Henny Penny CBC/CBR-105 - Manuals

Page 2 - LIMITED WARRANTY FOR HENNY PENNY APPLIANCES; EXTENDED FRYPOT WARRANTY:

Model CBC/CBR-103,104,105,106,107 LIMITED WARRANTY FOR HENNY PENNY APPLIANCES Subject to the following conditions, Henny Penny Corporation makes the following limited warranties to the original purchaser only for Henny Penny appliances and replacement parts: NEW EQUIPMENT: Any part of a new applianc...

Page 3 - TABLE OF CONTENTS; Section

Model CBC/CBR-103,104,105,106,107 TABLE OF CONTENTS Section Page Section 1. INTRODUCTION ................................................................................................................... 1-1 1-1. Henny Penny Cold Bases ..................................................................

Page 4 - SECTION 1. INTRODUCTION

Model CBC/CBR-103,104,105,106,107 1-1. COLD BASES The Henny Penny cold bases are self-serve units, designed to holdchilled, or refrigerated products. The units are electronicallycontrolled for easy use and for consistent operation. 1-2. FEATURES • Can be matched with hot or cold merchandisers in all...

Page 5 - NOTICE is used to highlight especially important information.

Model CBC/CBR-103,104,105,106,107 1-5. SAFETY The Henny Penny cold bases have many safety featuresincorporated. However, the only way to ensure a safe operationis to fully understand the proper installation, operation, andmaintenance procedures. The instructions in this manual havebeen prepared to a...

Page 6 - SECTION 2. INSTALLATION

Model CBC/CBR-103,104,105,106,107 2-1. INTRODUCTION This section provides the installation and unpacking instructions forthe Henny Penny cold bases. Installation of this unit should be performed only by aqualified service technician. Do not puncture the unit with any objects such asdrills or screws,...

Page 7 - Volts

Model CBC/CBR-103,104,105,106,107 2-2. UNPACKING Take care when moving the unit to prevent personalinjury or damage to the refrigeration system. The unitsweigh between 400 (182 kg) and 580 lbs. (263 kg). 4. Peel off any protective covering from exterior of the cabinet. 5. Install the grids into unit...

Page 8 - INFORMATION; High Low; UL Specs; Refrigerant Type Amount of Refrig. Design Pressure

Model CBC/CBR-103,104,105,106,107 303 2-3 2-4. LOCATION Place the cold bases in an area where product can be loaded andunloaded without interruption. For proper operation, level the unitby adjusting the bolts under the base, and leave 3 feet (91.44 cm)clearance behind the unit for ventilation and se...

Page 9 - AND LOAD; CBR MODELS; DRAIN & REFRIGERATION CONNECTIONS

Model CBC/CBR-103,104,105,106,107 2-7. COMPRESSOR SIZE AND LOAD 2-8. FOOT PRINT DRAWING CBR MODELS DRAIN & REFRIGERATION CONNECTIONS 2-4 403 Model CBC Motor HP CBR Motor HP CBC/ BTU Load UL CE UL CE CBR R-22 R-134a R-22 R-134a 103 2830 1/3 1/2 Remote 104 2830 1/3 1/2 Compressor 105 3840 1/2 1/2 ...

Page 10 - AND LAMP REPLACEMENT; Model; UL Units; Install new fluorescent bulb in reverse order.; CE Units; Install new fluorescent lamp in reverse order.

Model CBC/CBR-103,104,105,106,107 2-9. FLUORESCENT LIGHTING No. AND LAMP REPLACEMENT Model of Lights Size CBR/CBC-103 1 36 in. (.914 m) CBR/CBC-104 1 48 in. (1.22 m) CBR/CBC-105 1 24 in. (.610 m) 1 36 in. (.914 m) CBR/CBC-106 2 36 in. (.914 m) CBR/CBC-107 1 36 in. (.914 m) 1 48 in. (1.22 m) UL Units...

Page 12 - SECTION 3. OPERATION

Model CBC/CBR-103,104,105,106,107 3-1. INTRODUCTION This section provides explanations of all controls, alongwith operating procedures and daily maintenance. Read theIntroduction, Installation and Operation Sections beforeoperating the unit. Wait at least 4 hours before plugging the unit into anelec...

Page 18 - DIAGRAM FOR CBC MODEL

Model CBC/CBR-103,104,105,106,107 3-7 303 DIAGRAM FOR CBC MODEL

Page 19 - DIAGRAM FOR CBR MODEL

Model CBC/CBR-103,104,105,106,107 DIAGRAM FOR CBR MODEL 303 3-8

Page 21 - Filter Drier; Plastic Protector-Fluorescent Light - 48”; recommended parts; RECOMMENDED PARTS LIST

Model CBC/CBR-103,104,105,106,107 Item Part Quantity N o . N o . Description 1 0 3 1 0 4 1 0 5 1 0 6 1 0 7 1 23969 Refrigeration/Condensing unit 1/3 HP - CBC-103/104-UL 1 1 - - - 1 23968 Refrigeration/Condensing unit 1/2 HP - CBC-103/104-CE - - 1 1 1 1 23968 Refrigeration/Condensing unit 1/2 HP - CB...