Raypak 514-824 - Manual
Raypak 514-824 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 3 – CONTENTS
- Page 4 – PART ONE - OWNER’S OPERATING INSTRUCTIONS; FOR YOUR SAFETY - READ BEFORE OPERATING; OPERATING INSTRUCTIONS AND SHUT-OFF PROCEDURES
- Page 5 – OPERATING INSTRUCTIONS
- Page 7 – SECTION 1/RECEIVING EQUIPMENT; CALIFORNIA PROPOSITION 65 WARNING:; PART TWO - INSTALLATION/SERVICE INSTRUCTIONS
- Page 8 – HIGH WIND CONDITIONS; In areas where high winds are fre-; OUTDOOR HEATERS; Installation must be in accordance with local codes,; BASE INSTALLATION; Heater must be mounted on a level base, such as; CLEARANCES; ALL HEATERS
- Page 10 – ANSI
- Page 11 – GAS SUPPLY CONNECTIONS
- Page 12 – PLUMBING FOR WATER CONNECTIONS; When 2” piping is used into the heater, this; DO NOT
- Page 14 – To avoid water damage or scalding due to valve; ELECTRICAL WIRING; The Electronic Intermittent Ignition Device automati-
- Page 19 – SECTION 4/SERVICING INSRUCTIONS; General Location of Controls
- Page 20 – ADJUSTMENT KNOB
- Page 21 – If the heat exchanger is sooted badly, the burner
- Page 22 – In extreme cases it may be necessary to remove; REFACTORY PANELS TOP VIEW
- Page 23 – SECTION 5/TROUBLESHOOTING GUIDE; IMPORTANT NOTICE
- Page 25 – WARNING; HIGH VOLTAGE; Intermittent Pilot System; TROUBLESHOOTING HONEYWELL S8600; START; ELECTRICAL
- Page 26 – SECTION 6/REPLACEMENT PARTS LIST; Any part returned for replacement under standard
- Page 27 – this page is empty
P/N 240499 Rev. 15
CATALOG NO: 6200.50N
Effective:
04-09-07
Replaces:
04-15-05
INSTALLATION
AND OPERATING
INSTRUCTIONS
COMMERCIAL
SWIMMING POOL
HEATERS
Raytherm
Models 514-824
This manual should be maintained in legible condition and kept adjacent to the
heater or kept in a safe place for future reference.
WARNING: If the information in these instructions are not followed exactly, a fire or
explosion may result causing property damage, personal injury or death.
—
WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not use any phone in your building.
•
Immediately call your gas supplier from a neighbor's phone. Follow the gas
supplier's instructions.
•
If you cannot reach your gas supplier, call the fire department.
—
Installation and service must be performed by a qualified installer, service agency or
the gas supplier.
—
Do not store or use gasoline or other flammable vapors and liquids in the vicinity of
this or any other appliance.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
4 PART ONE - OWNER’S OPERATING INSTRUCTIONS 4 SECTION 1/START-UP PROCEDURES 4 Before Start-Up 5 Operating Instructions 6 After Start-up 6 SECTION 2/CAUTION 6 SECTION 3/MAINTENANCE AND CARE PROCEDURES Pool & Spa Water Chemistry 7 PART TWO - INSTALLATION/SERVICE INSTRUCTIONS 7 SECTION 1/RECEIVING ...
PART ONE - OWNER’S OPERATING INSTRUCTIONS FOR YOUR SAFETY - READ BEFORE OPERATING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAYRESULT, CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. SECTION 1/START-UP PROCEDURES BEFORE START-UP BURNERS Clean main burners and a...
5 1. STOP! Read the safety information on the preceeding page. 2. Set the thermostat on the lowest setting. 3. Turn off all electric power to the appliance. 4. Remove heater door panel. 5. This appliance is equipped with an ignition devicewhich automatically lights the pilot. Do not try to lightthe ...
