Char-Broil 463250108 - Manual

WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Turn ...

6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE...

WARNING For Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly. • Use grill only in well-ventilated space. NEVE...

Burner Flame Check • Remove cooking grates and troughs. Light burners, rotate knobs from to . You should see a smaller flame in position than seen on . Perform burner flame check on sideburner, also. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low fla...

CAUTION Storing Your Grill • Clean cooking grates.• Store in dry location.• When LP cylinder is connected to grill, store outdoors in a well- ventilated space and out of reach of children. • Cover grill if stored outdoors. Choose from a variety of grill covers offered by manufacturer. • Store grill ...

10 • 463250108 Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. To keep food safe from harmful bacteria, follow these four basic steps: Clean: Wash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry. Separate:...

463250108 • 11 CARE AND CLEANING OF YOUR STAINLESS STEEL GRILL Routine cleaning is necessary to preserve the appearance and corrosion resistance of Stainless Steel. The perception that many people have is that stainless steel will not rust. That is not the case in certain conditions. Rust marks are ...

463250108 • 13 PARTS DIAGRAM – Model No. 463250108 JJ J E ZZ G Y EEE Z VV UU WW T DDD GG FF PP RR U TT LL NN I II YY D FFF CCC BB CC K X A B C F L M O P Q R S FF FF DD DD SS SS AA HH KK KK KK MM QQ XX AAA BBB GGG KK HHH III OO JJJ V W N EE H

Right and Left Shelf Assembly 1 A To wel Ba r Right Side Shelf 1/4” Flat Washer C Tabs into Cut-outs And Holes over Bulges D B 1/4-20x3/4” Screw 1/4” Flat Washer 1/4” Lock Washer 1/4-20x1-1/2” Screw 1/4” lock Washer 1/4” Flat Washer 1/4-20x1/2” Screw Attach two 1/4-20x3/4” screws, 1/4” flat washers ...

Sideburner Assembly 2 Correct Alignment A Burner Tube Sideburner Valve C D #10-24x3/8” Screw #10 Lock Washer 5mm silicon washer #10-24x3/8” Screw #10 Lock Washer 5mm Silicon Washer Insert the side burner into the cut-out shown C , place the side burner on support bracket, align and insert these stud...

Sideburner Control Knob Assembly A Control Knob Sideburner Bezel Fasia Sideburner Shelf Valve Stem Position sideburner valve bracket beneath sideburner shelffascia so that valve stem comes through larger center hole infascia shown A . Attach sideburner bezel to fascia using two #8-32x3/8” screws sho...

ox Trough Install 5 bled Rack Trough A Trough B First, place Trough Middle onto Firebox shown A . 18 • 463250108 Trough Middle Front Rear Rear Front Second, Place Trough A and Trough B onto Firebox. Make sure this is put in the right direction as show in B. A B Trough Middle Front Rear

Cooking Grate and Warming Rack 6 bled Rack 463250108 • 19 Place cooking grates onto the firebox as shown. Place the Warming Rack onto the the firebox.Make sure insert the Warming Rack ends into the holes properly shown as below. Fire box Cooking Grate Warming Rack

7 Condiment Basket Assembly 　 Open the door and place the Condiment Basket on the left door inside, make sure the insert the pivots of the Condiment Backet into the bracket which riveted together the door inside shown as below. 20 • 463250108

Battery Cap Battery Positive(+) side up towards Cap + - 8 Electronic Ignition 463250108 • 21 　 Unscrew electronic ignition button left side panel of cart. Insert AA battery into ignitor, negative (—) end first . Replace button.

LP Tank . Tank Screw at rear of cart CAUTION LP Tank valve must face to front of cart once tank is attached. Failure to install cylinder correctly may allow gas hose to be damaged in operation, resulting in the risk of fire. 9 Always keep LP tank in upright position during use, transport, and storag...

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire ...

Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also) Burner(s) will notmatch light. Sudden drop in gasflow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback...(fire in burner tube(s)). Unable to fill LP c...

463250108 • 25 Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when control knob turned to ; no noise can be heard from spark module. SECTION II No sparks appear at any electrodes when control knob turned to ; noise can be heard from spark module...

LIMITED WARRANTY Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer...

Mail to: / Envíelo a:Consumer Warranty ServiceP. O. Box 1240Columbus, GA 31902-1240 Thank you for completing this questionnaire. Your answers will help us and other companies reach you with offers that may interest you. If you prefer not to receive these offers, please check here .Gracias por comple...

STOP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-888-430-7870 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. Grilling Safety Checklist Read and understand owners manual. Nev...