Vermont Casting 2465 - Manual

Table of Contents:

• Page 2 – Dutchwest Direct Vent / Natural Vent Gas Heater; Table of Contents
• Page 3 – General Information
• Page 4 – Dutchwest Direct Vent / Natural Vent Dimensions; CL; Dutchwest dimensions.; Attention
• Page 5 – Installation Requirements; Locating the Stove; We do not recommend the use of wallpaper; Dutchwest; Direct Vent System Only; A. Flat on corner wall; Possible stove locations.; Clearance Requirements; Always maintain required clear-
• Page 6 – Stove Clearance
• Page 7 – Input; Gas Specifications; Dutchwest Direct Vent/Natural Vent; High Elevations; Horizontal Termination -; Horizontal vent termination window.
• Page 8 – Vertical Termination - Direct Vent ONLY; NOTE: The restrictor plate supplied; A vertically terminated vent system must; Vertical vent termination window.; Vent Termination Clearances; IMPORTANT
• Page 9 – Venting Termination Clearances; • Venting terminals shall not be recessed into a wall or; Location of Vent Termination
• Page 10 – Canadian Installations; General Venting Information - Termination Location
• Page 11 – Termination clearances.; Venting Requirements - Natural Vent Only; Venting Runs; NOTE: When venting staight vertical, without any; Vent termination window - Natural Vent ONLY.; Outside Corner; Termination Clearances; with no side wall; of Caps
• Page 12 – Venting Requirements and Options -
• Page 13 – Install the Optional Fan; Fan kit components.; Remove the rear skirt insert panel at the bottom of; Remove rear skirt insert.; attach fan; Attach the fan assembly and the snapstat.
• Page 14 – Venting System Assembly - Direct Vent; For Canadian installations:; Install the Vent Adapter Pipe; Install the restrictor plate only if required for the vent-; Dry fit the Outer pipe assembly; attach inner pipe; Connect the inner starter with the next section of in-; attach inner assy; Attach inner assembly to flue collar.; attach inner assy
• Page 15 – Discard the inner starter pipe; dura vent; Simpson DuraVent - install inner adapter pipe.; DW dura vent; Simpson DuraVent - install outer adapter pipe.; Side Wall Termination Assembly; Vent Opening; CFM System; Locate vent opening.; Assemble the wall sleeve and firestop.
• Page 16 – For DuraVent pipe only:; DW; Determine the vertical pipe length.; measure thru wall; Measure the horizontal length.; install pipe thru wall; Install the horizontal pipe and wall plate parts.; install wall terminal; Install the vent terminal.
• Page 17 – Vent Termination Below Grade; If the; install snorkel; snorkel detail; Use extension brackets to mount snorkel against; Vent Assembly
• Page 18 – vent thru ceiling; Install firestops and attic insulation shield.; vent thru roof; Roof support and flashing.; Venting System Assembly - Natural Vent; Decorative 7” pipe may be fitted around the B-vent; Install the Vent Pipe
• Page 19 – Install draft hood adapter.; Install the Log Set; Stardance; Connect the Gas Supply Line; CAUTION
• Page 20 – Burner Information; Air Shutter Adjustment Instructions; In order to connect Natural Gas,; Air Shutter Adjustment; Model; Remove stove front.; Jefferson; Remove rear log bracket and left and right log
• Page 21 – Air shutter adjusted.; air shutter adjust; Be sure to maintain 90° angle at left burner leg.; Complete the Assembly; attach switch assy; Attach switch assembly to rear shroud.; attach switch; Attach switch wires to valve.
• Page 22 – Thermostat; Install the wall thermostat in the desired location and; Install the Stove Front; handle assy; Insert handle stub into hole in front. Secure with 3/8”; Install the front plate.
• Page 23 – Operation; Your First Fire; Pilot assembly location.; Flame & Temperature Adjustment; Flame adjustment knob for Honeywell valve.; Flame Characteristics; Pilot flame; Correct pilot and burner flame patterns.
• Page 24 – FOR YOUR SAFETY READ BEFORE LIGHTING; Follow the gas supplier’s instructions.; To Turn Off Gas To Heater; Lighting and Operating Instructions; Lighting Instructions; Euro SIT; Lighting instructions
• Page 25 – Troubleshooting / Honeywell #8420 Gas Control System; SYMPTOM
• Page 26 – Fuel Conversion Instructions; Attach the gas line to the left side of the valve.; Conversion Precautions; Honeywell Valve
• Page 27 – Pilot Orifice Conversion; Remove mounting screws, pressure regulator tower; SIT; gas conversion; Remove pilot orifice.; Remove pilot hood. (Your pilot may have a different; Gas Conversion; Remove pilot orifice.
• Page 28 – Replace burner. Slide the burner in at an angle; Table 2. Injector Orifice Size Matrix
• Page 29 – Maintenance; ERATE THE HEATER WITH DAMAGED LOGS.; Remove the stove front.; glass swivel latch; Release the latches to release the glass frame.
• Page 30 – Gasket Replacement; Determine the correct length of gasket by laying it; Check the Gas Flame Regularly; glass gasket detail; Wrap the gasket material around the outside edge of; Inspect the Vent System Annually; Correct flame pattern.; Stove Disassembly
• Page 31 – Wiring Diagrams; On/Off switch and optional thermostat circuit.; IF ANY OF THE ORIGINAL WIRE, AS; Draft hood adapter wiring.; AN; BLK; FK26 wiring diagram; Schematic Diagram
• Page 32 – Small Lava Rock Package
• Page 33 – Pilot Top Convertible; Fuel Conversion Kits
• Page 34 – Optional Accessories; Fan Kits; Refer to Page 13 for installation instructions.; Remote Controls; ON/OFF and Temperature; Decorative Rings
• Page 35 – LIMITED LIFETIME WARRANTY; BASIC WARRANTY; IF WARRANTY SERVICE IS NEEDED...; ) Contact your supplier. Make sure you have your warranty, your
• Page 36 – Efficiency Ratings; CFM Corporation