Lennox EPIC40 - Manual
Lennox EPIC40 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Cautions and Safety
- Page 3 – Table of Contents
- Page 4 – Certification
- Page 6 – Features; RATINGS; NATURAL GAS; P4 Efficiency
- Page 7 – Figure 1
- Page 8 – Clearances to Combustibles; Parallel Installation; Alcove dimensions; Alcove Dimensions; Figure 3; Pipe Clearances
- Page 9 – Installation; Figure 6
- Page 10 – Do not cover any secondary air holes or gas ports (see; Burner Pan Diagram; Firebox Setup; Figure 7
- Page 11 – Brick Panel Installation; CAUTION: The brick panels are required for your appli-; Figure 9
- Page 12 – Log Set and Ember Installation; NOTE: All logs are designed to fit only one way. For the
- Page 13 – Vent Installation; Page 16. Consult your local building codes; Residential and Mobile Home Installations:
- Page 14 – Vent Parts List; Part Number; Horizontal Vent Installation
- Page 15 – Vertical Vent Installation; Important Notes; Flue Restrictors
- Page 16 – Vertical Terminations; NOTE: Horizontal pipe requires 1/4” rise for every 12”; Horizontal Terminations
- Page 17 – Exterior Horizontal Vent Termination Clearance Requirements; Minimum Clearances
- Page 18 – Gas Line Installation; Gas Pressure Requirements; A MAJOR CAUSE OF OPERATING PROBLEMS WITH GAS; LP and Natural Gas Supplies:; Check all connections
- Page 19 – OPERATING INSTRUCTIONS; Operating Instructions; Lighting Instructions:
- Page 20 – Flame Color and Behavior; TO TURN OFF GAS TO APPLIANCE; Burner Flame Appearance; WARNINGS
- Page 21 – Air Shutter Adjustment Handle, highlighted
- Page 22 – Operating Options; Millivolt Control Schematic; Millivolt Control System; CAUTION: Label all wires prior to disconnection when; Gas Valve
- Page 23 – Maintenance and Servicing; Maintenance Checklist:
- Page 25 – Opening and Removing Door; CAUTION: Do not attempt to open the main door while
- Page 26 – CAUTION: Label all wires prior to disconnection when
- Page 27 – Troubleshooting; ply inlet is in the “ON” position.; SYMPTOM
- Page 28 – Parts List
- Page 30 – Wire Harness Diagram; dangerous operation. Verify proper operation after servicing.; POWER CORD; RING LUG CRIMP
- Page 31 – Replacement Parts List; Description
- Page 32 – Accessories
- Page 33 – Lighting Label; FOR YOUR SAFETY READ BEFORE OPERATING
- Page 34 – Safety / Listing Label
- Page 35 – Notes
- Page 36 – Natural Gas; WARRANTY
Report No. 050-S-21b-5
INSTALLATION AND OPERATION MANUAL
WARNINGS
•
Hot! Do not touch! The glass and surfaces of this appliance will be hot during operation and will
retain heat for a while after shutting off the appliance. Severe burns may result.
•
Carefully supervise children in the same room as appliance.
Do not store or use gasoline or other flammable
vapors or liquids in the vicinity of this or any other
appliance.
WHAT TO DO IF YOU SMELL GAS:
• Do not light any appliance.
• Do not touch any electrical switch; do not
Use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone. Follow your gas supplier's
instructions.
• If your gas supplier cannot be reached, call
the fire department.
Installation and service must be performed by a quali-
fied installer, service agency or the gas supplier
.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser d'essence
ni d'autres vapeurs ou liquides inflammables à proximité de
cet appareil ou de tout autre appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une odeur
de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur.
• Ne pas vous servir des téléphones se trouvant dans le bâti-
ment
• Appelez immédiatement votre fournisseur de gaz depuis un
voisin. Suivez les instructions du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz, appelez
le service des incendies.
L'installation et l'entretien doivent être assurés par un
installateur ou un service d'entretien qualifié ou par le
fournisseur de gaz.
WARNING: If the information in this manual is not
followed exactly, a fire or explosion may result
causing property damage, personal injury or loss
of life.
AVERTISSEMENT: Assurez-vous de bien suivre les instruc-
tions données dans cette notice pour réduire au minimum
le risque d’incendie ou d’explosion ou pour éviter tout
dommage matériel, toute blessure ou la mort.
•
These appliances may be installed in an aftermarket permanently located, manufactured (mobile) home (USA
only), where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the
rating plate. This appliance is not convertible for use with other gases unless a certified kit is used.
•
Lennox™ gas-burning appliances are designed for use as a supplemental heater. They are not intended for
continuous use as a primary heat source.
Epic™ 33/40 (EPIC33/40)
I
n the Commonwealth of Massachusetts:
• Installation must be performed by a licensed plumber or gas fitter
• See Table of Contents for location of additional Commonwealth of
Massachusetts requirements
US
Direct-Vent
Gas Stove
Retain These Instructions For Future Reference
A French manual is available upon request. Order P/N 775,223CF. Ce manuel d’installation
est disponible en francais, simplement en faire la demande. Numéro de la pièce 775,223CF.
P/N 775,223M Rev. B, 03/2008
The Epic™ Gas Stove is factory equipped for 40,000 BTU input
and can be converted to 33,000 using the smaller orifice provided.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
FOR YOUR SAFETY do not install or operate your Epic™ gas stove without first reading and understanding this manual. Any installation or operation of the appliance deviating from that which is stated in this manual WILL void the warranty and may be hazardous. INSTALLATION AND REPAIR SHOULD ONLY B...
3 Table of Contents Cautions and Safety ....................................................................................................... Orifice Size / Altitude Adjustment ....................................................................................... 4 Codes and Approvals ..............
4 Orifice Size/Altitude Adjustment For altitudes above 2,000 feet (In Canada 4,500 FT/1370 M),the orifice should be de-rated by 4% for every 1,000 feet to maintain the proper ratio of gas to air. Improper orifice sizing may result in damage and unsafe conditions. Chang- ing the orifice should only b...
