Husqvarna 535LK - User Manual

Page 2 - Product description

Contents Introduction..................................................................... 2Safety..............................................................................4Assembly...................................................................... 10Operation....................................

Page 3 - Symbols on the product

9. Throttle trigger lockout10. Spark plug cap and spark plug11. Cylinder cover12. Starter rope handle13. Fuel tank14. Air filter cover15. Air purge bulb16. Choke control17. Handle adjustment18. Drive disc19. Operator's manual20. Hex key21. Locking pin22. Shaft coupling23. Combination wrench24. Muffl...

Page 4 - Safety; Safety definitions

yyyywwxxxx The rating plate shows the serial number. yyyy is the production year, ww is the production week. Note: Other symbols/decals on the product refer to certification requirements for some markets. Euro V Emissions WARNING: Tampering with the engine voids the EU type-approval of this product....

Page 9 - Safety instructions for maintenance

• Do a visual check for damage and deformation. Note: Do not remove the muffler from the product. • Make sure that the muffler is correctly attached to the product. • If the muffler on your product has a spark arrester screen, do a visual check. Replace the spark arrester screen if it is damaged.a) ...

Page 10 - Assembly; Introduction

Assembly Introduction WARNING: Before you assemble the product, you must read and understand the safety chapter. WARNING: Remove the spark plug cable from the spark plug before you assemble the product. To attach the loop handle 1. Attach the loop handle onto the shaft between the arrows. 2. Move th...

Page 12 - Operation; Fuel

Operation Fuel This product has a two-stroke engine. CAUTION: Incorrect type of fuel can result in engine damage. Use a mixture of gasoline and two-stroke oil. Gasoline CAUTION: Always use a quality gasoline/oil mixture of at least 90 octane (RON). There is a risk that use of lower octane grade caus...

Page 14 - To start the product; To stop the product

To start the product WARNING: Read the warning instructions in the safety chapter before you start the product (refer to Safety on page 4). 1. Use protective gloves.2. Hold the body of the product on the ground with your left hand. CAUTION: Do not use your feet! 3. Hold the starter rope handle with ...

Page 15 - Maintenance; To adjust the idle speed

4. Use 80 % throttle when you cut grass near objects. To cut the grass 1. Make sure that the trimmer line is parallel to the ground when you cut the grass. 2. Do not push the trimmer head to the ground. This can cause damage to the product. 3. Move the product from side to side when you cut grass. U...

Page 18 - Maintenance schedule

3. Remove the grease plug. 4. Look into the grease plug hole and turn the drive shaft. The grease level (A) must be in level with the top of the gear cogs (B). A B 5. If the grease level is too low fill the bevel gear with Husqvarna bevel gear grease. Fill slowly and turn the drive shaft as you appl...

Page 19 - Troubleshooting; The engine does not start

Maintenance Daily Weekly Monthly Examine the starter and the starter rope for damages. X Examine the vibration damping units for damages and cracks. X Clean the outside of the spark plug. Remove it and do a check of the electrode gap. Adjust the gap to the correct distance (see, To do a check of the...

Page 20 - The engine starts but stops again; Transportation, storage and disposal; Transportation and storage; Technical data

The engine starts but stops again Check Possible cause Procedure Fuel tank. Incorrect fuel type. Empty the fuel tank and fill it with cor- rect fuel. Air filter. The air filter is clogged. Clean the air filter. Transportation, storage and disposal Transportation and storage • Store and transport the...

Page 21 - Accessories

535LK Speed-regulated ignition system Yes Ignition system Spark plug Champion RCJ 6Y Electrode gap, mm 0.5 Fuel and lubrication system Fuel tank capacity, litre/cm 3 0.6/600 Weight Without fuel, cutting attachment and guard, kg 5.8 Noise emissions 1 Sound power level, measured dB (A) 111 Sound power...

Page 23 - Declaration of Conformity; EU Declaration of Conformity

Declaration of Conformity EU Declaration of Conformity We, Husqvarna AB, SE-561 82 Huskvarna, Sweden, tel: +46-36-146500, declare on our sole responsibility that the product: Description Grass trimmer Brand Husqvarna Type / Model 535LK Identification Serial numbers dating from 2024 and onwards compl...

Page 24 - Tri Cut

1 3 4 5 2 6 7 8 B Tri Cut x 10 A 6 Nm 24 331 - 013 - 03.12.2024