HP DB-102 Manual - Free PDF Download

Page 2 - TABLE OF CONTENTS; Operating Instructions

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 2 TABLE OF CONTENTS Specifications 3 1.0 Operating Instructions 4 1.1 Introduction 4 1.2 Wood-Burning 4 1.3 Storage of Wood 5 1.4 Maximum Solid-Fuel Charge 6 1.5 Maintenance 6 1.5.1 Cleaning 6 1.5.2 Servicing 7 1.6 Safety 7 1.7 Controls 7 1.8 El...

Page 3 - SPECIFICATIONS; NOTE; SAVE THESE INSTRUCTIONS

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 3 KERR SCOTTY Wood Furnace Model DB-102 Certified by the Canadian Standards Association Manufactured by: Parrsboro Metal Fabricators Ltd. P.O. Box 637, Crossroads 12118, Highway 209 Parrsboro, Nova Scotia, Canada B0M 1S0 SPECIFICATIONS Length 46...

Page 4 - OPERATING INSTRUCTIONS; use chemicals or fluids to start the fire or during operation.; DO NOT

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 4 1.0 OPERATING INSTRUCTIONS 1.1 INTRODUCTION Congratulations on your purchase of the KERR SCOTTY Wood Furnace. Developed in Atlantic Canada, this KERR Furnace has been designed to allow you to heat your home with wood, one of North America’s mo...

Page 5 - CREOSOTE; STORAGE OF WOOD

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 5 CREOSOTE Wood combustion is never 100% complete. Wood smoke always contains some unburned gases and a mixture of unburned tar-like liquids. A percentage of these materials will condense out on any cool surface, leaving a dark brown or black su...

Page 6 - exchanger and exposed surfaces.

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 6 1.4 MAXIMUM SOLID-FUEL CHARGE The maximum level for a solid-fuel charge is the middle of the loading door, or the level of the handle. DO NOT OVERFILL. The KERR SCOTTY Wood Furnace will accept whole or split logs up to 27 in. (686 mm) long, bu...

Page 7 - – No other waste shall be placed in this container.

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 7 DISPOSAL OF ASHES Ashes should be placed in a metal container with a tight fitting lid. The closed container of ashes should be placed on a non-combustible floor or on the ground, well away from all combustible materials, pending final disposa...

Page 8 - ELECTRICAL POWER FAILURE; IMPORTANT; the following procedure is followed.

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 8 1.8 ELECTRICAL POWER FAILURE If no one is home during a power failure, the damper will automatically close and some gravity heating will take place. Combustion air will continue to enter through the secondary air holes and a fire should be mai...

Page 9 - HOMEOWNER CHECKLIST; INSTALLATION INSTRUCTIONS; Applicable Standards

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 9 1.9 HOMEOWNER CHECKLIST o Keep area around unit clean and clear of combustibles. o Use only dry wood. DO NOT burn garbage, gasoline or naphtha. o Load carefully. o Remove ashes as directed. o Watch for soot in smoke pipe – clean regularly. o C...

Page 10 - CONTROL KIT B; LOCATING THE FURNACE

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 10 2.2 UNCRATING When you receive your KERR SCOTTY Wood Furnace, check it carefully to ensure that all components are present and in good condition. If there has been any damage or loss in transportation, please notify the carrier and retailer a...

Page 11 - Air inlets of at least 200 square inches free area (1.5 in

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 11 2.4.1 COMBUSTION AIR SUPPLY Air inlets of at least 200 square inches free area (1.5 in 2 /1000Btu) must be provided to the room occupied by the wood fired or oil fired furnace. These fresh air inlets must provide or allow free access of fresh...

Page 12 - Front

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 12 We recommend that the KERR SCOTTY Wood Furnace be connected to its own chimney. However, two or more fuel fired appliances, other than fireplaces or incinerators, may be connected to the same chimney. The National Standard of Canada, Installa...

Page 13 - WARM AIR DUCT & PLENUM CLEARANCES; DUCT CONNECTION; Approved Furnace Ductwork Configurations.

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 13 WARM AIR DUCT & PLENUM CLEARANCES The following clearances must be observed and must meet all local building, electrical and fire codes. Follow the National Standard of Canada, Installation Code for Solid Fuel Burning Appliances and Equip...

Page 14 - ALL ELECTRICAL WIRING MUST CONFORM TO NATIONAL AND LOCAL CODES.; T822 – Room Thermostat – Wood Furnace; Set Points; ALL ELECTRICAL WIRING MUST CONFIRM TO NATIONAL AND LOCAL CODES.

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 14 2.7 FREE-STANDING (Fig S102-4) The KERR SCOTTY Wood Furnace is designed to be the sole source of central heating in medium sized, well-insulated houses using an integral blower to circulate warm air. In this system connect the ductwork, as yo...

Page 15 - INSTALLERS FINAL CHECKLIST; use firebrick in the furnace

SCOTTY WOOD FURNACE – INSTRUCTION MANUAL Scotty Oct-06 15 2.9 INSTALLERS FINAL CHECKLIST DUCTWORK INSPECTION 1) Furnace ducted properly? 2) Proper duct clearances maintained? FURNACE INSPECTION 1) DO NOT use firebrick in the furnace 2) Check settings on fan limit controls. WIRING INSPECTION 1) Is ma...

Page 23 - Terms and Conditions of Warranty

Terms and Conditions of Warranty 1) The warranty is not assignable and rights pursuant to it are given only to the original purchaser of the furnace from an authorized retailer. 2) The warranty is null and void unless the original purchaser fully completes the warranty registration card and the card...

Page 24 - ATTENTION HEATING CONTRACTOR; SCOTTY; YEAR; CAUTION; Kerr Heating Products

ATTENTION HEATING CONTRACTOR : THIS WARRANTY IS FOR THE ORIGINAL PURCHASER AND SHOULD BE GIVEN TO HIM/HER OR PLACED IN SIGHT NEAR THE WOOD FURNACE. SCOTTY WOOD FURNACE 5 YEAR WARRANTY Subject to the terms and conditions on the reverse side hereof Kerr Heating Products (hereinafter called “Kerr”) war...