Page 2 - Stardance Natural Vent Gas Heater; Table of Contents
2 2 Stardance Natural Vent Gas Heater 20007067 PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS BEFORE USING APPLIANCE. Thank you and congratulations on your purchase of a Vermont Castings stove. IMPORTANT: Read all instructions and warnings carefully before starting installation. Failure t...
Page 3 - Completion of sale, nor for purpose of resale,; General Information
3 Stardance Natural Vent Gas Heater 20007067 The Stardance Natural Vent Room Heater, Model Nos. 3980- 3996 is a vented gas appliance listed to the ANSI standard Z21.88b-2002 and CSA-2.33b-2002 for Vented Room Heaters, and CSA 2.17-M91, Gas-Fired Appliances For Use at High Al-titudes. The installatio...
Page 4 - Stardance fully assembled; Stardance dimensions.; Stardance Natural Vent Gas Heater Dimensions
4 4 Stardance Natural Vent Gas Heater 20007067 9" (229mm) CL Valve Inlet 26 ��� " (680 mm) 25" (635 mm) 14 ��� " (355 mm) 3" (76 mm) CL 7067 Stardance fully assembled dimensions 12/22/03 djt Valve Inlet See Page 5 for Flue Collar Centerline Dimensions. 4406 Fig. 1 Stardance dimen...
Page 6 - Venting Requirements and Options; Input
6 6 Stardance Natural Vent Gas Heater 20007067 Venting Requirements and Options The Stardance must be properly connected to a listed 4” (102 mm) Type B venting system or to an approved Class A masonry or factory-built chimney system. In Canada, a complete relining of Class A chimney sys-tems is requ...
Page 7 - Passing Through a; It is essential to seal between the ceil-; Ceiling pass thru; A ceiling pass-through, with decorative pipe around the; Venting Requirements; Venting Runs; NOTE: When venting staight vertical, without an; (Measured from top of the unit before any elbow
7 Stardance Natural Vent Gas Heater 20007067 Passing Through a Combustible Wall or Ceiling An approved pass-through device is always required when a vent passes through a combustible wall or ceil-ing. Check with the maker of the vent system for the correct listed devices that are available. A listed...
Page 8 - Remove the snapstat and grommet from the bracket; WARNING; Install the Optional Fan; Installation; Unpack the Stove; Attach the fan assembly to the fan bracket.; CAUTION
8 8 Stardance Natural Vent Gas Heater 20007067 ST640 RUVSOD snapstat 7/01 Snapstat Bracket Snapstat Module Pinch Grommet to Remove ST670 Fig. 9 Remove the snapstat and grommet from the bracket 4. Connect snapstat leads. Disconnect the snapstat module from the leads inside the snapstat bracket. (Fig....
Page 9 - JUV; Venting System Assembly; attach
9 Stardance Natural Vent Gas Heater 20007067 ST194 attach fan to shroud 11/99 Outer Shroud Slot Inner Shroud Slot ST194 Fig. 10 Position the fan to engage the inner shroud with the fan bracket slots and secure with sheet metal screws. ST347a JUV FK28 rheostat install 9/21/00 Retaining Nut Control Kn...
Page 10 - Install decorative pipe over the B-vent pipe.; Paint Option for Enamelled Stoves; Gas connection should be made in ac-
10 10 Stardance Natural Vent Gas Heater 20007067 Insert the B-vent adapter into the flue collar and drill 1/8” (3mm) pilot holes through both the stove’s collar and the adapter. Attach the adapter to the flue collar with sheet metal screws. (Fig. 15)Attach the first section of venting to the B-vent ada...
Page 11 - Burner Information; In order to connect Natural Gas,; Install ON/OFF Switch; attach switch assy; Attach switch assembly to rear shroud.; THIS APPLIANCE SHOULD BE CON-; attach switch; Attach switch wires to valve.; Install the Log Set; Thermostat
11 Stardance Natural Vent Gas Heater 20007067 Burner Information The appliance must only use the gas specified on the rating plate, unless converted using a Fuel Conversion Kit. Refer to Page 25 for the correct Fuel Conversion Kit for your model. Conversion instructions are provided with each kit and...
Page 12 - Install the Front Plate; This completes assembly of the Stardance stove.; Completed log installation.; Stardance; Install the front plate.
12 12 Stardance Natural Vent Gas Heater 20007067 Install the Front Plate Hold the front plate by the window bars and lift it into position, engaging the two steel tabs on the top corners behind the adjacent bosses in the side plates. (Fig. 21) Then seat the Front against the sides so the tabs at the...
Page 13 - To open the front doors, turn handle clockwise.; Operation; Your First Fire; handle holder; When not in use, store handle in the handle holder.; Pilot Assembly location.; Flame & Temperature Adjustment; Flame adjustment knob for Honeywell valve.; Correct pilot and burner flame pattern.
13 Stardance Natural Vent Gas Heater 20007067 Fig. 22 To open the front doors, turn handle clockwise. ST261 Stardance operable doors 1/31/01 Clockwise to Open Counterclockwise to Close ST624 The Stardance is operated with the operable door front plate in place with the doors open or closed. To open ...
Page 14 - FOR YOUR SAFETY READ BEFORE LIGHTING; WHAT TO DO IF YOU SMELL GAS; To Turn Off Gas To Heater; Lighting and Operating Instructions; Lighting Instructions; Euro SIT
14 14 Stardance Natural Vent Gas Heater 20007067 3. Open control access panel.4. Push in gas control knob slightly and turn clock- wise to “OFF”. Do not force. 5. Close control access panel. 1. STOP! Read the safety information above. 2. Turn off all electrical power to the fireplace.3. For MN/MP/TN/...
Page 15 - Troubleshooting / Honeywell #8420 Gas Control System; SYMPTOM
15 Stardance Natural Vent Gas Heater 20007067 A. Defective or misaligned Using a match, light [ilot. If pilot lights, turn off pilot and electrode at the pilot push the ignitor button again. If pilot will not light, check gap at electrode and pilot - it should be 1/8” to have a strong spark. B. Defe...
Page 16 - Conversion Precautions; Fuel Conversion Instructions; Remove rear log bracket and left and right log; Attach the gas line to the left side of the valve.
16 16 Stardance Natural Vent Gas Heater 20007067 Conversion Precautions Conversion must be completed only by qualified personnel. Before proceeding, turn control knob on valve to OFF and turn gas supply OFF. Turn OFF any electricity that may be going to the appliance. CAU- TION: Allow stove to cool c...
Page 17 - Remove mounting screws, pressure regulator tower; SIT; Pilot Orifice Conversion; Install the conversion orifice.; Gas Conversion; Remove pilot orifice.; Be sure burner leg remains at a 90° angle to; LP air shutter settings.
17 Stardance Natural Vent Gas Heater 20007067 FC107 SIT820 valve conversion 10/03 A B C OFF PIL OT O Fig. 30 Remove mounting screws, pressure regulator tower and spring and diaphragm assembly. FC107 D E F FC108 SIT regulator conversion 10/03 OFF PIL OT O FC108 Fig. 31 Replace regulator. 3. Install t...
Page 18 - Remove and replace injector orifices.; injector orifice; Conversion to LP; Table 2. Injector Orifice Size Matrix
18 18 Stardance Natural Vent Gas Heater 20007067 17. Replace burner. Slide the burner in at an angle with left side lower than the right side. Slide the left side onto the injectors, making sure the burner leg remains at a 90° angle to the base. Lower the right hand side down in to place. Make sure ...
Page 19 - Maintenance; ERATE THE HEATER WITH DAMAGED LOGS.; painted surfaces; Remove the Stove Front.
19 Stardance Natural Vent Gas Heater 20007067 Maintenance Your Stardance Gas Heater will provide years of service with minimal upkeep. The following procedures will help ensure that your stove continues to function properly. Annual System Inspection Have the entire heater and venting system inspecte...
Page 20 - Gasket Replacement; Determine the correct length of gasket by laying it; Inspect the Vent System Annually; glass gasket detail; Wrap the gasket material around the outside edge of; Stove Disassembly; Correct flame pattern.; Release the latches to release the glass frame.
20 20 Stardance Natural Vent Gas Heater 20007067 Gasket Replacement The Stardance Gas Heater uses a ‘tadpole’ type gasket to seal between the glass panel and the frame. In time, this gasket can become brittle and compressed and should be replaced. New gasket is available from your dealer.Shut off th...
Page 21 - Safety Limit Switch wiring.; rdv connections diag.; Schematic Diagram; Wiring Diagrams; On/off switch and optional thermostat circuit.; wiring
21 Stardance Natural Vent Gas Heater 20007067 NOTE: IF ANY OF THE ORIGINAL WIRE, AS SUP- PLIED WITH THE APPLIANCE, MUST BE RE-PLACED, IT MUST BE REPLACED WITH TYPE SF-2, 200°C WIRE OR ITS EQUIVALENT. ST665 Fig. 42 Safety Limit Switch wiring. Ther m ocoupl e Safety Limit Switch Valve ST665 Safety Lim...
Page 22 - Stardance Natural Vent Gas Heater (SNV30); SDV30 Log Set Assembly
22 22 Stardance Natural Vent Gas Heater 20007067 1a 1b 1c PILOT ON OFF PILOT ADJ LO HI 3 5 6 7 20 8a,b 18 4 9a,b 17 19 7067 Stardance NV fully assembled parts 11/20/03 djt 23 24 22 a,b,c,d 25 27 21 28 26 30 31 32 2 29 11 12 15 10 13 14 16a,b 35 33 34 36 37 38 39 40 42a,b 43 CFM Corporation reserves ...
Page 24 - Refer to Enamel Parts Chart Page 24
24 24 Stardance Natural Vent Gas Heater 20007067 Stardance Natural Vent Gas Heater (SNV30) (continued) Models 3980-3996 Fuel Conversion Kits Conversion Kit, NG to LP - SNV30RN Kit #000-5022 Conversion Kit, LP to NG - SNV30RP Kit #000-5021 Shell Enamel Part Numbers Color Top Left End Right End Front ...
Page 25 - Optional Accessories Available; Fan Kits; To open doors, insert handle and turn. Store handle; Screen install; Hold screen at an angle to attach bottom hangers.
25 Stardance Natural Vent Gas Heater 20007067 Optional Accessories Available Fan Kits FK26 Fan The FK26 fan kit helps distribute heated air from within the firebox out into the room. The fan is controlled by a snapstat that turns power on and off as the firebox tem-perature rises above and falls below...
Page 26 - Screen in place; Warming Shelf; Decorative Rings; Model; Outside Air Adapter
26 26 Stardance Natural Vent Gas Heater 20007067 KT231 Screen in place 6/13/01 djt KT231 Fig. 46 Screen in place. Warming Shelf Warming shelves add versatility to your stove and can be used to keep foods warm at mealtime. Model Color 2702 Classic Black 2684 Biscuit 2685 Chestnut Brown 2688 Vt. Class...
Page 30 - IF WARRANTY SERVICE IS NEEDED...; ) Contact your supplier. Make sure you have your warranty,; LIMITED LIFETIME WARRANTY; PRODUCT COVERED BY THIS WARRANTY
30 30 Stardance Natural Vent Gas Heater 20007067 BASIC WARRANTY CFM Corporation (hereinafter referred to collectively as the Company) warrants that your new Vermont Castings or Majestic Gas Fireplace/Stove is free from manufacturing and material defects for a period of one year from the date of purc...
Page 31 - SI UN SERVICE SOUS GARANTIE EST REQUIS...
31 Stardance Natural Vent Gas Heater 20007067 GARANTIE DE BASE La société CFM Corporation (ci-après la « Société ») garantit votre nouveau poêle/foyer au gaz Vermont Castings ou Majestic contre tous défauts de fabrication et de matières premières pour une période d’un an à compter de la date d’achat...
Page 32 - Efficiency Ratings; CFM Corporation
Efficiency Ratings Model EnerGuide Ratings Fireplace Efficiency (%) SNV30RN 51.1 SNV30RP 51.1 410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 800-668-5323 • www.cfmcorp.com CFM Corporation