Keating 2005 - Manuals - manualsarea.com

Page 2 - WARNING; Improper installation; WARNIN; Disconnect all power

NOTICE: This operating, installation, and service manual should be given to the user. The operator of the Top- Side Cooker ™ should be familiar with its functions and operation. This manual must be kept in a prominent, easily reachable location near the Top-Side Cooker ™ . NOTICE: Keating of Chicago...

Page 3 - I INTRODUCTION; GENERAL; II INSTALLATION; What to do if equipment arrives damaged:; INSTALLATION

1 I INTRODUCTION GENERAL Keating Top-Side ™ Cookers are designed to give maximum production efficiency, delivering high qualityfood products. The following design features areincorporated into Keating Top-Side ™ Cookers. STANDARDFEATURES Stainless steel control panel Stainless steel head cover MIRAC...

Page 4 - THIS APPLIANCE MUST BE EARTHED.; III OPERATING; OPERATION OF THE TOP-SIDE; COOKING

2 ELECTRICALCONNECTION Each Keating Top-Side ™ Cooking head is equipped with a 9' (2.74m) neoprene covered, 12 gauge 4mm(2),three wire with ground electrical cord. Each cookinghead is rated 4000W, 18 amps, single phase at 220Volts and is designed to be connected to its own 208-240V single phase elec...

Page 5 - SHUTDOWN

3 Programming To program the timers, the unit must be in the idlemode. Press and hold the set button for approximatelytwo seconds. The display will show “SEt”. Press T1, T2or T3 for the cook time to be programmed. The displaywill show the current setting for that cook time. Use theup or down button ...

Page 6 - IV MAINTENANCE; WARRANTY REPAIRS

4 Do not hack, chop or hit the surface. You will dent thesteel plate under the trivalent chrome. It is evenpossible to hack two nicks close together and actuallytear the MIRACLEAN ® surface as the chromium will not stretch. Below is a sketch showing a side view of acooking head and how the surface c...

Page 8 - V SERVICE DIAGNOSIS; Disconnect power before servicing.

6 V SERVICE DIAGNOSIS A properly adjusted Keating Top-Side ™ Cooker, with no load, will cycle “ON” approximately every 5 1 / 2 to 6 1 / 2 minutes. Each cycle will last 40 seconds, ensuring thatthe temperature setting is held within a narrow range. A. Trouble-Shooting The following diagnosis is only ...

Page 9 - TROUBLESHOOTING THE THERMOSTAT; or; For troubleshooting the thermocouple, use the chart below

Temperature (°F) Resistance (Ohm) 95 0.30 100 3.80 125 4.60 150 5.50 175 6.40 200 7.90 225 8.40 250 9.70 275 10.90 300 12.40 325 13.80 350 15.10 375 17.00 400 18.40 425 20.20 450 21.30 475 23.30 7 TROUBLESHOOTING THE THERMOSTAT Temperature reading is incorrect,showing a sensor error, or LOAD LED is ...

Page 10 - VI EXPLODED VIEW & PARTS LIST; ORDERING PARTS; Refer to the Keating Top-Side; WARNING AND OPERATING PLATES; All warning and operating plates on the Keating Top-Side; COOKER; MICRO

8 VI EXPLODED VIEW & PARTS LIST ORDERING PARTS Parts may be ordered by part number by calling 1-800-KEATING or your local service company. You may also orderonline at Keating’s part store, www.keatingofchicago.com. Refer to the Keating Top-Side ™ Cooker Limited Warranty for complete service and ...

Page 14 - COOKER CONTROL PANEL; Top View with Cover Removed

12 TOP-SIDE ™ COOKER CONTROL PANEL Figure 6-4 PART ITEM DESCRIPTION QTY. NUMBER 1 THERMOSTAT 1 056840 THERMOSTAT REPLACEMENT KIT FOR PRE 2005 MODELS 1 057138 2 HI-LIMIT CONTROL 1 010311 3 HI-LIMIT MOUNTING BRACKET 1 016654 4 CONTACTOR, 50A, 3 POLE 1 011184 5 ROCKER SWITCH, LIGHTED, ON/OFF 1 016689 6...

Page 15 - WIRING DIAGRAM

13 TOP-SIDE ™ COOKER POWER SUPPLY BOX FOR AUTO-LIFT ACTUATORS WITH DIGITAL TIMER - 120VAC SUPPLY Figure 6-5 PART ITEM DESCRIPTION QTY. NUMBER 1 TRANSFORMER STEPDOWN 24VAC 75VA 1 056037 2 RELAY DPDT 24VAC 1 030844 3 RECTIFIER 24VDC 1 018321 4 CIRCUIT BREAKER 3A 1 POLE 250V 1 053338 5 CORD POWER 6’ 1 ...

Page 17 - VII WIRING DIAGRAM; COOKER MANUAL LIFT WIRING DIAGRAM

15 VII WIRING DIAGRAM TOP-SIDE ™ COOKER MANUAL LIFT WIRING DIAGRAM Figure 6-7 LIGHTED ROCKER ON/OFF SWITCH GREEN LIGHT ON TOP LIGHTED ROCKER ON/OFF SWITCH GREEN LIGHT ON BOTTOM OR NOTE: ANGLED TERMINALS OF SWITCH ARE ALWAYS TOWARD CONTROL PANEL BOTTOM.

Page 18 - COOKER AUTO-LIFT WIRING DIAGRAM FOR GAS GRIDDLE

16 NOTES: 2. ALL OTHER WIRES ARE 18 AWG. 1. = 12 AWG WIRE. RD - RED GR - GREEN WIRE COLOR CODES: OR - ORANGE WH - WHITE BL - BLACK GY - GRAY BR - BROWN BU - BLUE COMPONENT CODES: CR - CONTACTOR 220/240VAC EO - “ELEMENT ON” LIGHT (RED) TB - TERMINAL BLOCK OF - “ON/OFF” SWITCH, LIGHTED (GREEN) TH - TH...

Page 19 - COOKER AUTO-LIFT WIRING DIAGRAM FOR ELECTRIC

17 TOP-SIDE ™ COOKER AUTO-LIFT WIRING DIAGRAM FOR ELECTRIC GRIDDLE 208 - 240VOLT Figure 6-9

Page 22 - SERVICE INFORMATION; Have your serial and model number available when ordering parts.; KEATING LIMITED WARRANTY CARD; “Serving Those Who Serve The Very Best”

20 SERVICE INFORMATION If you have a service related question call 1-800-KEATING. Please state the nature of the call; it will ensure speaking with the appropriate person. Have your serial and model number available when ordering parts. KEATING OF CHICAGO, INC. 8901 W. 50th Street, McCook, Illinois ...