Char-Broil 463742112 - Manual

Page 2 - For residential use only. Do not use for commercial; DANGER; TABLE OF CONTENTS; DANGER; THIS GRILL IS FOR OUTDOOR USE ONLY.; CAUTION

For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3 Grilling Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7 Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-13 Limited Warranty . . . ...

Page 3 - Wash your hands after handling this product.; National Fuel Gas; over tighten screws and

3 WARNING CALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm. 2. This product contains chemicals, including lead and lead compounds, known to the State of C...

Page 4 - Turn on the appropriate control knob and light the grill per the; Pre-Heating Your Grill; GRILLING GUIDE – Getting Started; Regulator

4 First Time Use Read your Assembly Manual and ensure the grill is put together properly. Remove all Point-of-Purchase advertising material from all grill surfaces before first use. We recommend operating your grill on its highest setting for 15-20 minutes prior to your first use. This aids in remov...

Page 5 - GRILLING GUIDE – Grilling 101

5 Outdoor grilling is really quite simple. You'll succeed with burgers, dogs, or steaks usually on your very first try. With experience, you will learn how to work with your grill, creating more imaginative meals all the time. This knowledge makes up the art of grilling. Before you start grilling, o...

Page 7 - GRILLING GUIDE – Cleaning Your Grill; Storing Your Grill

7 Why Clean? We've all heard the saying 'An ounce of prevention is worth a pound of cure'. This is great advice when it comes to keeping your grill clean. Routine Care Periodic cleaning of this grill is necessary,as grill fires can occur when grease andfood debris collect in the bottom of the grill....

Page 8 - USE AND CARE; OPD Hand Wheel; LP Cylinder Filling; LP Cylinder Valve

8 • NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property ...

Page 9 - Connecting Regulator to the LP Cylinder; full stop; Safety Relief Valve; Strap and Cap; LP Cylinder Exchange; Exchange your cylinder only; LP Cylinder Leak Test; Do not use household cleaning agents.

9 WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Tur...

Page 10 - Leak Testing Valves, Hose and Regulator; rushing sound; immediately

10 6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. N...

Page 11 - Do not let children operate or play near grill.; Lighting instructions are continued on the next page

11 WARNING For Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly. • Use grill only in well-ventilated space. N...

Page 12 - Troubleshooting Section; LOW; Sideburner Ignitor Lighting

12 Burner Flame Check • Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW . You should see a smaller flame in LOW position than seen on HI . Perform burner flame check on sideburner, also. Always check flame prior to each use. If only low flame is seen refer to "...

Page 13 - Cleaning the Burner Assembly; Turn gas OFF at control knobs and LP cylinder.; Cleaning the Burner; Firebox

13 Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn gas OFF at control knobs and LP cylinder. 2. Remove cooking grates and flame tamers. 3. Remove carryover tubes and burners. 4. 5. Carefully lift eac...

Page 14 - ITEMS MANUFACTURER WILL NOT PAY FOR:; DISCLAIMER OF IMPLIED WARRANTIES and LIMITATION OF REMEDIES; LIMITED WARRANTY; SCOPE OF COVERAGE

14 This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indica...

Page 15 - PARTS LIST; Key Qty Description

PARTS LIST 15 Key Qty Description A 1 TOP LID B 2 UPPER HINGE C 1 LOGO PLATE D 1 HANDLE E 1 FIREBOX F 2 LOWER HINGE G 2 BURNER H 2 HEAT TENT I 1 FLAME CARRYOVER TUBE J 1 ELECTRODE K 1 GREASE CUP CLIP L 1 GREASE CUP M 1 COOKING GRATE N 1 SWINGAWAY GRID O 1 LEFT CART FRAME P 1 RIGHT CART FRAME Q 1 UPP...

Page 16 - PARTS DIAGRAM

A B D E F G H I J K L M N O P Q R S T U V W X Y Z AA BB CC BB CC DD EE FF GG GG HH II JJ KK LL MM NN OO PARTS DIAGRAM 16 C

Page 17 - Upper Back Brace; ASSEMBLY

ASSEMBLY 1 2 17 Lay the cart frames down. Place front panel between cart frames. Hook the holes to the preassembled #10-24x1/2’’ machine screws. Tighten the screws. Lower Back Brace, Upper Back Brace and Rear Tank Exclusion Wire Attach back braces to back of cart by inserting the ribs on back braces...

Page 18 - Tank Exclusion Wire; lef; Wheel assembly and Leg extender

18 3 4 Tank Exclusion Wire Hook tank exclusion wire onto right front leg. Flex tank exclusion wire to insert other end into the hole on left rear leg. Hook the other tank exclusion wire onto lef t front leg. Flex tank exclusion wire to insert other end into the hole on lower side brace on right cart...

Page 19 - Firebox Assembly; Wing Screw

5 6 19 Firebox Assembly Press down the pins on upper side braces. Slide firebox assembly along upper side brace from front to rear of cart assembly, until the pins snap into the holes on firebox support braces. Make sure the brackets on firebox support brace are fitted into the opening of the bracke...

Page 20 - Sideburner; Knob

7 20 Sideburner Feed the screws preassembled on sideburner valve brackets into keyhole slots on the fascia, turn it to lock in place, then tighten the screws (A). Place sideburner into sideburner drip pan. Make sure sideburner valve is inside sideburner tube. Secure sideburner with 5x9 fiber washer ...

Page 22 - Grease Cup and Grease Cup Clip; Grease Cup; Swing Away; Pivot Wire

10 11 22 Failure to install grease cup clip and cup will cause hot grease to drip from bottom of grill with risk of fire or property damage. CAUTION Grease Cup and Grease Cup Clip Hang grease cup clip from bottom of firebox, and place grease cup into grease cup clip. Grease Cup Clip Grease Cup Swing...

Page 23 - See Use & Care section of this manual to perform; to side or front of cart as shown; Correctly Installed

12 Hang tank collar on tank retainer . Make sure the bottom of tank is set into the bracket on tank support brace . LP CYLINDER IS SOLD SEPARATELY. Fill and leak check the cylinder before attaching to grill and regulator (see Use & Care section). Once cylinder has been filled and leak checked, p...

Page 24 - Troubleshooting

24 DANGER: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire co...

Page 25 - continued; Problem

25 Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor. Burner(s) will notmatch light. Low flame, drop in gas flow. Flames blow out. Flare-up. Persistent grease fire. Flashback...(fire in burner tube(s)). Unable to fill LP cylinder. Possible Cause PIEZO PUSH-BUTTON AND ROTAR...

Page 26 - NOTES