Schumacher PS-5250 - Manual

1

1.

Before you use your battery charger, be sure to read all
instructions and cautions printed on:

• Battery Charger

• Battery

• Vehicle or unit using battery

2.

Use battery charger on LEAD ACID type rechargeable bat-
teries only, such as used in autos, trucks, tractors, airplanes,
vans, RV's, trolling motors, etc. Charger is not intended to
supply power to low-voltage electrical system other than in
an automotive application.

WARNING:

Do not use battery charger for charging dry-

cell batteries that are commonly used with home appliances.
These batteries may burst and cause injury to persons and
damage to property.

3.

Use only attachments recommended or sold by manufac-
turer. Use of non-recommended attachments may result in
fire, electric shock, or injury.

4.

When disconnecting the battery charger, pull by the plug
not by the cord. Pulling on the cord may cause damage to
cord or plug.

5.

Locate battery power cord so it cannot be stepped on, tripped
over, or subjected to damage or stress.

6.

Do not operate charger with damaged cord or plug. Have
cord replaced immediately.

7.

Do not operate charger if it has received a sharp blow, been
dropped, or otherwise damaged in any way. Take it to a
qualified professional for inspection and repair.

8.

Do not disassemble charger. Take it to a qualified profes-
sional when service or repair is required. Incorrect reas-
sembly may result in electric shock or fire.

9.

To reduce risk of electric shock, unplug charger from outlet
before attempting any maintenance or cleaning.

10. Do not use an extension cord unless absolutely necessary.

Use of an improper extension cord could result in fire or
electric shock. If an extension cord must be used, make
sure that:

• Pins on plug of extension cord are the same number,

size, and shape as those of the plug on the charger.

• Extension cord is properly wired and in good electrical

condition.

• Wire size is large enough for AC ampere rating of charger,

as specified below:

Length of cord (feet):

25

50

100

150

AWG* size of cord:

16

14

10

8

*AWG-American Wire Gauge

11. Always charge battery in a well ventilated area.

NEVER

operate in a closed-in or restricted area without

adequate ventilation because of risk of explosive gases.

WARNING:

Risk of explosive gas.

12. Locate charger as far away from battery as DC charger

cables permit.

13. Do not expose charger to rain or snow.

14.

NEVER

charge a frozen battery. If battery fluid (electrolyte)

is frozen, bring into a warm area to thaw before charging.

15.

NEVER

allow battery acid to drip on charger when reading

specific gravity or filling battery.

16.

NEVER

set a battery on top of charger.

17.

NEVER

place charger directly above battery being charged.

Gases from battery will corrode and damage charger.

18.

NEVER

touch the battery clips together when the charger is

energized.

–Save–

Important Safety Instructions

Read instructions and rules for safe operation carefully.

Working in the vicinity of a lead-acid battery is dangerous. Batteries generate explosive gases
during normal battery operation. For this reason, it is of utmost importance that each time
before using your charger, you read this manual and follow the instructions exactly.

A.

GENERAL BATTERY SAFETY

00-99-000300/902

INSTRUCTION MANUAL

MODEL #

AMPS

VOLTS

ENGINE START

PS-2352

2/35

12

200

PS-5250

10/50

6/12

125/250

PS-8050

30/60

6/12

200/300

PS-3000

30/44/60/80

6/12/18/24

180/200

For
Lead-Acid
Batteries