Henny Penny DCW-2 - Manuals

Page 3 - LIMITED WARRANTY FOR HENNY PENNY EQUIPMENT

LIMITED WARRANTY FOR HENNY PENNY EQUIPMENT Subject to the following conditions, Henny Penny Corporation makes the following limited warranties to the original purchaser only for Henny Penny appliances and replacement parts: NEW EQUIPMENT: Any part of a new appliance, except baskets, lamps, and fuses...

Page 4 - Proper

TABLE OF CONTENTS Section P a g e Section 1. INTRODUCTION ........................................................................................................ 1 1-1. Heated Display Cabinet ...................................................................................... 1 1-2. Features........

Page 5 - SECTION 1. INTRODUCTION; CABINET

SECTION 1. INTRODUCTION 1-1. HEATED DISPLAY The Henny Penny Heated Display Cabinet is a basic unit of food CABINET processing equipment used to display the food product and maintain the temperature of hot foods in the commercial food service operation. This highly efficient, quality-built cabinet wi...

Page 6 - The word WARNING is used to alert you to a

CAUTION used without the safety alert symbol indicates a potentially hazardous situation which, if not avoided, may result in property damage. CAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury. The word WARNING is used to alert you to a...

Page 7 - SECTION 2. INSTALLATION; Do not puncture the skin of the unit with drills or

SECTION 2. INSTALLATION 2-1. INTRODUCTION This section provides the installation instructions for the Henny Penny Heated Display Cabinet. Installation of this unit should be performed only by a qualified service technician. Do not puncture the skin of the unit with drills or screws as component dama...

Page 8 - The unit is now ready for location and set-up.

2-2. UNPACKING (Continued) Step 2 2. Open top flaps and remove packing. Step 3 3. Lift carton off skid. Step 4 4. Remove four bolts from under skid. The unit is now ready for location and set-up. 4

Page 11 - SECTION 3. OPERATING INSTRUCTIONS; cabinets. The Introduction, Installation and Operation sections

SECTION 3. OPERATING INSTRUCTIONS 3-1. INTRODUCTION This section provides operating procedures for the heated display cabinets. The Introduction, Installation and Operation sections should be read, and all instructions should be followed before operating the cabinet. 3-2. OPERATING CONTROLS Figures ...

Page 15 - CLEANUP; Do not use steel wool, other abrasive cleaners or

3-5. SHUT-DOWN AND CLEANUP 1. Turn the radiant heat to OFF 2. Open the doors. 3. Remove all the pans. 4. Remove the grids from the lower level and clean with soap and water at sink. Do not use steel wool, other abrasive cleaners or cleaners/sanitizers containing chlorine, bromine, iodine or ammonia ...

Page 16 - SECTION 4. TROUBLESHOOTING; TROUBLESHOOTING GUIDE

SECTION 4. TROUBLESHOOTING 4-1. TROUBLESHOOTING GUIDE PROBLEM CAUSE CORRECTION Product not holding z Doors are not kept closed z Product held too long z Temperature too low z Radiant heat too low z Light bulbs out z Keep doors closed when holding possible z Only hold product for recommended times z ...

Page 17 - G L O S S A R Y

G L O S S A R Y HENNY PENNY HOLDING CABINETS air temperature probe a round device located inside the cabinet that measures the inside air temperature and sends that information to the control panel concentration ring assembly a metal assembly located in the water pan in the bottom of the unit that h...