Chicago Electric 97677 - Manuals

Page 2 - SAVE ThIS MAnUAL; IMPORTAnT SAFETY; General Safety Rules; Cluttered or dark areas invite; DAnGER; Notice; CAUTIOn

Page 2 SKU 97677 For technical questions, please call 1-800-444-3353. SAVE ThIS MAnUAL K e e p t h i s m a n u a l f o r t h e s a f e t y warnings and precautions, assembly, operating, inspection, maintenance and cleaning procedures. Write the product’s serial number in the back of the manual near ...

Page 3 - Personal safety; tired or under the influence of drugs,; Power tool use and care

Page 3 SKU 97677 For technical questions, please call 1-800-444-3353. outlets will reduce risk of electric shock. Avoid body contact with grounded b. surfaces such as pipes, radiators, ranges and refrigerators. There is an increased risk of electric shock if your body is grounded. Do not expose powe...

Page 4 - Service; Specific Safety Rules

Page 4 SKU 97677 For technical questions, please call 1-800-444-3353. power tool’s operation. If damaged, have the power tool repaired before use. Many accidents are caused by poorly maintained power tools. Use the power tool and its f. accessories in accordance with these instructions and in the ma...

Page 5 - SAVE ThESE; GROUnDInG; Grounded Tools: Tools with Three; WARnInG

Page 5 SKU 97677 For technical questions, please call 1-800-444-3353. activities, contains chemicals known [to the State of California] to cause cancer, birth defects or other reproductive harm. Some examples of these chemicals are: • Lead from lead-based paints • Crystalline silica from bricks and ...

Page 6 - Outlets for 2-Prong Plug; system which satisfies OSHA; Extension Cords; Grounded

Page 6 SKU 97677 For technical questions, please call 1-800-444-3353. of electric shock. (See 3-Prong Plug and Outlet.) The grounding prong in the plug is 2. connected through the green wire inside the cord to the grounding system in the tool. The green wire in the cord must be the only wire connect...

Page 7 - Symbology; SPECIFICATIOnS

Page 7 SKU 97677 For technical questions, please call 1-800-444-3353. Protect the extension cords from 8. sharp objects, excessive heat, and damp or wet areas. RECOMMEnDED MInIMUM WIRE GAUGE FOR EXTEnSIOn CORDS* (120/240 VOLT) nAMEPLATE AMPERES (at full load) EXTEnSIOn CORD LEnGTh 25’ 50’ 75’ 100’ 1...

Page 8 - Product Features; For additional information on the Product; Assembly Diagram; near the end of this manual.; FIGURE A

Page 8 SKU 97677 For technical questions, please call 1-800-444-3353. Product Features See Figure A. 1. Suction hose (50). a. Telescopic Suction Tube (82). b. Drain hose (29). c. Upper handle (18). d. Switch knob (80). e. Upper Cover (9). f. handle Pipe (19) g. Lower handle (20). h. Intake Port (49)...

Page 9 - General Operation Instructions; “On”; Adjust the air flow rate of the Vacuum; “OFF”

Page 9 SKU 97677 For technical questions, please call 1-800-444-3353. General Operation Instructions Dry Vacuuming: Unlock the Right Latch (34) and Left 1. Latch (59). Then remove the Upper Cover (9). (See Figure A, and Assy. Diagram.) If using the Cartridge Filter (54), 2. remove the Filter Cover (...

Page 10 - Foam Filter must be flush with the

Page 10 SKU 97677 For technical questions, please call 1-800-444-3353. Wet Vacuuming: Unlock the Right Latch (34) and Left 1. Latch (59). Then remove the Upper Cover (9). (See Figure A, and Assy. Diagram.) Snap the Foam Filter (85) over 2. the Filter Cage (84). nOTE: The Foam Filter must be flush wi...

Page 11 - Lubrication

Page 11 SKU 97677 For technical questions, please call 1-800-444-3353. MAInTEnAnCE AnD SERVICInG Procedures not specifically explained in this manual must be performed only by a qualified technician. TO PREVEnT SERIOUS InjURY FROM ACCIDEnTAL OPERATIOn: Turn the Power Switch knob (80) of the Wet/Dry ...

Page 12 - TROUBLEShOOTInG; Problem; Disconnect power supply before service.; PLEASE READ ThE FOLLOWInG CAREFULLY

Page 12 SKU 97677 For technical questions, please call 1-800-444-3353. TROUBLEShOOTInG Problem Possible Causes Likely Solutions Vacuum will not start. No power at outlet. 1. Cord not connected. 2. On/Off switch is not turned On. 3. Check power at outlet. 1. Check that cord is plugged in. 2. Turn On ...

Page 13 - PARTS LIST

Page 13 SKU 97677 For technical questions, please call 1-800-444-3353. Part # Description Qty. Part # Description Qty. 1 Decorative Cover 1 45 Caster (55mm) 2 2A Screw (ST4.2x16-F) 24 46 Base 1 3 Upper Cover Pressing Plate 2 47 Intake Bracket 1 4A Screw (ST3.5x16-F) 3 48 Intake Seal 1 5A Screw (ST2....

Page 14 - ASSEMBLY DIAGRAM

Page 14 SKU 97677 For technical questions, please call 1-800-444-3353. ASSEMBLY DIAGRAM REV 10c For the following parts, see page 8, Figure A: Telescopic Suction Tube (82) Wet & Dry Brush (83) Filter Cage (84) Foam Filter (85) Crevice nozzle (86) Furniture Brush (87) Dust Bag (88) Suction hose (...

Page 15 - LIMITED 1 YEAR / 90 DAY WARRAnTY; WARRANTy IS ExPRESSLy IN LIEU OF ALL OTHER WARRANTIES, ExPRESS OR

Page 15 SKU 97677 For technical questions, please call 1-800-444-3353. LIMITED 1 YEAR / 90 DAY WARRAnTY Harbor Freight Tools Co. makes every effort to assure that its products meet high quality and durability standards, and warrants to the original purchaser that for a period of ninety days from dat...