Honeywell HE360B - Manuals

HE360A,B POWERED FLOW-THROUGH HUMIDIFIER 7 69-1176—04 • Select a location that cannot damage the air conditioner A-coil during installation. • Do not locate the humidifier on the furnace body. • Allow adequate clearance in front of and above the humidifier so you can easily remove the cover to perfo...

Fig. 2. Selecting duct location for humidistat. Locating Closest 120V Electrical Outlet • Select location with access to an outlet. If not available, contact an electrician to have one installed. • Make sure that the humidifier cord is adequate to reach from the humidifier to the outlet. • Make sure...

HE360A,B POWERED FLOW-THROUGH HUMIDIFIER 9 69-1176—04 2. Make sure the humidifier housing is level, then position it in the opening so the plastic tabs are in place on the lower sheet metal edge of the opening. Use pli- ers, as necessary, to flatten cut edges. See Fig. 4. 3. Push in securing clips u...

HE360A,B POWERED FLOW-THROUGH HUMIDIFIER 69-1176—04 10 Connecting the Plumbing Use hot or cold water and either hard or softened water in the humidifier. 1. Shut off the water. CAUTION Chemical Hazard. Can cause personal injury or equipment damage. Do not use any line connected to an air conditioner...

HE360A,B POWERED FLOW-THROUGH HUMIDIFIER 69-1176—04 12 Fig. 7. Installing the drain tubing. Installing the Sail Switch Adapting Switch to Air Flow Direction The S688A Sail Switch has two counterbalancing springs in place as shown in Fig 8. These springs offset the effect of gravity for air flow dire...

HE360A,B POWERED FLOW-THROUGH HUMIDIFIER 13 69-1176—04 Fig. 8. Adapting sail switch to air flow direction or mounting position. • Vertical downward air flow: Leave the spring in place that is attached to the bracket marked Down. Remove the spring that is attached to the bracket marked Up. • Vertical...

HE360A,B POWERED FLOW-THROUGH HUMIDIFIER 15 69-1176—04 6. Secure the switch by using the sheet metal screws provided. 7. After wiring, snap on the cover. Installing the Humidistat Installing on Mounting Duct 1. Apply the template to the duct location chosen for the humidistat. Make sure the template...

HE360A,B POWERED FLOW-THROUGH HUMIDIFIER 69-1176—04 16 WIRING CAUTION Hazardous Voltage. Can cause personal injury or equipment damage. Disconnect power supply before installing or servicing equipment. IMPORTANT All wiring must comply with applicable local code, ordinances and regula- tions. Wire th...

HE360A,B POWERED FLOW-THROUGH HUMIDIFIER 17 69-1176—04 TESTING HUMIDIFIER OPERATION Checklist ‰ Humidifier is level. ‰ Control wiring was reviewed using circuit diagram. ‰ Humidifier is plugged in. ‰ Feed line has no kinks. ‰ Drain line slopes continuously down and ends at floor drain. ‰ Water hose ...

HE360A,B POWERED FLOW-THROUGH HUMIDIFIER 19 69-1176—04 MAINTAINING YOUR HUMIDIFIER A regular maintenance program prolongs the life of your humidifier and makes your home more comfortable. The frequency of cleaning depends on the condition of your water. You can use either hard or soft water in your ...

TROUBLESHOOTING YOUR HUMIDIFIER Table 3. Troubleshooting Humidifier Problem What to look for What to do Water leakage Leaking joints. Shut off water. Tighten connections. Brass tubing inserts Verify that brass tubing inserts are used. Saddle valve leaking. Verify rubber gasket is installed on saddle...

HE360A,B POWERED FLOW-THROUGH HUMIDIFIER Automation and Control Solutions Honeywell International Inc. Honeywell Limited-Honeywell Limitée1985 Douglas Drive North 35 Dynamic Drive Golden Valley, MN 55422 Toronto, Ontario M1V 4Z9 yourhome.honeywell.com ® U.S. Registered Trademark© 2009 Honeywell Inte...