Honeywell KA 54- Manuals

Page 2 - WARNING; COPYRIGHT NOTICE

WARNING The enclosed technical data is eligible for export under License Designation NLR and is to be used solely by the individual/organization to whom it is addressed. Diversion contrary to U.S. law is prohibited. COPYRIGHT NOTICE ©1997, 1999, 2001, 2003, 2005 Honeywell International Inc. REPRODUC...

Page 3 - KRA 405B RADAR ALTIMETER INSTALLATION MANUAL; REVISION HIGHLIGHTS

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page RH-1 006-10536-0010 Rev. 10 Oct/2005 REVISION HIGHLIGHTS 006-10536-0010 Rev. 10 Oct/2005 This is a full reprint of the KRA 405B Installation Manual. Discard the previous manual revision in its entirety. Specific changes to content are denoted by ch...

Page 5 - TABLE OF CONTENTS; ITEM; SECTION I

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page TC-1 006-10536-0010 Rev. 10 Oct/2005 TABLE OF CONTENTS ITEM PAGE SECTION I GENERAL INFORMATION 1.0 INTRODUCTION ............................................................... 1-1 1.1 DESCRIPTION OF EQUIPMENT ..........................................

Page 6 - SECTION III

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page TC-2 006-10536-0010 Rev. 10 Oct/2005 ITEM PAGE 2.4 CONFIGURABLE PARAMETERS .................................................... 2-2 A. ALTITUDE TRIP POINTS ....................................................... 2-2B. ZERO FEET OFFSET ................

Page 7 - TSO APPENDIX

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page TC-3 006-10536-0010 Rev. 10 Oct/2005 ITEM PAGE D. APPROACH ................................................................... 3-3E. PUSH-TO-TEST MODE .......................................................... 3-3 3.3 SELF-TEST DIAGNOSTICS ...........

Page 8 - THIS PAGE IS RESERVED

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page TC-4 006-10536-0010 Rev. 10 Oct/2005 THIS PAGE IS RESERVED

Page 23 - TABLE 1-2 CABLE INSTALLATIONS

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 1-11 006-10536-0010 Rev. 10 Oct/2005 E. KNI 415/416 INDICATOR INSTALLATION KIT P/N 050-01401-0002 which includes the following: F. KA 54A RADAR ALTIMETER ANTENNA INSTALLATION KIT P/N 050-02960-0000 which includes the following: *See TABLE 1-2 CABLE...

Page 25 - PARAMETERS

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 1-13 006-10536-0010 Rev. 10 Oct/2005 The CM 2000 allows the KRA 405B to operate with custom altitude trip points (rather than the factory preset values) and allows for an offset to the zero foot readout. Refer to section 2.4 CONFIGURABLE PARAMETERS...

Page 28 - ACCESSORIES SUPPLIED (KRA 405B SYSTEM COMPONENTS)

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-2 006-10536-0010 Rev. 10 Oct/2005 The installing agency will supply and fabricate all external cables. The connectors required for RG 393 (the preferred cable) are supplied by Honeywell. Installation kits are also available. Consult 1.4 UNITS AND...

Page 31 - FIGURE 2-3 KRA 405B ZERO POINT OFFSET

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-5 006-10536-0010 Rev. 10 Oct/2005 The KRA 405B has provisions to allow some flexibility in the altitude at which zero feet is displayed. This deviation would be useful for installations where a zero foot reading is desired before the landing gear...

Page 33 - FIGURE 2-6 KRA 405B INSTALLATION DRAWING

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-7 006-10536-0010 Rev. 10 Oct/2005 The selected mounting location will vary with each particular type of aircraft. The unit should be installed in a convenient location for accessibility for inspection and maintenance. The area should be free from...

Page 35 - TABLE 2-1 TSO CERTIFIED ANTENNAS

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-9 006-10536-0010 Rev. 10 Oct/2005 (3) Make certain that clearance is available between units so that normal vibration does not cause the unit to strike adjacent equipment cases. (4) Allow clearance behind the unit for installation of the cables a...

Page 36 - TABLE 1-2 CABLE INSTALLATIONS

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-10 006-10536-0010 Rev. 10 Oct/2005 The UB Corporation, Sensor Systems, Dorne and Margolin (EDO) and Comant Industries antennas can be purchased directly from the respective manufacturers at the following addresses: (1) UB Corporation 9829 Wilsky ...

Page 37 - TEM TYPICAL ANTENNA INSTALLATIONS

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-11 006-10536-0010 Rev. 10 Oct/2005 • Antennas should be pointing straight down within plus or minus 6 ° when the aircraft is in a level flight attitude. Antennas mounted more than 6 ° off the vertical will exhibit erratic op- eration on the groun...

Page 42 - FIGURE 2-4 KRA 405B POST INSTALLATION CALIBRATION SWITCH

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-16 006-10536-0010 Rev. 10 Oct/2005 FIGURE 2-4 KRA 405B POST INSTALLATION CALIBRATION SWITCH Verify proper on ground performance after the calibration is complete. For systems without a zero feet offset programmed into the configuration module, th...

Page 46 - 05B SYSTEM INSTALLATION

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-20 006-10536-0010 Rev. 10 Oct/2005 An antenna fault will be detected when its cable is ter- minated into a 50 ohm load and the indicator needle will stow behind the mask. Re-bond the antenna if the point- er is now stowed. If the indicator pointe...

Page 47 - 05B TEST EQUIPMENT SETUP

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-21 006-10536-0010 Rev. 10 Oct/2005 (3) Test Procedure a. Connect the test equipment as shown in FIGURE 2-15 KRA 405B TEST EQUIPMENT SETUP , replacing the antennas in the installation. b. Adjust the variable attenuator to 0 dBm (this setting yield...

Page 52 - FIGURE 2-6 KRA 405B INSTALLATION DRAWING

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-27 006-10536-0010 Rev. 10 Oct/2005 FIGURE 2-6 KRA 405B INSTALLATION DRAWING (Dwg No 155-06030-0000 R-0)

Page 55 - FIGURE 2-8 KA 54 ANTENNA OUTLINE AND MOUNTING DRAWING

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-33 006-10536-0010 Rev. 10 Oct/2005 FIGURE 2-8 KA 54 ANTENNA OUTLINE AND MOUNTING DRAWING DORNE MARGOLIN INC. TYPE DMPN 3-3/A, (Dwg No 155-05159-0000, R-1)

Page 59 - OUTLINE AND MOUNTING DRAWING

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-41 006-10536-0010 Rev. 10 Oct/2005 FIGURE 2-12 HONEYWELL GT 7003586 (SENSOR SYSTEMS TYPE S67-2002-4 ANTENNA) OUTLINE AND MOUNTING DRAWING

Page 61 - FIGURE 2-14 CONNECTOR PIN LOCATIONS

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-44 006-10536-0010 Rev. 10 Oct/2005 KRA 405B MATING CONNECTOR (P4051) P/N 030-02077-0000 KRA 415/416 MATING CONNECTOR (P4151/P4161) P/N 030-02210-0001 FIGURE 2-14 CONNECTOR PIN LOCATIONS

Page 62 - FIGURE 2-15 KRA 405B TEST EQUIPMENT SETUP

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-45 006-10536-0010 Rev. 10 Oct/2005 FIGURE 2-15 KRA 405B TEST EQUIPMENT SETUP

Page 63 - FIGURE 2-16 EXTERNAL SONALERT

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-46 006-10536-0010 Rev. 10 Oct/2005 FIGURE 2-16 EXTERNAL SONALERT (W/15 SECOND DH AUDIO FADER)

Page 64 - FIGURE 2-17 KRA 405B RADAR ALTIMETER SYSTEM INTERCONNECT

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-47 006-10536-0010 Rev. 10 Oct/2005 FIGURE 2-17 KRA 405B RADAR ALTIMETER SYSTEM INTERCONNECT (Dwg No 155-01645-0000, R-AD)

Page 65 - FIGURE 2-18 CM 2000 CONFIGURATION MODULE MOUNTING DRAWING

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 2-49 006-10536-0010 Rev. 10 Oct/2005 FIGURE 2-18 CM 2000 CONFIGURATION MODULE MOUNTING DRAWING (Dwg No 155-06016-0000, R-2)

Page 66 - KNI 415 CONTROL FUNCTIONS

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 3-1 006-10536-0010 Rev. 10 Oct/2005 SECTION III OPERATION 3.1 GENERAL The KNI 415 and KNI 416 Radar Altimeter Indicators are shown in FIGURE 3- 1 KNI 415 CONTROL FUNCTIONS and FIGURE 3-2 KNI 416 CONTROL FUNCTIONS and are discussed below. • Altitude...

Page 70 - FIGURE 3-1 KNI 415 CONTROL FUNCTIONS

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 3-5 006-10536-0010 Rev. 10 Oct/2005 FIGURE 3-1 KNI 415 CONTROL FUNCTIONS

Page 71 - FIGURE 3-2 KNI 416 CONTROL FUNCTIONS

N KRA 405B RADAR ALTIMETER INSTALLATION MANUAL Page 3-6 006-10536-0010 Rev. 10 Oct/2005 FIGURE 3-2 KNI 416 CONTROL FUNCTIONS