINESS CENTER DRIVE • MOUNT PROSPECT, ILLINOIS 60056-2179
Send Warranty Product Repairs to: 1025 E. Thompson, Hoopeston, IL 60942-0280
Call Customer Service if you have questions: 1-800-621-5485
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 Charging Hours 3-6 Hrs. 6-8 Hrs. 3-5 Hrs. 2 minutes on 5 minutes off 5 seconds on 240 seconds off D. PREPARING TO CHARGE Charger Selection Guide (see section H) Ampere Rating 2 amp 6 amp 10 amp 30 amp Boost 50 amp Engine Start Recommended Battery Uses Charge motorcycle, snow-mobile, lawnmower, tri...
3 E. OPERATING INSTRUCTION: CHARGING BATTERY IN VEHICLE 1. Position AC power cord and DC charging cords to reduce risk of damage by hood, door, or moving engine parts. 2. Stay clear of fan blades, belts, pulleys, and other parts that can cause injury. 3. Check polarity of battery posts. Battery case...
4 G. METER FUNCTIONS PERCENT OF CHARGE The percent of charge scale is intended as a visual aid to help simplify detemmining the stateof charge. It is scaled for use with the 6 or 10 amp charge rates only. For the 2 amp chargerate, use the red triangle.The percent of charge is based on current draw b...
